Abstract
Articular cartilage injury is a common type of damage observed in clinical practice. A matrix-induced autologous chondrocyte implant was developed to repair articular cartilage as an advancement on the autologous chondrocyte implant procedure. Here, we establish a thin double layer of collagen as a novel and effective bioscaffold for the regeneration of cartilaginous lesions. We created a collagen membrane with double layers using a cover slip, a cover slip, and the collagen was then freeze-dried under vacuum. Carbodiimide as a crosslinking agent was used to obtain a relatively stable collagen construction. The thickness of the knee joint cartilage from grown rabbits was measured from a frozen section. Both type I and type II collagens were characterized using Sodium dodecylsulfate/polyacrylamide gel electrophoresis (SDS-PAGE) and ultraviolet absorption peaks. The aperture size of the scaffold was observed using a scanning electron microscope (SEM). The degradation of the scaffolds in vitro was tested through digestion using collagenase solution. The mechanical capacity of the scaffolds was assessed under dynamic compression. The influence of the scaffold on chondrocyte proliferation was assessed using the methyl thiazolyl tetrazolium (MTT) colourimetric assay and scanning electron microscopy. The frozen sections of the rabbit femoral condyle showed that the thickness of the weight-bearing area of the articular cartilage was less than 1 mm. The results of the SDS-PAGE and ultraviolet absorption peaks of the collagens were in agreement with the standard photographs in the references. SEM showed that the aperture size of the cross-linked scaffold was 82.14 ± 15.70 μm. The in vitro degradation studies indicated that Carbodiimide cross-linking can effectively enhance the biostability of the scaffolds. The Carbodiimide cross-linking protocol resulted in a mean value for the samples that ranged from 8.72 to 15.95 MPa for the compressive strength. The results of the MTT demonstrated that the scaffold had promoted chondrocyte proliferation and SEM observations showed that the scaffold was a good adhesive and growth material for chondrocytes. Thin type I/II collagen composite scaffold can meet the demands of cartilage tissue engineering and have good biocompatibility.
Similar content being viewed by others
References
Balsly CR, Cotter AT, Williams LA, Gaskins BD, Moore MA, Wolfinbarger L (2008) Effect of low dose and moderate dose gamma irradiation on the mechanical properties of bone and soft tissue allografts. Cell Tissue Bank 9:289–298
Basad E, Wissing FR, Fehrenbach P, Rickert M, Steinmeyer J, Ishaque B (2014) Matrix-induced autologous chondrocyte implantation (MACI) in the knee: clinical outcomes and challenges. Knee Surg Sports Traumatol Arthrosc 23:1–7
Behery OA, Harris JD, Karnes JM, Siston RA, Flanigan DC (2012) Factors influencing the outcome of autologous chondrocyte implantation: a systematic review. J Knee Surg 26:203–211
Bertolo A, Arcolino F, Capossela S, Taddei AR, Baur M, Pötzel T, Stoyanov J (2015) Growth factors cross-linked to collagen microcarriers promote expansion and chondrogenic differentiation of human mesenchymal stem cells. Tissue Eng Part A 21:2618–2628
Chang SJ, Kuo SM, Manousakas I, Niu GC, Chen JP (2009) Preparation and characterization of hyaluronan/collagen II microspheres under an electrostatic field system with disc electrodes. Acta Biomater 5:101–114
Chen G, Sato T, Tanaka J, Tateishi T (2014) Preparation of a biphasic scaffold for osteochondral tissue engineering. Mater Sci Eng C Biomim 96:824–830
Curl WW, Krome J, Gordon ES, Rushing J, Smith BP, Poehling GG (1997) Cartilage injuries: a review of 31,516 knee arthroscopies. Arthroscopy 13:456–460
