Abstract
In this work, we report the influence of pyrolytic temperature on the properties of ZnO films deposited by a novel spray pyrolysis deposition route. XRD results revealed an improvement in crystal quality of the films with increase in growth temperature. The optical measurements of the films show a maximum transmittance of ~85 % and the band gap of ~3.5 eV. Photoluminescence spectra revealed that the UV emission peaks at 385 nm is improved with increase in growth temperature upto 300 °C, which corresponds to the increase of optical quality and decrease of Zn interstitial defect in the films. Gold ohmic contacts were evaporated on the optimized ZnO film prepared at the substrate temperature of 300 °C, and response of the film to different concentrations of hydrogen (150–500 ppm) at room temperature was investigated. The ZnO sensor showed significant sensitivity to hydrogen for concentration as low as 150 ppm at room temperature, and the sensor response was observed to increase with increase in hydrogen concentration. The increased sensitivity of the film was attributed to the large roughness of the film revealed from AFM analysis. The results ensure the application of our novel sensor, to detect H2 at low concentration and at room temperature.
Similar content being viewed by others
References
W.F. Liu, J.M. Bian, L.Z. Hu, H.W. Liang, H.Q. Zang, J.C. Sun, Z.W. Zhao, A.M. Liu, G.T. Du, Electroluminescence from a ZnO homojunction device grown by pulsed laser deposition. Solid State Commun. 142, 655–658 (2007)
A. Janotti, C.G. Van de Walle, Fundamentals of zinc oxide as a semiconductor. Rep. Prog. Phys. 72, 126501 (2009)
T. Seiyama, A. Kato, K. Fulishi, M. Nagatani, A new detector for gaseous components using semiconductive thin films. Anal. Chem. 34, 1502–1503 (1962)
S. Badadhe, I.S. Mulla, Effect of aluminium doping on structural and gas sensing properties of zinc oxide thin films deposited by spray pyrolysis. Sens. Actuators B Chem. 156, 943–948 (2011)
J. Zhang, H. Liu, Z. Wang, N. Ming, Low-temperature growth of ZnO with controllable shapes and band gaps. J. Cryst. Growth 310, 2848–2853 (2008)
M. Gupta, V. Sharma, J. Shrivastava, A. Solanki, A.P. Singh, V.R. Satsangi, S. Dass, R. Shrivastava, Preparation and characterization of nanostructured ZnO thin films for photoelectrochemical splitting of water. Bull. Mater. Sci. 32, 23–30 (2009)
F. Chowdhury, K.H.S. Begum, S.M. Firoz Hasan, M.S. Alam, Effects of substrate temperature on the optical properties of vacuum evaporated ZnO thin film. J. Optoelectron. Adv. Mater. 5, 356–359 (2011)
S. Ilican, M. Caglar, Y. Caglar, Effect of substrate temperature on the structural and optical properties of non-doped ZnO thin films. AIP Conf. Proc. 899, 651 (2007)
L.J. Bie, X.N. Yan, J. Yin, Y.Q. Duan, Z.H. Yuan, Nanopillar ZnO gas sensor for hydrogen and ethanol. Sens. Actuators B Chem. 126, 604–608 (2007)
M. Suchea, S. Christolulakis, K. Moschovis, N. Katsarakis, G. Kiriakidis, ZnO transparent thin films for gas sensor applications. Thin Solid Films 515, 551–554 (2006)
Z.R. Khan, M.S. Khan, M. Zulfequar, M.S. Khan, Optical and structural properties of ZnO thin films fabricated by sol–gel method. Mater. Sci. Appl. 2, 340–345 (2011)
A. Alias, K. Hazawa, N. Kawashima, H. Fukuda, K. Uesugi, Fabrication of ZnO thin-film transistors by chemical vapor deposition method using zinc acetate solution. Jpn. J. Appl. Phys. 50, 1–4 (2011)
G. Epurescu, N.D. Scarisoreanu, D.G. Matei, G. Dinescu, C. Ghica, L.C. Nistor, M. Dinescu, Functional Zno thin films obtained by radiofrequency beam assisted pulsed laser deposition. Rom. Rep. Phys. 60(3), 807–814 (2008)
