Skip to main content
SpringerLink
Log in

Study on the effects of crisp layer on optical and mechanical properties of CVD ZnS

  • Published:
Journal of Materials Science: Materials in Electronics Aims and scope Submit manuscript

Abstract

CVD ZnS was prepared by chemical vapor deposition, and multispectral ZnS was obtained by hot isostatic pressing treatment. XRD, transmittance and bending strength were used to characterize the samples. The effects of CVD ZnS crisp layer on the optical and mechanical properties of materials before and after hot isostatic pressing were studied systematically. It was found that there were relatively few hexagonal phases in the standard ZnS crisp layer, with stress concentration, grain size significantly larger than the normal zone and the bending strength lower than the normal zone 10%. When the wavelength is less than 660 nm, the transmittance of the crisp layer can be higher than that of the normal region. When the wavelength is greater than 660 nm, the transmittance of the crisp layer is lower than that of the normal region, with a difference of 11% at 2 μm. The transmittance of the far-infrared region was basically same. After hot isostatic pressing treatment, the stress concentration in the crisp layer and the hexagonal phase of each layer was eliminated. The grain size tended to be uniform, but the bending strength of the crisp layer was still lower than that of the normal area 4%. The overall transmittance was significantly improved, and the transmittance of the crisp layer was higher than that of the normal area. The difference gradually decreased with the increase in wavelength, and the difference was 3% at 450 nm.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8
Fig. 9

Similar content being viewed by others

References

  1. S. Musikant, Optical Materials—An Introduction to Selection & Application (Marcel Dekker, New York, 1985)

    Google Scholar 

  2. Y. Drezner, S. Berger, M. Hefetz et al., A correlation between microstructure, composition and optical transparency of CVD-ZnS. Mater. Sci. Eng. B 87, 59–65 (2001)

    Article  Google Scholar 

  3. J. Mccloy, R.W. Tustison, Chemical Vapor Deposited Zinc Sulfide (SPIE Press, Bellingham, 2013)

    Book  Google Scholar 

  4. J. Mccloy, E. Fest, R. Korenstein, et al., Anisotropy in structural and optical properties of chemical vapor deposited ZnS. Proc. SPIE Int. Soc. Opt. Eng. (2011). https://doi.org/10.1117/12.886138

    Article  Google Scholar 

  5. A.F. Shchurov, E.M. Gavrishchuk, V.B. Ikonnikov et al., Effect of hot isostatic pressing on the elastic and optical properties of polycrystalline CVD ZnS. Inorg. Mater. 40(4), 336–339 (2004)

    Article  CAS  Google Scholar 

  6. S. Joseph, O. Marcovitch, Y. Yadin et al., Improved rain erosion protection for multi-spectral ZnS. SPIE Window Dome Technol. Mater. IX 5786, 373–380 (2005)

    Article  CAS  Google Scholar 

  7. T.M. Radchenko, A.A. Shylau, I.V. Zozoulenko et al., Conductivity of epitaxial and CVD graphene with correlated lined effects. Solid State Commun. 195, 88–94 (2014)

    Article  CAS  Google Scholar 

  8. C.-H. Su, Bulk growth of wide band gap II-VI compound semiconductors by physical vapor transport. Proc. SPIE (1997). https://doi.org/10.1117/12.277715

    Article  Google Scholar 

  9. D.C. Harris, W.F. Parsons, J. Pappis et al., Development of hot-pressed and chemical-vapor-deposited zinc sulfide and zinc selenide in the United States for optical windows. Proc. SPIE Int. Soc. Opt. Eng. 6545, 54502 (2007)

    Google Scholar 

  10. S. Vahid, D. Fatemeh, T.M. Hassan et al., Preparation of alumina /AlON and AlON/AlN composites from Al2O3/carbon nanocomposite by solvothermal method. Ceram. Int. 45(5), 6074–6084 (2019)

    Article  Google Scholar 

  11. A. Tallaire, M. Kasu, K. Ueda et al., Origin of growth defects in CVD diamond epitaxial films. Diam. Relat. Mater. 17, 60–65 (2008)

    Article  CAS  Google Scholar 

  12. F. Zhenyi, C. Yichao, H. Yongliang et al., CVD growth of bulk polycrystalline ZnS and its optical properties. J. Cryst. Growth 1707, 237–239 (2002)

    Google Scholar 

  13. D.W. Blodgett, M.E. Thomas, D.V. Hahn et al., Longwave infrared absorption properties of ZnS and ZnSe. Proc. SPIE Int. Soc. Opt. Eng. 5078, 137–147 (2003)

    CAS  Google Scholar 

  14. P. Biswas, R. Senthil Kumar, P. Ramavath et al., Effect of post-CVD thermal treatments on crystallographic orientation, microstructure, mechanical and optical properties of ZnS ceramics. J. Alloys Compd. 496, 273–277 (2010)

    Article  CAS  Google Scholar 

  15. A.F. Shchurov, E.M. Gavrishchuk, V.B. Ikonnikov et al., Effect of hot isostatic pressing on the elastic and optical properties of polycrystalline CVD ZnS. Inorg. Mater. 40, 336–339 (2004)

    Article  CAS  Google Scholar 

  16. J. McCloy, R. Korenstein, B. Zelinski, Effects of temperature pressure and metal promoter on the recrystallized structure and optical transmission of chemical vapor deposited zinc sulfide. J. Am. Ceram. Soc. 92, 1725–1731 (2009)

    Article  CAS  Google Scholar 

Download references

Acknowledgements

This work was financially supported by the project of The Transformation of Major Science and Technology Achievements of Hebei Province (No. 18041030Z).

Author information

Authors and Affiliations

  1. GRIRNM Guojing Advanced Material Co., Ltd, General Research Institute for Nonferrous Metals, Sanhe, 065201, China

    Lipeng Jiang, Dongxu Li, Wenjiang Li, Zilin Song, Jianchun Yang, Li Guo, Zhirui Tian, Xiaohua Liu & Jianming Li

Authors
  1. Lipeng Jiang
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Dongxu Li
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Wenjiang Li
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Zilin Song
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. Jianchun Yang
    View author publications

    You can also search for this author in PubMed Google Scholar

  6. Li Guo
    View author publications

    You can also search for this author in PubMed Google Scholar

  7. Zhirui Tian
    View author publications

    You can also search for this author in PubMed Google Scholar

  8. Xiaohua Liu
    View author publications

    You can also search for this author in PubMed Google Scholar

  9. Jianming Li
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Lipeng Jiang.

Additional information

Publisher's Note

Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Jiang, L., Li, D., Li, W. et al. Study on the effects of crisp layer on optical and mechanical properties of CVD ZnS. J Mater Sci: Mater Electron 31, 2459–2465 (2020). https://doi.org/10.1007/s10854-019-02783-y

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s10854-019-02783-y

Search

Navigation