The corrosion of a glass coating of pipelines in acidic, alkaline, and marine environments was studied. In an acidic environment the corrosion of a pipe coating is very small and the corrosion rate is practically non-existent. In an alkaline environment, initially the leach rate is very low and then sharply increases. In the range pH = 6 – 12, pipe coatings do not have high stability and active leaching of pipe coatings occurs. It was shown experimentally that during long-time operation very small scale deposits are observed on the surface of the glass coatings of pipes, but a significant layer of scale forms in pipes that are not glass-lined.
Similar content being viewed by others
References
Yu. V. Alekseev, “Matching corrosion-resistant pipes to field conditions,” Inzhenernaya praktika, No. 1, 64 – 71 (2012).
V. N. Ivanovskii, “Corrosion of downhole equipment and methods of protection against it,” Korroziya Territorii Neftegaz, No. 1, 50 – 59 (2011).
A. B. Lazarev, “Basic methods of combating corrosion of oilfield equipment,” Inzh. Praktika, No. 8, 18 – 20 (2011).
N. Yu. Ibragimov, “Heat resistance and strength of the silicate coating of pipe,” Chem. Petroleum Eng., 52(1 – 2), 33 – 35 (2016).
OST 26-01-1255–83: Glass Enamel and Glass Crystal Coatings. Test Methods for Corrosion Resistance in Acids and Alkalis [in Russian], Moscow (1995), pp. 87 – 89.
V. S. Aleksandrov and A. G. Dorofeev, “Study of the corrosion resistance of vitrified pipes and pipelines,” Korroziya Zashch. Neftegaz. Prom-sti, No. 1, 14 – 17 (2001).
N. Yu. Ibragimov, “Thermal stability and strength of silicate coating of a pipe,” Khim. Neftegaz. Mashinostr., No. 1, 22 – 24 (2016).
N. Yu. Ibragimov and E. N. Ismaiylova, “Thermal conductivity of layers of scale and corrosion products of pipe coatings on use of seawater,” Énergetik, No. 5, 54 – 56 (2013).
N. Yu. Ibragimov, “Glass coating deposition temperature on the inner surface of heat-exchange tube,” Glass Ceram., 76(5 – 6), 225 – 227 (2019) [Steklo Keram., No. 6, 30 – 32 (2019)].
Author information
Authors and Affiliations
Corresponding author
Additional information
Translated from Steklo i Keramika, No. 5, pp. 14 – 18, May, 2021.
Rights and permissions
About this article
Cite this article
Ibragimov, N.Y. Investigation of Corrosion and Scaling of Glass Coatings on Pipes Used in the Petrochemical Industry. Glass Ceram 78, 184–187 (2021). https://doi.org/10.1007/s10717-021-00375-z
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10717-021-00375-z