Abstract
The paper is devoted to substantiation and prediction of the allowable gas temperature at the outlet from a furnace subject to slagging. The non-optimality of values recommended by effective methodical instructions regarding the design of furnace devices is demonstrated. Utilizing knowledge gained from temperature measurements in boilers, and the situation regarding the slagging of heating surfaces located at the outlet from the furnace, new, frequently higher values are proposed. A method for evaluating the allowable gas temperature at the outlet froma furnace subject to slagging is suggested on the basis of data regarding the chemical composition of the mineral portion of coals.
Similar content being viewed by others
References
A. N. Alekhnovich and V. V. Bogomolov, “Selection of gas temperature at the outlet from a furnace subject to slagging,” Teploénergetika, No. 8 (1994).
E. Kh. Berbovetskii and N. G. Zhmerik (eds.), Methodical Instructions for Design of Furnace Devices in Power-Generation Boilers [in Russian], Izd. VTI-TsKTI, St. Petersburg (1996).
A. A. Abryutin, É. S. Karasina, B. N. Livshits, et al., “Development of a method and program for three-dimensional zonal calculation of heat exchange in the furnace chambers of pulverized-coal-fired boilers,” Teploénergetika, No. 6 (1998).
Heat Analysis of Boiler Units (Standard Method) [in Russian], Izd. NPO TsKTI, St. Petersburg (1998).
V. V. Bogomolov, A. N. Alekhnovich, N. V. Artem’eva, et al., “Results of experimental burning of Kuznetsk coals in the P-57 boiler of an 500-MW unit designed for non-slagging Ékibastuz coal,” in: Mineral Portion of Fuel, Slagging, Contamination, and Cleaning of Boilers. Abstrs. of the Sci.-Tech. Conf. [in Russian], Chelyabinsk (2001).
Heat Analysis of Boiler Units (Standard Method) [in Russian], Énergiya, Moscow (1973).
A. N. Alekhnovich, N. V. Artem’eva, V. V. Bogomolov, and V. A. Rodionov, “Results of investigations of the slagging properties of coals on a heating bench developed by UralVTI,” in: Mineral Portion of Fuel, Slagging, Contamination, and Cleaning of Boilers. Abstrs. of the 3 rd Sci.-Pract. Conf. [in Russian], Chelyabinsk (2001).
A. N. Alekhnovich, N. V. Artem’eva, and V. V. Bogomolov, “Investigations and prediction of the slagging properties of power-generating coals,” in: Improvement in Operational Reliability and Efficiency of Thermomechanical Equipment at Thermoelectric Power Stations [in Russian], Izd. UralVTI-Chelyabé nergoset’proekt, Chelyabinsk (2005).
S. G. Kozlov, V. V. Vasil’ev, S. Yu. Belov, and E. G. Alfimov, “Investigation of the BKZ-500-140-1_boiler operating on reduced excesses of air when fired with Irsha-Borodinsk coal,” in: Improvement in Efficiency and Ecological Safety of Coal-Fired Power Plants in Siberia [in Russian], Izd. SibVTI, Krasnoyarsk (1995).
Author information
Authors and Affiliations
Additional information
__________
Translated from Élektricheskie Stantsii, No. 2, February, 2007, pp. 23–28.
Rights and permissions
About this article
Cite this article
Alekhnovich, A.N., Artem’eva, N.V. & Bogomolov, V.V. Allowable gas temperature at outlet from furnace subject to slagging. Power Technol Eng 41, 105–110 (2007). https://doi.org/10.1007/s10749-007-0023-2
Issue Date:
DOI: https://doi.org/10.1007/s10749-007-0023-2