Ebert JR, Smith A, Fallon M, Butler R, Nairn R, Breidahl W, Wood DJ (2015) Incidence, degree, and development of graft hypertrophy 24 months after matrix-induced autologous chondrocyte implantation: association with clinical outcomes. Am J Sports Med 43:2208–2215
Edwards PK, Ackland T, Ebert JR (2014a) Clinical rehabilitation guidelines for matrix-induced autologous chondrocyte implantation on the tibiofemoral joint. J Orthop Sports Phys Ther 44:102–119
Edwards PK, Ebert JR, Janes GC, Wood D, Fallon M, Ackland T (2014b) Arthroscopic versus open matrix-induced autologous chondrocyte implantation: results and implications for rehabilitation. J Sport Rehabil 23:203–215
Enea D, Cecconi S, Busilacchi A, Manzotti S, Gesuita R, Gigante A (2012) Matrix-induced autologous chondrocyte implantation (MACI) in the knee. Knee Surg Sports Traumatol Arthrosc 20:862–869
Gigante A, Enea D, Greco F, Bait C, Denti M, Schonhuber H, Volpi P (2009) Distal realignment and patellar autologous chondrocyte implantation: mid-term results in a selected population. Knee Surg Sports Traumatol Arthrosc 17:2–10
Gistelinck C, Gioia R, Gagliardi A, Tonelli F, Marchese L, Bianchi L, Landi C, Bini L, Huysseune A, Witten PE, Staes A, Gevaert K, De Rocker N, Menten B, Malfait F, Leikin S, Carra S, Tenni R, Rossi A, De Paepe A, Coucke P, Willaert A, Forlino A (2016) Zebrafish collagen type I: molecular and biochemical characterization of the major structural protein in bone and skin. Sci Rep 6:21540
Grelsamer RP, Dejour D, Gould J (2008) The pathophysiology of patellofemoral arthritis. Orthop Clin North Am 39:269–274
Jones CW, Willers C, Keogh A, Smolinski D, Fick D, Yates PJ, Kirk TB, Zheng MH (2008) Matrix-induced autologous chondrocyte implantation in sheep: objective assessments including confocal arthroscopy. J Orthop Res 26:292
Karageorgiou V, Kaplan D (2005) Porosity of 3D biomaterial scaffolds and osteogenesis. Biomaterials 26:5474–5491
Keeney M, Pandit A (2009) The osteochondral junction and its repair via bi-phasic tissue engineering scaffolds. Tissue Eng Part B 15:55–73
Khor E (1997) Methods for the treatment of collagenous tissues for bioprostheses. Biomaterials 18:95–105
Kontturi LS, Järvinen E, Muhonen V, Collin EC, Pandit AS, Kiviranta I, Yliperttula M, Urtti A (2014) An injectable, in situ forming type II collagen/hyaluronic acid hydrogel vehicle for chondrocyte delivery in cartilage tissue engineering. Drug Deliv Transl Res 4:149–158
Liu K, Dan W, Liu X (2014) Preparation and characterization of collagen type I from pig tendons. China Leather 43:9–18 (in Chinese)
Maslennikova A, Kochueva M, Ignatieva N, Vitkin A, Zakharkina O, Kamensky V, Sergeeva E, Kiseleva E, Bagratashvili V (2015) Effects of gamma irradiation on collagen damage and remodeling. Int J Radiat Biol 91:240–247
Meyerkort D, Ebert JR, Ackland TR, Robertson WB, Fallon M, Zheng MH, Wood DJ (2014) Matrix-induced autologous chondrocyte implantation (MACI) for chondral defects in the patellofemoral joint. Knee Surg Sports Traumatol Arthrosc 22:2522–2530
Mullazehi M, Mathsson L, Lampa J, Rönnelid J (2006) Surface-bound anti-type II collagen-containing immune complexes induce production of tumor necrosis factor alpha, interleukin-1beta, and interleukin-8 from peripheral blood monocytes via Fc gamma receptor IIA: a potential pathophysiologic mechanism for humoral anti-type II collagen immunity in arthritis. Arthritis Rheum 54:1759–1771
Nawaz SZ, Bentley G, Briggs TW, Carrington RW, Skinner JA, Gallagher KR (2014) Autologous chondrocyte implantation in the knee: mid-term to long-term results. J Bone Joint Surg Am 96:824–830
Outerbridge RE (1961) The etiology of chondromalacia patellae. Clin Orthop Relat Res 43:752–757
Qiao X, Russell SJ, Yang X, Tronci G, Wood DJ (2015) Compositional and in vitro evaluation of nonwoven type I collagen/poly-dl-lactic acid scaffolds for bone regeneration. J Funct Biomater 6:667–686
