Abstract
Two γ-alumina-supported molybdenum oxide catalysts with different Mo loadings were prepared by the impregnation of a precipitated alumina. The alumina support and the supported catalysts were characterized using X-ray diffraction, N2 adsorption and NH3-TPD techniques and tested in the liquid-phase esterification of acetic acid with n-butanol. The effects of the reaction time, of the molar ratio of the reactants, of the speed of agitation and of the mass fraction of the catalyst on the catalytic properties were studied. After only 120 min of reaction at 100 °C with an n-butanol to acetic acid mole ratio equal to 3 the conversion reached 81% in the presence of the supported catalyst containing 10 wt% MoO3 (10Mo–Al2O3 sample). The conversion as well as the total NH3-TPD acidity increased in the following order: Al2O3 < 5Mo−Al2O3 (5 wt% MoO3/Al2O3) < 10Mo–Al2O3. The selectivity of n-butyl acetate was, in all cases, 100%. No loss in catalytic activity and product selectivity after three cycles with 10Mo–Al2O3 catalyst was observed.
Graphical Abstract
Similar content being viewed by others
References
Kirk-Othmer (1994) Encyclopedia of chemical technology, 4th edn., vol 9. Wiley, New York, p 755
Sawant DP, Vinu A, Justus J, Srinivasu P, Halligudi SB (2007) J Mol Catal A Chem 276:150
Liu Y, Lotero E, Goodwin JG Jr (2006) J Catal 242:278
Izci A, Bodur F (2007) React Funct Polym 67:1458
Corma A, Garcia H, Iborra S, Primo J (1989) J Catal 120:78
Zhang HB, Zhang BZ, Li HX (1992) J Nat Gas Chem 49:56
Timofeeva MN, Matrosova MM, Il’inich GN, Reshetenko TV, Avdeeva LB, Kvon RI, Chuvilin AL, Budneva AA, Paukshtis EA, Likholobov VA (2003) Kinet Catal 44:778
Zhang F, Wang J, Yuan C, Ren X (2006) Sci China Ser B Chem 49:140
Bhorodwaj SK, Pathak MG, Dutta DK (2009) Catal Lett 133:185
Chen K, Xie S, Bell AT, Iglesia E (2001) J Catal 198:232
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Mitran, G., Makó, É., Rédey, Á. et al. Esterification of Acetic Acid with n-Butanol Using Molybdenum Oxides Supported on γ-Alumina. Catal Lett 140, 32–37 (2010). https://doi.org/10.1007/s10562-010-0431-z
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10562-010-0431-z