Skip to main content
SpringerLink
Log in

Solidification of ettringite after uptaking selenate as a surrogate of radionuclide in glass-ceramics by using industrial by-products

  • Ceramics
  • Published:
Journal of Materials Science Aims and scope Submit manuscript

Abstract

After accumulation of toxic ions from a contaminated source, spent absorbents and coprecipitation sludge should be stabilized before landfilling for long time storage, especially in the case of absorbed radionuclides. Therefore, development of novel and efficient method to stabilize spent absorbents that contain highly toxic ions is urgently needed. In the present work, the use of industrial by-products as raw materials to produce ceramics to treat toxic waste was investigated. As a typical oxoanion absorbent, selenate-doped ettringite was mixed with granulated blast furnace slag and silica fume and then calcined at various temperatures to produce glass-ceramics. Above 800 °C, the amorphous mixture was converted to glass-ceramics, which were subjected to the toxicity characteristic leaching procedure test. The synthesized ceramics exhibited excellent behavior for immobilization of selenate, and only 0.1 mg/L of selenate was leached out. However, the total concentration of selenate in the mixture was not reduced during calcination. The X-ray photoelectron spectroscopy revealed the stabilization mechanism is based on encapsulation. In addition, the ceramic materials exhibited excellent chemical stability at pH 2–12. These results showed that industrial by-products can be successfully applied to produce ceramics for immobilization and storage of hazardous wastes.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Figure 1
Figure 2
Figure 3
Figure 4
Figure 5
Figure 6
Figure 7
Figure 8
Figure 9
Figure 10

Similar content being viewed by others

References

  1. Jörg G, Bühnemann R, Holla S, Kivelc N, Kossertd K, Winckelb SV, Gostomskia CL (2010) Preparation of radiochemically pure 79Se and highly precise determination of its half-life. Appl Radiat Isot 68:2339–2351

    Article  Google Scholar 

  2. Riley RG, Zachara JM (1992) Chemical contaminants on DOE lands and selection of contaminant mixtures for subsurface science research. Pacific Northwest Lab, Richland

    Google Scholar 

  3. U.S. Environmental Protection Agency (EPA) (2000) Selenium compounds and hazard summary-revised. US Environmental Protection Agency, Washington DC

    Google Scholar 

  4. Baur I, Johnson CA (2003) Sorption of selenite and selenate to cement minerals. Environ Sci Technol 37:3442–3447

    Article  Google Scholar 

  5. Zhang P, Sparks DL (1990) Kinetics of selenate and selenite adsorption/desorption at the goethite/water interface. Environ Sci Technol 24:1848–1856

    Article  Google Scholar 

  6. Evans NDM (2008) Binding mechanisms of radionuclides to cement. Cem Concr Res 38:543–553

    Article  Google Scholar 

  7. Peak D (2006) Adsorption mechanisms of selenium oxyanions at the aluminum oxide/water interface. J Colloid Interface Sci 303:337–345

    Article  Google Scholar 

  8. Holmberg B (1981) Solubility and complexation of calcium iodate in (K, Na) NO3 melts. J Inorg Nucl Chem 43:5–8

    Article  Google Scholar 

  9. Kossoy A, Schulze R, Tang M, Safarik DJ, McCabe RJ (2013) Nd–Mo-borosilicate glass–ceramic: synthesis, characterization and response to ionizing radiation. J Nucl Mater 437:216–221

    Article  Google Scholar 

  10. Zhu YN, Zhang XH, Xie QL, Wang DQ, Cheng GW (2006) Solubility and stability of calcium arsenates at 25 C. Water Air Soil Pollut 169:221–238

    Article  Google Scholar 

  11. Kumarathasan PK, McCarthy GJ, Hassett DJ, Debra F (1990) Oxyanion substituted ettringites: synthesis and characterization; and their potential role in immobilization of As, B, Cr, Se and V. In: MRS Proceedings, vol 178. Cambridge University Press, pp 83–104

  12. Chrysochoou M, Dermatas D (2006) Evaluation of ettringite and hydrocalumite formation for heavy metal immobilization: literature review and experimental study. J Hazard Mater 136:20–33