L. Xiao-Bo, S. Hong-Lie, Z. Hui, L. Bin-Bin, Optical properties of nanosized ZnO films prepared by sol–gel process. Trans. Nonfer. Met. Soc. China 17, 814–817 (2007)
S. Tewari, A. Bhattacharjee, Structural, electrical and optical studies on spray-deposited aluminium-doped ZnO thin films. Pramana 76, 153–163 (2011)
K. Vijayalakshmi, K. Karthick, D. Gopalakrishna, Influence of annealing on the structural, optical and photoluminescence properties of ZnO thin films for enhanced H2 sensing application. Ceram. Int. 39, 4749–4756 (2013)
S. Thanikaikarasan, T. Mahalingam, V. Dhanasekaran, A. Kathalingam, J.-K. Rhee, Growth and characterization of lead selenide thin films. J. Mater. Sci.: Mater. Electron. 23, 1562–1568 (2012)
D. Gopalakrishna, K. Vijayalakshmi, C. Ravidhas, Effect of pyrolytic temperature on the properties of nano-structured CuO optimized for ethanol sensing applications. J. Mater. Sci.: Mater. Electron. 24, 1004–1011 (2013)
S. Cho, Effects of growth temperature on the properties of ZnO thin films grown by radio-frequency magnetron sputtering. Trans. Electr. Electron. Mater. 10, 185–188 (2009)
T. Ivanova, A. Harizanova, T. Koutzarova, B. Vertruyen, Study of ZnO sol–gel films: effect of annealing. Mater. Lett. 64, 1147–1149 (2010)
R.N. Gayen, K. Sarkar, S. Hussain, R. Bhar, A.K. Pal, ZnO films prepared by modified sol–gel technique. Indian J. Pure Appl. Phys. 49, 470–477 (2011)
P. Mitra, S. Mondal, Structural and morphological characterization of ZnO thin films synthesized by SILAR. Prog. Theor. Appl. Phys. 1, 17–31 (2013)
S. Aydogu, O. Sendil, M.B. Coban, The optical and structural properties of ZnO thin films deposited by the spray pyrolysis technique. Chin. J. Phys. 50, 89–100 (2012)
S. Ilican, M. Caglar, Y. Caglar, The effect of deposition parameters on the physical properties of CdxZn1-x S films deposited by spray pyrolysis method. J. Optoelectron. Adv. Mater. 9, 1414–1417 (2007)
A. Djelloul, K. Bouzid, F. Guerrab, Role of substrate temperature on the structural and morphological properties of ZnO thin films deposited by ultrasonic spray pyrolysis. Turk. J. Phys. 32, 49–58 (2008)
S.H. Jeong, J.K. Kim, B.T. Lee, Effects of growth conditions on the emission properties of ZnO films prepared on Si(100) by rf magnetron sputtering. J. Phys. D Appl. Phys. 36, 2017–2020 (2003)
T. Minami, H. Nanto, S. Takata, Luminescent properties of sputtered ZnO thin films. J. Lumin. 24–25, 63–66 (1981)
Zheng Jiao, Minghong Wo, Jianzhong Gu, Xilian Sun, The gas sensing characteristics of ITO thin film prepared by sol–gel method. Sens. Actuators B Chem. 94, 216–221 (2003)
Y. Liu, T. Hang, Y. Xie, Z. Bao, J. Song, H. Zhang, E. Xie, Effect of Mg doping on the hydrogen-sensing characteristics of ZnO thin films. Sens. Actuators B Chem. 160, 266–270 (2011)
C.S. Rout, S. Hari Krishna, S.R.C. Vivekchand, A. Govindaraj, C.N.R. Rao, Hydrogen and ethanol sensors based on ZnO nanorods, nanowires. Chem. Phys. Lett. 418, 586–590 (2006)
V. VasanthiPillay, K. Vijayalakshmi, Effect of rf power on the structural properties of indium tin oxide thin film prepared for application in hydrogen gas sensor. J. Mater. Sci.: Mater. Electron. 24, 1895–1899 (2013)
Acknowledgments
This work was financially supported by the University Grants Commission (Major Research Project-File No: 40-441/2011) India, which is gratefully acknowledged.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Vijayalakshmi, K., Gopalakrishna, D. Influence of pyrolytic temperature on the properties of ZnO films optimized for H2 sensing application. J Mater Sci: Mater Electron 25, 2253–2260 (2014). https://doi.org/10.1007/s10854-014-1868-4
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10854-014-1868-4