Skip to main content
SpringerLink
Log in

Heat Transfer of a Stack of Low-Thermal-Conductivity Plates in Cyclic Heat Exchange with Cold and Hot Media

  • Published:
Journal of Engineering Physics and Thermophysics Aims and scope

The authors have described a laboratory bench with a regenerative air heater and an automated system for control and measurement of the parameters of air flows and a packing. The bench is intended for investigating the heat transfer of a packing in the form of a stack of parallel plates under nonstationary conditions. A procedure for measuring the temperature of the flows of cold and hot heat-transfer agents with account taken of the inertia of thermocouples has been presented. A mathematical model of thermal processes in the flows of heat-transfer agents and the packing in cyclic heat exchange with the cold and hot heat-transfer agents has been developed. Results of computations of the changes in the temperatures of the heat-transfer agents and the plate with time and along the plate have been presented. Coefficients of heat transfer of the plate′s lateral surfaces have been calculated by the existing procedure and with the developed mathematical model. The calculation results have been generalized by the similarity equations. Coefficients of heat transfer of the plate′s end surfaces have been assessed.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Similar content being viewed by others

References

  1. E. H. Hausen, Wärmeübertragung im Gegenstrom, Gleichstrom und Kreuzstrom, Springer Verlag, Berlin, Heidelberg, New York (1976).

    Book  Google Scholar 

  2. T. S. Dobryakov, V. K. Migai, V. S. Nazarenko, I. I. Nadyrov, and I. I. Fedorov, Air Heaters of Boiler Units [in Russian], Énergiya, Leningrad (1977).

    Google Scholar 

  3. Thermal Calculation of Boilers (Normative Method) [in Russian], Izd. NPO TsKTI, St. Petersburg (1998).

  4. Yu. A. Kirsanov, Cyclic Thermal Processes and the Theory of Heat Conduction in Regenerative Air Heaters [in Russian], Fizmatlit, Moscow (2007).

    Google Scholar 

  5. Yu. A. Kirsanov, D. V. Makarushkin, and A. G. Filimonov, Influence of the regenerator rotor speed on the heat transfer of a packing and the performance of a steam generator, Tr. Akademénergo, No. 3, 60–71 (2018).

  6. Yu. A. Kirsanov, K. M. Volchenko, and A. Sh. Nizamova, Method of experimental study of a stack of parallel plates, Izv. Vyssh. Uchebn. Zaved., Probl. Énerg., Nos. 5–6, 19–23 (1999).

  7. Yu. A. Kirsanov, A. E. Yudakhin, D. V. Makarushkin, and A. Yu. Kirsanov, Method of investigation of heat transfer in a regenerative air heater, Tr. Akademénergo, No. 2, 29–44 (2018).

  8. Yu. A. Kirsanov, D. V. Makarushkin, and A. Yu. Kirsanov, Influence of the frequency of switching of periods on the heat transfer of the packing of a regenerative air heater, Teplofiz. Aéromekh., 26, No. 4, 539–548 (2019).

    Google Scholar 

  9. Yu. A. Kirsanov, D. V. Makarushkin, and A. Yu. Kirsanov, Investigation of heat exchange in a regenerator with a lowthermal-conductivity checkerwork, Tr. Akademénergo, No. 2, 7–24 (2019).

  10. Yu. A. Kirsanov, K. M. Volchenko, and A. Sh. Nizamova, Mathematical model of a regenerative air heater to investigate the heat transfer of a stack of parallel solid bodies, Izv. Vyssh. Uchebn. Zaved., Probl. Énerg., Nos. 9–10, 3–10 (1999).

  11. P. P. Kremlevskii, Flowmeters and Fluid Meters [in Russian], Mashinostroenie, Leningrad (1975).

    Google Scholar 

  12. Yu. A. Kirsanov, Influence of the unsteadiness and nonuniformity of temperature fields in the wall on the temperature of the heat-transfer agent, Izv. Vyssh. Uchebn. Zaved., Aviats. Tekh., No. 2, 75–79 (1997).

