Skip to main content
Log in

Synthesis, Luminescence and Thermal Properties of PVA–ZnO–Al2O3 Composite Films: Towards Fabrication of Sunlight-Induced Catalyst for Organic Dye Removal

  • Original Paper
  • Published:
Journal of Polymers and the Environment Aims and scope Submit manuscript

Abstract

Poly(vinyl alcohol) (PVA)–ZnO–Al2O3 composite films have been prepared by the addition of different compositions of ZnO and Al2O3 through solvent casting method. Fourier transform infrared spectroscopy (FTIR), ultraviolet–visible spectroscopy (UV–Vis) and photoluminescence spectroscopy (PL) spectra revealed the successful incorporation of ZnO and Al2O3 onto PVA and interactions among ZnO, Al2O3 and PVA molecules. PL data indeed showed the enhanced luminescence property of composite films compared with the PVA. Thermogravimetric analysis (TGA) data showed that thermal stability of PVA–ZnO–Al2O3 composite films could be greatly improved by the incorporation of ZnO and Al2O3 into the system. The glass transition temperature (Tg) were increased for the composite samples using ZnO and Al2O3. Differential scanning calorimetry (DSC) measurements revealed that the melting temperature (Tm) of PVA–ZnO–Al2Ocomposite films are significantly higher (~ 12 to 25 °C) than PVA. The photocatalytic measurements exhibited better photocatalytic degradation ability of PVA–ZnO–Al2O3 composites over PVA. Such photocatalytic capacity makes the PVA–ZnO–Al2O3 composite films promising candidates for the removal of organic dyes for water purification.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7

Similar content being viewed by others

References

  1. Zhang X-J, Wang G-S, Wei Y-Z, Guo L, Cao M-S (2013) Polymer-composite with high dielectric constant and enhanced absorption properties based on graphene–CuS nanocomposites and polyvinylidene fluoride. J Mater Chem A 1:12115–12122

    Article  CAS  Google Scholar 

  2. Rao Y, Wong CP (2004) Material characterization of a high-dielectric-constant polymer–ceramic composite for embedded capacitor for RF applications. J Appl Polym Sci 92:2228–2231

    Article  CAS  Google Scholar 

  3. Rao Y, Ogitani S, Kohl P, Wong CP (2002) Novel polymer–ceramic nanocomposite based on high dielectric constant epoxy formula for embedded capacitor application. J Appl Polym Sci 83:1084–1090

    Article  CAS  Google Scholar 

  4. Kundachira Subramani N(2015) Opto-electrical characteristics of poly(vinyl alcohol)/cesium zincate nanodielectrics. J Phys Chem C 119(35):20244–20255

    Article  CAS  Google Scholar 

  5. Suma GR, Subramani NK, Sachhidananda S, Satyanarayana SV, Siddaramaiah (2017) J Mater Sci: Mater Electron. https://doi.org/10.1007/s10854-017-7148-3

    Article  Google Scholar 

  6. Singhal A, Kaur M, Dubey KA, Bhardwaj YK, Jain D, Pillai CGS, Tyagi AK (2012) Polyvinyl alcohol–In2O3 nanocomposite films: synthesis, characterization and gas sensing properties. RSC Adv 2:7180–7189

    Article  CAS  Google Scholar 

  7. Jia YT, Gong J, Gu XH, Kim HY, Dong J, Shen XY (2007) Fabrication and characterization of poly (vinyl alcohol)/chitosan blend nanofibers produced by electrospinning method. Carbohydr Polym 67:403–409

    Article  CAS  Google Scholar 

  8. Jung G, Kim H-II (2014) Synthesis and photocatalytic performance of PVA/TiO2 graphene-MWCNT nanocomposites for dye removal. J Appl Polym Sci 40715:1–7. https://doi.org/10.1002/APP.40715

    Article  Google Scholar 

  9. Shilpa KN, Subramani NK, Sachhidanand S, Madhukar BS, Siddaramaiah (2016) Visibly transparent PVA/sodium doped dysprosia (Na2Dy2O4) nano composite films, with high refractive index: an optical study. J Alloys Compd 694:884–891

    Article  CAS  Google Scholar 

  10. Kumar RV, Koltypin Y, Cohen YS, Aurbach D, Palchik O, Felner I, Gedanken A (2000) Preparation of amorphous magnetite nanoparticles embedded in polyvinyl alcohol using ultrasound radiation. J Mater Chem 10:1125–1129