    Article  Google Scholar 

  13. Bonhoure I, Baur I, Wieland E, Johnson CA, Scheidegger AM (2006) Uptake of Se (IV/VI) oxyanions by hardened cement paste and cement minerals: an X-ray absorption spectroscopy study. Cem Concr Res 36:91–98

    Article  Google Scholar 

  14. Szlachta M, Chubar N (2013) The application of Fe–Mn hydrous oxides based adsorbent for removing selenium species from water. Chem Eng J 217:159–168

    Article  Google Scholar 

  15. Zhang M, Reardon EJ (2003) Removal of B, Cr, Mo, and Se from wastewater by incorporation into hydrocalumite and ettringite. Environ Sci Technol 37:2947–2952

    Article  Google Scholar 

  16. Moon DH, Grubb DG, Reilly TL (2009) Stabilization/solidification of selenium-impacted soils using Portland cement and cement kiln dust. J Hazard Mater 168:944–951

    Article  Google Scholar 

  17. Anthony JW, Bideaux RA, Bladh KW, Nichols MC (2003) Handbook of mineralogy: borates carbonates, sulfates. Mineral Data Publishing, Tuscon

    Google Scholar 

  18. Poellmann H, Kuzel HJ, Wenda R (1993) Solid solution of ettringites: part II: incorporation of B(OH) −4 and CrO4 2− in 3CaO·Al2O3·3CaSO4·32H2O. Cem Concr Res 23:422–430

    Article  Google Scholar 

  19. Ghorpade PA, Ha MG, Choi WH, Park JY (1993) Combined calcium sulfoaluminate and ordinary portland cement/Fe(II) system for enhanced dechlorination of trichloroethylene. Chem Eng J 231:326–333

    Article  Google Scholar 

  20. Saikia N, Kato S, Kojima T (2006) Behavior of B, Cr, Se, As, Pb, Cd, and Mo present in waste leachates generated from combustion residues during the formation of ettringite. Environ Toxicol Chem 25:1710–1719

    Article  Google Scholar 

  21. Hassett DJ, McCarthy GJ, Kumarathasan P, Pflughoeft-Hassett D (1990) Synthesis and characterization of selenate and sulfate-selenate ettringite structure phases. Mater Res Bull 25:1347–1354

    Article  Google Scholar 

  22. Gougar MLD, Scheetz BE, Roy DM (1996) Ettringite and C–S–H Portland cement phases for waste ion immobilization: a review. Waste Manag 16:295–303

    Article  Google Scholar 

  23. Myneni SCB, Traina SJ, Logan TJ, Waychunas GA (1997) Oxyanion behavior in alkaline environments: sorption and desorption of arsenate in ettringite. Environ Sci Technol 31:1761–1768

    Article  Google Scholar 

  24. Shi C (2004) Steel slag-its production, processing, characteristics, and cementitious properties. J Mater Civ Eng 16:230–236

    Article  Google Scholar 

  25. Nippon Slag Association (NSA) (2016) Production and usage of blast furnace slag in Japan. Tokyo. http://www.slg.jp/e/

  26. Li J, Yu Q, Wei J, Zhang T (2011) Structural characteristics and hydration kinetics of modified steel slag. Cem Concr Res 41:324–329

    Article  Google Scholar 

  27. Malhotra VM (1993) Fly ash, slag, silica fume, and rice-husk ash in concrete: a review. Concr Int 15:23–28

    Google Scholar 

  28. Chan YW, Chu SH (2004) Effect of silica fume on steel fiber bond characteristics in reactive powder concrete. Cem Concr Res 34:1167–1172

    Article  Google Scholar 

  29. Behnood A, Ziari H (2008) Effects of silica fume addition and water to cement ratio on the properties of high-strength concrete after exposure to high temperatures. Cem Concr Compos 30:106–112

    Article  Google Scholar 

  30. Toya T, Nakamura A, Kameshima Y, Nakajima A, Okada K (2007) Glass-ceramics prepared from sludge generated by a water purification plant. Ceram Int 33:573–577

