An investigation has been conducted into the action of nonequilibrium low-temperature plasma of a high-frequency capacitive discharge in air at a pressure of 133.3 MPa upon the structure of brass and beryllium bronze. The absence of changes in the microstructure of alloys under the action of plasma was established using the target metallography method. It has been shown that the main effect of the plasma action is the formation of static distortions of the abovementioned materials at the level ~0.007·10–10 m.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
G. S. Zhdanov, Solid Physics [in Russian], MGU, Moscow (1962).
A. G. Anisovich, X-Ray Structural Analysis in Practical Materials Science Problems [in Russian], Fizmatlit, Moscow (1961).
L. I. Mirkin, Handbook of X-Ray Structural Analysis of Polycrystals [in Russian], Fizmatlit, Moscow (1961).
A. G. Anisovich, V. V. Azharonok, and I. I. Filatova, Lattice strain as a factor of structure formation, Proc. 8th Int. Conf. “SMaterials Science and Condensed Matter Physics,” 12–16 September 2016, Chisinau (2016), p. 327.
A. G. Anisovich, V. V. Azharonok, V. F. Gologan, Zh. I. Bobanova, S. Kh. Ivashku, and D. M. Kroitoru, The effect of low temperature nonequilibrium air plasma on the structure and properties of copper and chromium electrodeposited coatings, Int. J. Res. Stud. Sci., Eng., Technol., 3, No. 2, 42–49 (2016).
V. V. Azharonok, A. G. Anisovich, A. V. Basalai, S. V. Goncharik, I. I. Filatova, and N. I. Chubrik, Transformation of copper structure on exposure to a nonequilibrium low-temperature plasma, J. Eng. Phys. Thermophys., 86, No. 4, 781–788 (2013).
A. É. Lipskii, Optimum regimes of hardening treatment of working surfaces of high-speed-steel tools based on the method of modifying than by a low-energy-plasma flux, Vestn. Belorussko-Ross. Univ., No. 4, 64–71 (2007).
V. A. Barvinok and A. V. Ryasnyi, Influence of low-energy plasma treatment on the physicomechanical properties and structure of aluminum and its alloys, Vestn. Samarsk. Gos. Tekh. Univ., Ser. Fiz. Mat. Nauk, 19, No. 2, 193–199 (2009).
I. V. Tereshko, V. I. Khodyrev, A. É. Lipskii, Zh. A. Rymkevich, V. V. Glushenko, V. N. Konchalenko, and D. L. Vinogradov, The effect of long-range action in materials under low-energy ionic irradiation, Vestn. Nats. Issled. Nizhegorodsk. Gos. Univ. im. N. I. Lobachevskogo, Ser. Fiz. Tverd. Tela, No. 2, 131–139 (1998).
L. Vi vet, A. L. Joudrier, M. Bouttemy, J. Vigneron, K. L. Tan, J. M. Morelle, A. Etcheberry, and L. Chalumeau, Wettability and XPS-analyses of nickel–phosphorus surfaces after plasma treatment: An efficient approach for surface qualification in mechatronic processes, Appl. Surf. Sci., 274, 71–78 (2013).
V. Brackmann, V. Hoffmann, A. Kauffmann, A. Helth, J. Thomas, H. Wendrock, J. Freudenberger, T. Gemming, and J. Eckert, Glow discharge plasma as a surface preparation tool for microstructure investigations, Mater. Character, 91, 76–88 (2014).
V. Prysiazhnyi, M. Stupavská, J. Ráhel’, C. Kleber, M. Černák, and L. D. Rafailović, A comparison of chemical and atmospheric plasma assisted copper plating on carbon fiber reinforced epoxy polymer surfaces, Surf. Coat. Technol., 258, 1082–1089 (2014).
Z. Gurskii and J. Krawczyk, The role of atomic static displacements in binary-alloy formation, Physica B, 337, 255–265 (2003).
V. A. Lapitskaya, T. A. Kuznetsova, A. A. Rogachev, G. B. Mel’nikova, S. A. Chizhik, and D. A. Kotov, Influence of the treatment of surfaces of materials in a dielectric-barrier-discharge plasma on their morphology and hydrophilic properties, J. Eng. Phys. Thermophys., 92, No. 5, 1349–1354 (2019).
Ya. S. Umanskii, B. N. Finkel’shtein, M. E. Blanter, S. T. kishkin, N. S. Fastov, and S. S. Gorelik, Physical Metal Science [in Russian], Metallurgiya, Moscow (1955).
Yu. S. Terminasov and G. A. Feklistov, X-ray investigation into the mechanism of thermal action on plastically deformed metals, Izv. Akad. Nauk SSSR, Ser. Fiz., 20, No. 6, 695–699 (1956).
D. Batsur’, V. I. Iveronova, and G. P. Revkevich, On the problem of 3rd-kind stresses, Izv. Akad. Nauk SSSR, Ser. Fiz., 23, No. 5, 591–600 (1959).
V. M. Finkel’, Distortions of the crystalline lattice of coarse- and fine-grained steel under cold plastic deformation, Fiz. Met. Metalloved., 2, Issue 1, 189–191 (1956).
Cyril Cayron, Continuous atomic displacements and lattice distortion during fcc–bcc martensitic transformation, Acta Mater., 96, 189–202 (2015).
Feng Peng, Modulated fluctuation of atomic displacement in a crystal with a single impurity, Physica B, 373, 194–197 (2006).
Yu. N. Mikhailov and S. F. Dubinin, Longwave static displacements of atoms in γ-FeNi alloys, Fiz. Tverd. Tela, 46, No. 12, 2113–2118 (2004).
A. P. Zhernov and A. V. Inyushkin, Influence of an isotope composition on phonon modes. Static atomic displacements in crystals, Usp. Fiz. Nauk, 171, No. 8, 827–824 (2001).
G. V. Kurdyumov, V. A. Il’ina, V. K. Kritskaya, and L. I. Lysak, X-ray investigation into the distortions and bonding strengths in the crystal lattice of metals and alloys, Izv. Akad. Nauk SSSR, Ser. Fiz., 18, No. 3, 297–312 (1953).
A. G. Anisovich, V. V. Azharonok, A. V. Basalai, and S. V. Goncharik, Structural changes in metal alloys under the action of a cold air plasma, Proc. XI Belorussian-Serbian Symp. “Physics and Diagnostics of Laboratory and Astrophysical Plasma,” December 2016, Minsk (2016), pp. 34–37.
Author information
Authors and Affiliations
Corresponding author
Additional information
Translated from Inzhenerno-Fizicheskii Zhurnal, Vol. 93, No. 6, pp. 1637–1644, November–December, 2020.
Rights and permissions
About this article
Cite this article
Anisovich, A.G., Filatova, I.I. & Goncharik, S.V. Variation in the Stress State of Copper Alloys Under the Action of Cold Air Plasma. J Eng Phys Thermophy 93, 1583–1590 (2020). https://doi.org/10.1007/s10891-020-02263-9
Received:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10891-020-02263-9