In this paper, the outdoor production of Botryococcus braunii in pilot-scale panel reactors (0.4 m3) is studied under uncontrolled conditions at a location close to the Atacama Desert (Chile). Discontinuous experiments were performed on different dates to determine the feasibility of the culture and the influence of environmental conditions on the system yield. Data showed that solar radiation is a major parameter in determining system yield, the average irradiance inside the culture determining both the growth rate and biomass productivity. A maximum specific growth rate of 0.09 day−1 and biomass productivity of 0.02 g L−1 day−1 (dry weight) were measured in discontinuous mode, at an average irradiance of 60 μE m−2 s−1. With respect to lipids, a productivity of 2.5 mg L−1 day−1 was obtained under favourable growth conditions; no accumulation of lipids at the stationary phase was observed. To confirm this behaviour, a semicontinuous culture was performed at 0.04 day−1 in a larger reactor (1 m3). In this experiment, the biomass concentration and productivity was 0.3 g L−1 and 0.015 g L−1 day−1, respectively. The lipid content and productivity was 15.6% and 2.4 mg L−1 day−1, respectively, the mean average irradiance inside the reactor being 60 μmol photons m−2 s−1. The light path of the reactor determines the light availability, thus determining also the biomass concentration and productivity of the reactor once the dilution rate is fixed. Experimentally, biomass productivity of 0.015 g L−1 day−1 was determined for a light path of 0.15 m, but this can be increased by more than three times for a light path of 0.1 m. These data confirm that this alga can be produced outdoors in a secure form, the culture yield improving when optimal conditions are applied, the data reported here establishing the starting point for the development of the process.
This is a preview of subscription content, access via your institution.
Buy single article
Instant access to the full article PDF.
Tax calculation will be finalised during checkout.
Acién Fernández FG, García Camacho F, Sánchez Pérez JA, Fernández Sevilla JM, Molina Grima E (1997) A model for light distribution and average solar irradiance inside outdoor tubular photobioreactors for the microalgal mass culture. Biotech Bioeng 55:701–714
Banerjee A, Sharma R, Chisti Y, Banerjee UC (2002) Botryococcus braunii: a renewable source of hydrocarbons and other chemicals. Crit Rev Biotechnol 22:245–279
Borowitzka MA (1999) Commercial production of microalgae: ponds, tanks, tubes and fermenters. J Biotechnol 70:313–321
Casadevall E, Dif D, Largeau C (1985) Studies on batch and continuous cultures of Botryococcus braunii: hydrocarbon production in relation to physiological state, cell ultrastructure, and phosphate nutrition. Biotechnol Bioeng 27:286–295
Chisti Y (2007) Biodiesel from microalgae. Biotechnol Adv 25:294–306
Choi G, Kim B, Ahn C, Oh H (2010) Effect of nitrogen limitation on oleic acid biosynthesis in Botryococcus braunii. J Appl Phycol 23:1031–1037
Dayananda C, Kumudha A, Sarada R, Ravishankar GA (2010) Isolation, characterization and outdoor cultivation of green microalgae Botryococcus sp. Sci Res Essays 5:2497–2505
Eroglu E, Okada S, Melis A (2011) Hydrocarbon productivities in different Botryococcus strains: comparative methods in product quantification. J Appl Phycol 23:763–775
Guillard RR, Ryther JH (1962) Studies of marine planktonic diatoms. I. Cyclotella nana Hustedt, and Detonula confervacea (cleve) Gran. Can J Microbiol 8:229–239
Kalacheva GS, Zhila NO, Volova TG (2001) Lipids of the green alga Botryococcus cultured in a batch mode. Microbiology 70:256–262
Kochert G (1978) Handbook of phycological methods. Cambridge University Press, London
Kojima E, Zhang K (1999) Growth and hydrocarbon production of microalga Botryococcus braunii in bubble column photobioreactors. J Biosci Bioeng 87:811–815
Lee SJ, Kim S, Kim H, Kwon G, Yoon B, Oh H (1999) Mass cultivation of Botryococcus braunii for the advanced treatment of swine wastewater and lipid production in a photobioreactor. Korean J Appl Microbiol Biotechnol 27:166–171
Lepage G, Roy CC (1984) Improved recovery of fatty acid through direct transesterification without prior extraction or purification. J Lipid Res 25:1391–1396
Metzger P, Largeau C (1999) Chemicals of Botryococcus braunii. In: Cohen Z (ed) Chemicals from microalgae. Taylor & Francis, London, pp 205–260
Niitsu R, Kanazashi M, Matsuwaki I, Ikegami Y, Tanoi T, Kawachi M, Watanabe MM, Kato M (2011) Changes in the hydrocarbon-synthesizing activity during growth of Botryococcus braunii B70. Bioresour Technol. doi:10.1016/j.biortech.2011.08.072
Okada S, Murakami M, Yamaguchi K (1995) Hydrocarbon composition of newly isolated strains of the green microalga Botryococcus braunii. J Appl Phycol 7:555–559
Pulz O, Gross W (2004) Valuable products from biotechnology of microalgae. Appl Microbiol Biotechnol 65:635–648
Rodolfi L, Chini Zittelli G, Bassi N, Padovani G, Biondi N, Bonini G, Tredici M (2009) Microalgae for Oil: Strain Selection, Induction of Lipid Synthesis and Outdoor Mass Cultivation in a Low-Cost Photobioreactor. Biotechnol Bioeng 102: 100–112
Ruangsomboon S (2011) Effect of light, nutrient, cultivation time and salinity on lipid production of newly isolated strain of the green microalga, Botryococcus braunii KMITL 2. Bioresour Technol. doi:10.1016/j.biortech.2011.07.025
Singh Y (2003) Photosynthetic activity, and lipid and hydrocarbon production by alginate-immobilized cells of Botryococcus in relation to growth phase. J Microbiol Biotechnol 13:687–691
Weetall HH (1985) Studies on the nutritional requirements of the oil-producing alga Botryococcus braunii. Appl Biochem Biotechnol 11:377–391
Yeesang C, Cheirsilp B (2011) Effect of nitrogen, salt, and iron content in the growth medium and light intensity on lipid production by microalgae isolated from freshwater sources in Thailand. Bioresour Technol 102:3034–3040
Zhang H, Wang W, Li Y, Yang W, Shen G (2011) Mixotrophic cultivation of Botryococcus braunii. Biomass Bioenerg 35:1710–1715
Zhila NO, Kalacheva GS, Volova TG (2011) Effect of salinity on the biochemical composition of the alga Botryococcus braunii Kütz IPPAS H-252. J Appl Phycol 23:47–52
This research was supported by the project “Optimization and biotechnological improvement of culture conditions B. braunii for the production of Bio-Oil” funded by Fondef-CONICYT.
About this article
Cite this article
Bazaes, J., Sepulveda, C., Acién, F.G. et al. Outdoor pilot-scale production of Botryococcus braunii in panel reactors. J Appl Phycol 24, 1353–1360 (2012). https://doi.org/10.1007/s10811-012-9787-3
- Botryococcus braunii
- Pilot scale