    Article  CAS  Google Scholar 

  11. Qian XF, Jin J, Huang JC, Yang YF, Guo XX, Zhu ZK (2001) The preparation and characterization of PVA/Ag2S nanocomposite. Mater Chem Phys 68:95–97

    Article  CAS  Google Scholar 

  12. Lagashetty A, basavaraj S, Bedre M, Venkatarman A (2009) Metal oxides dispersed polyvinyl alcohol nanocomposites. J Metall Mater Sci 51:297–306

    CAS  Google Scholar 

  13. Dey KK, Kumar P, Yadav RR, Dhar A, Srivastava AK (2014) CuO nanoellipsoids for superior physicochemical response of biodegradable PVA. RSC Adv 4:10123–10132

    Article  CAS  Google Scholar 

  14. Karthikeyan K, Poornaprakash N, Selvakumar N, Jeyasubrmanian K (2009) Thermal properties and morphology of MgO-PVA nanocomposite film. J Nanostruct Polym Nanocompd 5:83–88

    Google Scholar 

  15. Nakhaei O, Shahtahmassebi N, Rezaeeroknabadi M, Mohagheghi MMB (2012) Synthesis, characterization and study of optical properties of polyvinyl alcohol/CaF2 nanocomposite films. Sci Iranica 19:1979–1983

    Article  Google Scholar 

  16. Anbuvannan M, Ramesh M, Viruthagiri G (2015) Synthesis, characterization and photocatalytic activity of ZnO nanoparticles prepared by biological method. Spectrochim Acta A. https://doi.org/10.1016/j.saa.2015.01.124

    Article  Google Scholar 

  17. Pathania D, Katwal R, Kaur H (2016) Enhanced photocatalytic activity of electrochemically synthesized aluminum oxide nanoparticles. Int J Miner Metall Mater 23:358–371

    Article  CAS  Google Scholar 

  18. Khodja AA, Sehili T, Pilichowski J-F, Boule P (2001) Photocatalytic degradation of 2-phenylphenol on TiO2 and ZnO in aqueous suspensions. J Photochem Photobiol A 141:231–239

    Article  CAS  Google Scholar 

  19. Umadevi M, Christy AJ (2013) Synthesis, characterization and photocatalytic activity of CuO nanoflowers. Spectrochim Acta A 109:133–137

    Article  CAS  Google Scholar 

  20. Valenzuela MA, Bosch P, Jiménez-Becerrill J, Quiroz O, Páez AI (2002) Preparation, characterization and photocatalytic activity of ZnO, Fe2O3 and ZnFe2O4. J Photochem Photobiol A 148:177–182

    Article  CAS  Google Scholar 

  21. Fernandes DM, Hechenleitner AW, Lima SM, Andrade LH, Caires AR, Pineda EG (2011) Preparation, characterization, and photoluminescence study of PVA/ZnO nanocomposite films. Mater Chem Phys 128:371–376

    Article  CAS  Google Scholar 

  22. Aga Mu (2010) Doping of polymers with zno nanostructures for optoelectronic and sensor applications. Nanowires Science and Technology. Intech, Rijeka

    Google Scholar 

  23. Sugumaran S, Bellan CS, Nadimuthu M (2015) Characterization of composite PVA–Al2O3 thin films prepared by dip coating method. Iran Polym J 24:63–74

    Article  CAS  Google Scholar 

  24. Samzadeh-Kermani A, Mirzaee M, Ghaffari-Moghaddam M (2016)Polyvinyl alcohol/polyaniline/ZnO nanocomposite: synthesis, characterization and bactericidal property. Adv Biol Chem 6:1–11

    Article  CAS  Google Scholar 

  25. Subramani NK, Shilpa KN, Shivanna S, Siddaramaiah H (2016) Highly flexible and visibly transparent poly(vinyl alcohol)/calcium zincate nanocomposite films for UVA shielding applications as assessed by novel ultraviolet photon induced fluorescence quenching. Macromolecules 49(7):2791–2801

    Article  CAS  Google Scholar 

  26. Sakthivel S, Nepolian B, Shankar MV, Palanichamy M, Arabindoo B, Murugesan V (2003) Solar photocatalytic degradation of azo dye: comparison of photocatalytic efficiency of ZnO and TiO2. Energy Mater Sol Cells 77:65–82