  13. A. V. Luikov, Heat Conduction Theory [in Russian], Vysshaya Shkola, Moscow (1967).

    Google Scholar 

  14. E. Kamke, Differentialgleichungen Lösungsmethoden und Lösungen. I. Gewöhnliche Differentialgleichungen, Akademische Verlagsgesellschaft Geets & Portig K.-G., Leipzig (1959).

  15. Yu. A. Kirsanov and D. V. Makarushkin, Conjugate problem of cyclic heat exchange between a prism and cold and hot heat-transfer agents, Vestn. Kazansk. Gos. Tekh. Univ. im A. N. Tupoleva, No. 1, 29–36 (2018).

  16. É. M. Kartashov, Integral transformations for the generalized equation of nonstationary heat conduction on a partially bounded region, J. Eng Phys. Thermophys., 90, No. 6, 1279–1287 (2017).

    Article  Google Scholar 

  17. É. M. Kartashov, Calculations of temperature fields in solid bodies on the basis of improved convergence of Fourier–Hankel series, Part 2, Izv. Ross. Akad. Nauk, Énergetika, No. 3, 106–125 (1993).

  18. Yu. A. Kirsanov, Improvement of the convergence of Fourier–Hankel series in solving two-dimensional heat-conduction problems, J. Eng Phys. Thermophys., 73, No. 6, 1310–1316 (2000).

    Article  Google Scholar 

  19. V. G. Karmanov, Mathematical Programming: A Textbook [in Russian], Fizmatlit, Moscow (2004).

    Google Scholar 

  20. E. R. Meinders, K. Hanjalic, and R. J. Martinuzzi, Experimental study of the local convection heat transfer from a wall-mounted cube in turbulent channel flow, Trans. ASME, 121, 564–573 (1999).

    Article  Google Scholar 

  21. V. I. Terekhov, A. I. Gnyrya, and S. V. Korobkov, Vortex pattern of vortex flow and heat transfer of a single cube on a plane surface at various angles of attack, Teplofiz. Aéromekh., 17, No. 4, 521–533 (2010).

    Google Scholar 

  22. A. A. Zhukauskas, Convective Transfer in Heat Exchangers [in Russian], Nauka, Moscow (1982).

    Google Scholar 

  23. S. S. Kutateladze, Heat Transfer and Hydrodynamic Resistance: a Reference Book [in Russian], Énergoatomizdat, Moscow (1990).

    Google Scholar 

  24. Heat Exchanger Design Handbook, Vol. 1. Heat Exchanger Theory, D. B. Spalding and J. Taborek (Contr.), Hemisphere Publishing Corp. (1983).

Download references

Author information

Authors and Affiliations

  1. Institute of Power Engineering and Advanced Technologies of the Federal Research Center, “Kazan Scientific Center of the Russian Academy of Sciences,”, 2/31 Lobachevskii Str, Kazan, 420111, Russia

    Yu. A. Kirsanov, D. V. Makarushkin & A. E. Yudakhin

  2. A. N. Tupolev Kazan National Research Technical University, 10 K. Marx Str, Kazan, 420111, Russia

    A. Yu. Kirsanov

Authors
  1. Yu. A. Kirsanov
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. D. V. Makarushkin
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. A. Yu. Kirsanov
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. A. E. Yudakhin
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to A. Yu. Kirsanov.

Additional information

Translated from Inzhenerno-Fizicheskii Zhurnal, Vol. 94, No. 2, pp. 301–312, March–April, 2021.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Kirsanov, Y.A., Makarushkin, D.V., Kirsanov, A.Y. et al. Heat Transfer of a Stack of Low-Thermal-Conductivity Plates in Cyclic Heat Exchange with Cold and Hot Media. J Eng Phys Thermophy 94, 286–297 (2021). https://doi.org/10.1007/s10891-021-02301-0

Download citation

  • Received:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s10891-021-02301-0

Keywords

Search

Navigation