    Article  Google Scholar 

  31. Verbinnen B, Block C, Van Caneghem J, Vandecasteele C (2015) Recycling of spent adsorbents for oxyanions and heavy metal ions in the production of ceramics. Waste Manag 45:407–411

    Article  Google Scholar 

  32. Liu T, Tang Y, Han L, Song J, Luo Z, Lu A (2017) Recycling of harmful waste lead-zinc mine tailings and fly ash for preparation of inorganic porous ceramics. Ceram Int 43:4910–4918

    Article  Google Scholar 

  33. Erol M, Küçükbayrak S, Ersoy-Mericboyu A (2007) Production of glass–ceramics obtained from industrial wastes by means of controlled nucleation and crystallization. Chem Eng J 132:335–343

    Article  Google Scholar 

  34. Kim JM, Kim HS (2004) Glass–ceramic produced from a municipal waste incinerator fly ash with high Cl content. J Eur Ceram Soc 24:2373–2382

    Article  Google Scholar 

  35. Xu Z, Jiang Z, Wu D, Peng X, Xu Y, Li N, Qi Y, Li P (2017) Immobilization of strontium-loaded zeolite A by metakaolin based-geopolymer. Ceram Int 43:4434–4439

    Article  Google Scholar 

  36. Donald IW, Metcalfe BL, Taylor RJ (1997) The immobilization of high level radioactive wastes using ceramics and glasses. J Mater Sci 32:5851–5887. doi:10.1023/A:1018646507438

    Article  Google Scholar 

  37. Ojovan MI (2004) Glass formation in amorphous SiO2 as a percolation phase transition in a system of network defects. J Exp Theor Phys 79:632–634

    Article  Google Scholar 

  38. Toplis MJ, Dingwell DB, Lenci T (1997) Peraluminous viscosity maxima in Na2O–Al2O3–SiO2 liquids: the role of triclusters in tectosilicate melts. Geochimica Geochim Cosmochim Acta 61:2605–2612

    Article  Google Scholar 

  39. International Centre for Diffraction Data (ICDD) (2016) Powder diffraction file, PDF-2 database release

  40. Toby BH (2001) EXPGUI, a graphical user interface for GSAS. J Appl rystallogr 34:210–213

    Article  Google Scholar 

  41. U.S. Environmental Protection Agency (EPA) (1986) Test methods for evaluating solid waste: physical/chemical methods. Governmental Printing Office, Washington DC

    Google Scholar 

  42. Perkins RB, Palmer CD (1999) Solubility of ettringite (Ca6(Al(OH)6)2(SO4)3·26H2O) at 5–75°C. Geochim Cosmochim Acta 63:1969–1980

    Article  Google Scholar 

  43. Zhou Q, Lachowski EE, Glasser FP (2004) Metaettringite, a decomposition product of ettringite. Cem Concr Res 34:703–710

    Article  Google Scholar 

  44. Han DS, Batchelor B, Abdel-Wahab A (2013) XPS analysis of sorption of selenium (IV) and selenium (VI) to mackinawite (FeS). Environ Prog Sustain Energy 32:84–93

    Article  Google Scholar 

  45. Schampera B, Tunega D, Šolc R, Woche SK, Mikutta R, Wirth R, Guggenberger G (2016) External surface structure of organoclays analyzed by transmission electron microscopy and X-ray photoelectron spectroscopy in combination with molecular dynamics simulations. J Colloid Interface Sci 478:188–200

    Article  Google Scholar 

  46. Katrib A, Petit C, Légaré P, Hilaire L, Maire G (1987) An investigation of metal-support interaction in bimetallic Pt–Mo catalysts deposited on silica and alumina. Surf Sci 189:886–893

    Article  Google Scholar 

  47. Dua AK, George VC, Agarwala RP (1988) Characterization and microhardness measurement of electron-beam-evaporated alumina coatings. Thin Solid Films 165:163–172