    Article  CAS  Google Scholar 

  27. Qunitana M, Ricra E, Rodriguez J, Estrada W (2002) Spray pyrolysis deposited zinc oxide films for photo-electrocatalytic degradation of methyl orange: influence of the pH. Catal Today 76:141–148

    Article  Google Scholar 

  28. Anderson C, Bard AJ (1997) Improved photocatalytic activity and characterization of mixed TiO2/SiO2 and TiO2/Al2O3 materials. J Phys Chem B 101:2611–2616

    Article  CAS  Google Scholar 

  29. Reddy DA, Lee S, Choi J, Park S, Ma R, Yang H, Kim TK (2015) Green synthesis of AgI-reduced graphene oxide nanocomposites: toward enhanced visible-light photocatalytic activity for organic dye removal. Appl Surf Sci 341:175–184

    Article  CAS  Google Scholar 

  30. Akhter S, Allan K, Buchanan D, Cook JA, Campion A, White JM (1988) XPS and IR study of X-ray induced degradation of PVA polymer film. Appl Surf Sci 35:241–258

    Article  CAS  Google Scholar 

  31. Jiang L, Shen XP, Wu JL, Shen KC (2010) Preparation and characterization of graphene/poly(Vinylalcohol) nanocomposites. J Appl Polym Sci 118:275–279

    Article  CAS  Google Scholar 

  32. Kazeminezhad I, Sadollahkhani A, Farbod M (2013) Synthesis of ZnO nanoparticles and flower-like nanostructures using nonsono-and sono-electrooxidation methods. Mater Lett 92:29–32

    Article  CAS  Google Scholar 

  33. Varghese N, Hariharan M, Cherian AB, Sreenivasan PV, Paul J, Antony AK A (2014) PVA-assisted synthesis and characterization of nano α-alumina. Int J Sci Res Publ 4:1–5

    Google Scholar 

  34. Rao NR (1967) Ultraviolet and visible spectroscopy. Chemical applications, Butterworth, London

    Google Scholar 

  35. Jayasekaro R, Harding I, Bowater I, Christie GBY, Lonergan GT (2004) Preparation, surface modification and characterisation of solution cast starch PVA blended films. Polym Test 23:17–27

    Article  CAS  Google Scholar 

  36. Segets D, Gradl J, Taylor RK, Vassilev V, Peukert W (2009) Analysis of optical absorbance spectra for the dDetermination of ZnO nanoparticle size distribution, solubility, and surface energy. ACS Nano 3(7):1703–1710

    Article  CAS  PubMed  Google Scholar 

  37. Prashanth PA, Raveendra RS, Hari Krishna R, Ananda S, Bhagya NP, Nagabhushana BM, Lingaraju K, Raja Naika H (2015) J Asian Ceram Soc. https://doi.org/10.1016/j.jascer.2015.07.001

    Article  Google Scholar 

  38. Zak AK, Razali R, Majid WHA, Darroudi M (2011) Synthesis and characterization of a narrow size distribution of zinc oxide nanoparticles. Int J Nanomed 6:1399–1403

    Google Scholar 

  39. Bu Y, Chen Z, Li W, Hou B (2013) Highly efficient photocatalytic performance of Graphene–ZnO quasi-shell-core composite material. ACS Appl Mater Interface 5:12361–12368

    Article  CAS  Google Scholar 

  40. Djurišić AB, Leung YH, Tam KH, Ding L, Ge WK, Chen HY, Gwo S (2006) Green, yellow, and orange defect emission from ZnO nanostructures: Influence of excitation wavelength. Appl Phys Lett 88:103107

    Article  CAS  Google Scholar 

  41. Zhou J, Sun G, Zhao H, Pan X, Zhang Z, Fu Y, Mao Y, Xie E (2015) Tunable white light emission by variation of composition andde fects of electrospun Al2O3–SiO2 nanofibers. Beilstein J Nanotechnol 6:313–320

    Article  CAS  PubMed  PubMed Central  Google Scholar 

  42. Chaaya AA, Viter R, Baleviciute I, Bechelany M, Ramanavicius A, Gertnere Z, Erts D, Smyntyna V, Miele P (2014) Tuning optical properties of Al2O3/ZnO nanolaminates snthesized by atomic layer deposition. J Phys Chem C 118:3811–3819