Rault I, Frei V, Herbage D, Abdul-Malak N, Huc A (1996) Evaluation of different chemical methods for cross-linking collagen gel, films and sponges. J Mater Sci Mater Med 7:215–221
Roelofs AJ, Rocke JP, De-Bari C (2013) Cell-based approaches to joint surface repair: a research perspective. Osteoarthr Cartil 21:892–900
Rogowska J, Bryant CM, Brezinski ME (2003) Cartilage thickness measurements from optical coherence tomography. J Opt Soc Am A Opt Image Sci Vis 20:357–367
Sionkowska A (2004) Flash photolysis and pulse radiolysis studies on collagen type I in acetic acid solution. J Photochem Photobiol B 84:38–45
Steinwachs M, Kreuz PC (2007) Autologous chondrocyte implantation in chondral defects of the knee with a type I/III collagen membrane: a prospective study with a 3-year follow-up. Arthrosc J Arthrosc Relat Surg 23:381–387
Tanaka Y (2015) Human mesenchymal stem cells as a tool for joint repair in rheumatoid arthritis. Clin Exp Rheumatol 33:S58–S62
Vijayan S, Bartlett W, Bentley G, Carrington RW, Skinner JA, Pollock RC, Alorjani M, Briggs TW (2012) Autologous chondrocyte implantation for osteochondral lesions in the knee using a bilayer collagen membrane and bone graft: a two-to eight-year follow-up study. J Bone Jt Surg Br 94:488–492
Wakitani S, Goto T, Young RG, Mansour JM, Goldberg VM, Caplan AI (1998) Repair of large full-thickness articular cartilage defects with allograft articular chondrocytes embedded in a collagen gel. Tissue Eng 4:429–444
Wang H, Feng ZT, Zhu JQ, Wu XH, Li J (2014) Identification of Zaocys type II collagen and its effect on arthritis in mice with collagen-induced arthritis. Zhong Yao Cai 37:1020–1024
Willers C, Chen J, Wood D, Xu J, Zheng MH (2005) Autologous chondrocyte implantation with collagen bioscaffold for the treatment of osteochondral defects in rabbits. Tissue Eng 11:1065–1076
Wissink MJ, Beernink R, Pieper JS, Poot AA, Engbers GH, Beugeling T, van Aken WG, Feijen J (2001) Binding and release of basic fibroblast growth factor from heparinized collagen matrices. Biomaterials 22:2291–2299
Wu X, Liu Y, Li X, Wen P, Zhang Y, Long Y, Wang X, Guo Y, Xing F, Gao J (2010) Preparation of aligned porous gelatin scaffolds by unidirectional freeze-drying method. Acta Biomater 6:1167–1177
Zeeman R, Dijkstra PJ, Van-Wachem PB, Van-Luyn MJ, Hendriks M, Cahalan PT, Feijen J (1999) Successive epoxy and carbodiimide cross linking of dermal sheep collagen. Biomaterials 20:921–931
Zhang X, Chen X, Yang T, Zhang N, Dong L, Ma S, Liu X, Zhou M, Li B (2014a) The effects of different crossing-linking conditions of genipin on type I collagen scaffolds: an in vitro evaluation. Cell Tissue Bank 15:531–541
Zhang Z, Zhong X, Ji H, Tang Z, Bai J, Yao M (2014b) Matrix-induced autologous chondrocyte implantation for the treatment of chondral defects of the knees in chinese patients. Drug Des Dev Ther 8:2439–2448
Zhang X, Azuma N, Hagihara S, Adachi S, Ura K, Takagi Y (2016) Characterization of type I and II procollagen α 1chain in Amur sturgeon (Acipenser schrenckii) and comparison of their gene expression. Gene 579:163–171
Acknowledgements
There are no funding sources to report for this submission. Special thanks to Li-dong Zhou and Ai-bing Liu of the central laboratory of the General Hospital of the Chinese People’s Armed Police Forces. The author thanks Lin Wang from Jinzhou Medical University for her help during the experiment.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Han, L., Zhang, Zw., Wang, Bh. et al. Construction and biocompatibility of a thin type I/II collagen composite scaffold. Cell Tissue Bank 19, 47–59 (2018). https://doi.org/10.1007/s10561-017-9653-2
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10561-017-9653-2