    Article  Google Scholar 

  48. Mullins WM, Averbach BL (1988) Surface properties of silicon and aluminum oxide powders. Surf Sci 206:41–51

    Article  Google Scholar 

  49. Hollinger G (1981) Structures chimique et electronique de l’interface SiO2–Si. Appl Surf Sci 8:318–336

    Article  Google Scholar 

  50. Nguyen TP, Lefrant S (1989) XPS study of SiO thin films and SiO-metal interfaces. J Phys Cond Matter 10:51–97

    Google Scholar 

  51. Anderson PR, Swartz WE (1974) X-ray photoelectron spectroscopy of some aluminosilicates. Inorg Chem 13:2293–2294

    Article  Google Scholar 

  52. Dutta AK (1993) Removal of native oxide from silicon surfaces of a-SiNx/Si devices using high pressure hydrogen plasma. Solid State Electron 36:247–249

    Article  Google Scholar 

  53. Barr TL (1983) An XPS study of Si as it occurs in adsorbents, catalysts, and thin films. Appl Surf Sci 15:1–35

    Article  Google Scholar 

  54. Van Doveren H, Verhoeven JATH (1980) XPS spectra of Ca, Sr, Ba and their oxides. J Electron Spectrosc 21:265–273

    Article  Google Scholar 

  55. Wagner CD, Passoja DE, Hillery HF, Kinisky TG, Six HA, Jansen WT, Taylor JA (1982) Auger and photoelectron line energy relationships in aluminum–oxygen and silicon–oxygen compounds. J Vac Sci Technol 21:933–944

    Article  Google Scholar 

  56. Schwar J, Jahn PW, Wiedmann L, Benninghoven A (1991) Combined chemical and surface analytical investigation of the calcium catalyzed coal gasification process. J Vac Sci Technol, A 9:39–43

    Article  Google Scholar 

  57. Wagner CD (1983) Sensitivity factors for XPS analysis of surface atoms. J Electron Spectrosc Relat Phenom 32:99–102

    Article  Google Scholar 

  58. Barbieri L, Manfredini T, Queralt I, Rincón JM, Romero M (1997) Vitrification of fly ash from thermal power stations. Glass Technol 38:165–170

    Google Scholar 

  59. Fredericci C, Zanotto ED, Ziemath EC (2000) Crystallization mechanism and properties of a blast furnace slag glass. J Non Cryst Solids 273:64–75

    Article  Google Scholar 

  60. Kalinina AM, Filipovich VN (1995) Metastable crystallization of glasses in the pseudobinary diopside-akermanite system. Glass Phys Chem 2:97–102

    Google Scholar 

  61. Berner U (1999) Concentration limits in the cement based Swiss repository for long-lived, intermediate-level radioactive wastes (LMA). Paul Scherner Institut, Villigen

    Google Scholar 

  62. Atkins M, Glasser FP (1992) Application of Portland cement-based materials to radioactive waste immobilization. Waste Manag 12:105–131

    Article  Google Scholar 

  63. Atkins M, Glasser FP (1990) Encapsulation of radioiodine in cementitious waste forms. In: MRS online proceedings library archive, vol 176, p 15

Download references

Acknowledgements

Financial support was provided to KS by the Japan Society for the Promotion of Science (JSPS) KAKENHI research grants (A) (No. JP16H02435). The scholarship was provided to GB by the Minister of Education, Culture, Sports, Science and Technology, Japan (MEXT). We thank Dr. Keiji Watanabe and Mr. Yotaro Inoue from JFE Steel Co., Ltd (Tokyo, Japan) for incisive criticisms and helpful suggestions.

Author information

Authors and Affiliations

  1. Department of Earth Resource Engineering, Kyushu University, Fukuoka, 819-0395, Japan

    Binglin Guo, Keiko Sasaki & Tsuyoshi Hirajima

Authors
  1. Binglin Guo
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Keiko Sasaki
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Tsuyoshi Hirajima
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Keiko Sasaki.

Ethics declarations

Conflict of interest

The authors declare no conflict of interest.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Guo, B., Sasaki, K. & Hirajima, T. Solidification of ettringite after uptaking selenate as a surrogate of radionuclide in glass-ceramics by using industrial by-products. J Mater Sci 52, 12999–13011 (2017). https://doi.org/10.1007/s10853-017-1422-x

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s10853-017-1422-x

Keywords

Search

Navigation