    Article  CAS  Google Scholar 

  43. Zou JP, Rendu PL, Musa I, Yang SH, Dan Y, That CT, Nguyen TP (2011) Investigation of the optical properties of polyfluorene/ZnO nanocomposites. Thin Solid Films 519:3997–4003

    Article  CAS  Google Scholar 

  44. Budrugeac P (2008) Kinetics of the complex process of thermo-oxidative degradation of poly(vinyl alcohol). J Therm Anal Calorim 92:291–296

    Article  CAS  Google Scholar 

  45. Gilman JW, Van der Hart DL, Kashiwagi T (1994) Fire and polymers II: materials and test for hazard prevention, American Chemical Society, ACS Symposium Series 599, August 21–26, Washington, DC

  46. Singh R, Kulkarni SG, Naik NH (2013) Effect of nano sized transition metal salts and metals on thermal decomposition behavior of polyvinyl alcohol. Adv Mater Lett 4:82–88

    Article  CAS  Google Scholar 

  47. Leszczynska A, Njuguna J, Pielichowski K, Banerjee JR (2007) Polymer/montmorillonite nanocomposites with improved thermal properties: Part I. Factors influencing thermal stability and mechanisms of thermal stability improvement. Thermochim Acta 453:75–96

    Article  CAS  Google Scholar 

  48. Rahman Khan MM, Wee YK, Mahmood WAK (2014) Effect of CuO on the thermal stability of polyaniline nanofibers. Int J Chem React Eng 12:1–7

    Google Scholar 

  49. Lee J, Bhattacharyya D, Easteal AJ, Metson JB (2008) Properties of nano-ZnO/poly(vinyl alcohol)/poly(ethylene oxide) composite thin films. Curr Appl Phys 8:42

    Article  Google Scholar 

  50. Radosavljević A, Božanić D, Bibić N, Mitrić M, Popovic ZK, Nedeljković J (2012) Characterization of poly(vinyl alcohol)/gold nanocomposites obtained by in situ gamma-irradiation method. J Appl Polym Sci 125:1244–1251

    Article  CAS  Google Scholar 

  51. Peresin MS, Habibi Y, Zoppe JO, Pawlak JJ, Rojas OJ (2010) Nanofiber composites of polyvinyl alcohol and cellulose nanocrystals: manufacture and characterization. Biomacromolecules 11:674–681

    Article  CAS  PubMed  Google Scholar 

  52. Guo Z, Zhang D, Wei S, Wang Z, Karki AB, Li Y, Bernazzani P, Young DP, Gomes JA, Cocke DL, Ho TC (2010) Effects of iron oxide nanoparticles on polyvinyl alcohol: interfacial layer and bulk nanocomposites thin film. J Nanopart Res 12:2415–2426

    Article  CAS  Google Scholar 

  53. Chandrakala HN, Ramaraj B, Shivakumaraiah, Madhu GM, Siddaramaiah (2012) The influence of zinc oxide–cerium oxide nanoparticles on the structural characteristics and electrical properties of polyvinyl alcohol films. J Mater Sci 47:8076–8084

    Article  CAS  Google Scholar 

  54. Soltani N, Saioni E, Yunus WMM, Navasery M, Bahmanrokh G, Erfania M, Reza Zare M, Gharibshahi E (2013) Photocatalytic degradation of methylene blue under visible light using PVP-capped ZnS and CdS nanoparticles. Sol Energy 97:147–154

    Article  CAS  Google Scholar 

Download references

Acknowledgements

The authors gratefully acknowledge Organic and Materials Chemistry Laboratory of the Chemistry Department, SUST for supporting experimental works.

Author information

Authors and Affiliations

Authors

Corresponding author

Correspondence to Mohammad Mizanur Rahman Khan.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Rahman Khan, M.M., Akter, M., Amin, M.K. et al. Synthesis, Luminescence and Thermal Properties of PVA–ZnO–Al2O3 Composite Films: Towards Fabrication of Sunlight-Induced Catalyst for Organic Dye Removal. J Polym Environ 26, 3371–3381 (2018). https://doi.org/10.1007/s10924-018-1220-9

Download citation

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s10924-018-1220-9

Keywords

Navigation