An experimental and theoretical study of the combustion of granulated charges consisting of pyroxylin powders in a manometric bomb of constant volume is presented. A comparison was made of the experimentally measured dependence of pressure increase in a manometric bomb with calculations according to thermodynamic model of combustion of a gunpowder sample in a manometric bomb using the empirical law of the dependence of the burning rate on pressure and a conjugate model of unsteady combustion of gunpowder. The unsteady rate of burning of pyroxylin powder, due to the high rate of pressure growth in the manometric bomb, differs from the quasi-stationary speed. This difference depends on the rate of pressure growth and on its absolute value and decreases with increasing pressure.
Similar content being viewed by others
References
M. E. Serebryakov, Interior Ballistics of Barrel Systems and Powder Rockets [in Russian], Oborongiz, Moscow (1962).
V. V. Burkin, A. S. D’yachkovskii, A. N. Ishchenko, V. Z. Kasimov, K. S. Rogaev, and N. M. Samorokova, Combustion of pastelike fuel in case of different charging schemes, Vestn. Tomsk. Gos. Univ., Mat. Mekh., No. 67, 89–101 (2020).
K. Ikuta, Two stage travelling charge accelerator for high velocity, Sci. Technol. Energy, 65, No. 1, 25–27 (2004).
M. S. Baryshev, V. A. Burakov, A. N. Ishchenko, N. M. Samorokova, and Yu. P. Khomenko, Refining the Combustion Law of DRP Based on the Results of Manometric Tests [in Russian], Nzd. RFYaTs-VNIIEF, Sarov, 2, 1007–1013 (2010).
B. S. Ermolaev, A. A. Sulimov, and A. V. Roman’kov, An attached high-density charge of convective combustion in a combined scheme of the shot: New results, Gor. Vzryv, No. 6, 206−210 (2013).
A. M. Lipanov and I. G. Rusyak, Investigation of the conjugate heat and mass transfer at ignition and subsequent nonstationary erosion combustion of powders under conditions close to those of fi ring a shot, J. Eng. Phys. Thermophys., 89, No. 6, 1527–1537 (2016).
Yu. P. Khomenko, A. N. Ishchenko, and N. M. Samorokova, Intergrodifferential method of determining the laws of the rates of combustion of condensed systems under constant volume conditions, Fiz. Goreniya Vzryva, 35, No. 1, 67–71 (1999).
Yu. P. Khomenko, A. N. Ishchenko, V. Z. Kasimov, N. M. Samorokova, and V. M. Shirokov, Identification of laws of combustion and gas formation of propellant charges based on ballistic and manometric tests, in: Modern Methods for Designing Rocket and Artillery Weapons [in Russian], VNIIEF, Sarov (2000), pp. 223–229.
A. N. Ishchenko and V. Z. Kasimov, Mathematical Model and Software Package for Theoretical Research of Intraballistic Processes in Barrel Systems, Textbook [in Russian], Izd. Dom Tomsk. Gos. Univ., Tomsk (2015).
Yu. P. Khomenko, A. N. Ishchenko, and V. Z. Kasimov, Mathematical Simulation of Intraballistic Processes in Barrel Systems [in Russian], Izd. SO RAN, Novosibirsk (1999).
V. V. Burkin, A. S. D’yachkovskii, A. N. Ishchenko, L. V. Korol’kov, K. S. Rogaev, A. Yu. Sammel’, E. Yu. Stepanov, and A. V. Chupashev, Information measuring complex of the Scientific Research Institute of Appl. Math. Mech. TSU, Collection of papers of the Int. Youth Sci. Conf. “Current Problems of Modern Continuum Mechanics and Celestial Mechanics,” November 17–19, 2014, Tomsk, TSU (2014), pp. 127–128.
V. V. Burlov, V. V. Grabin, A. Yu. Kozlov, et al., Ballistics of Barrel Systems (L. N. Lysenko and A. M. Lipanov Eds.), (Research Developer Reference Library), Russian Academy of Missile and Artillery Sciences, Mashinostroenie, Moscow (2006).
V. M. Ushakov and I. G. Rusyak, Intrachamber Heterogeneous Processes in Barrel Systems [in Russian], UrO RAN, Ekaterinburg (2001).
I. G. Rusyak, A. M. Lipanov, and V. M. Ushakov, Physical Foundations and Gas Dynamics of Combustion of Gunpowders in Artillery Systems [in Russian], Institute of Computer Research (2016).
A. Yu. Krainov and V. A. Poryazov, Numerical simulation of unsteady gunpowder combustion at a rapid Increase in pressure on the basis of a conjugate combustion model, J. Eng. Phys. Thermophys., 95, No. 1, 184–192 (2022).
Ya. B. Zel’dovich, On the theory of combustion of gunpowders and explosives, Zh. Éksp. Teor. Fiz., 12, 498–524 (1942).
Author information
Authors and Affiliations
Corresponding author
Additional information
Translated from Inzhenerno-Fizicheskii Zhurnal, Vol. 96, No. 6, pp. 1487–1493, November–December, 2023.
Rights and permissions
Springer Nature or its licensor (e.g. a society or other partner) holds exclusive rights to this article under a publishing agreement with the author(s) or other rightsholder(s); author self-archiving of the accepted manuscript version of this article is solely governed by the terms of such publishing agreement and applicable law.
About this article
Cite this article
Ishchenko, A.N., Krainov, A.Y., Rogaev, K.S. et al. Experimental and Theoretical Study of Granulated Charge Combustion in a Closed Volume. J Eng Phys Thermophy 96, 1474–1480 (2023). https://doi.org/10.1007/s10891-023-02816-8
Received:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10891-023-02816-8