Abstract
The objective of this work was to evaluate the feasibility of ethanol production by fermentation of coffee husks by Saccharomyces cerevisiae. Batch fermentation studies were performed employing whole and ground coffee husks, and aqueous extract from ground coffee husks. It was observed that fermentation yield decreased with an increase in yeast concentration. The best results were obtained for the following conditions: whole coffee husks, 3 g yeast/l substrate, temperature of 30°C. Under these conditions ethanol production was 8.49 ± 0.29 g/100 g dry basis (13.6 ± 0.5 g ethanol/l), a satisfactory value in comparison to literature data for other residues such as corn stalks, barley straw and hydrolyzed wheat stillage (5–11 g ethanol/l). Such results indicate that coffee husks present excellent potential for residue-based ethanol production.
Similar content being viewed by others
References
ABNT (1997) Determinação do teor alcoólico (Brazilian Association of Technical Norms—Ethanol content)—NBR 13920. São Paulo: ABNT (in portuguese)
AOAC (1995) Official methods of analysis, 16 edn. AOAC, Washington
Athanasiadis I, Boskou D, Kanellaki M et al (2002) Whey liquid waste of the dairy industry as raw material for potable alcohol production by Kefir granules. J Agric Food Chem 50:7231–7234
Ballesteros M, Oliva JM, Negro MJ, Manzanares P et al (2004) Ethanol from lignocellulosic materials by a simultaneous saccharification and fermentation process (SFS) with Kluyveromyces marxianus CECT 10875. Process Biochem 39:843–848
Belkacemi K, Turcotte G, Savoite P (2002) Aqueous/steam-fractionated agricultural residues as substrates for ethanol production. Res Ind Eng Chem 41:173–179
Davis L, Jeon Y, Svenson C et al (2005) Evaluation of wheat stillage for ethanol production by recombinant Zymomonas mobilis. Biomass Bioenerg 29:49–59
Franca AS, Oliveira LS (2009) Coffee processing solid wastes: current uses and future perspectives. In: Columbus F (ed) Agricultural wastes, Nova Publishers, New York
Mojovié M, Nikolié L, Rakin S et al (2006) Production of bioethanol from corn meal hydrolyzates. Fuel 85:1750–1755
Ohgrem K, Bura R, Lesnicki G et al (2007) A comparison between simultaneous saccharification and fermentation and separate hydrolysis and fermentation using steam-pretreated corn stover. Process Biochem 42:834–839
Oliveira LS, Franca AS, Camargos RRS et al (2008) Coffee oil as a potential feedstock for biodiesel production. Bioresource Technol 99:3244–3250
Saha BC, Cotta MA (2008) Fuel ethanol production from agricultural residues: current status and future prospects. J Biotechnol 136:S285–S286
Tang Y-Q, Koike Y, Liu K et al (2008) Ethanol production from kitchen waste using the flocculating yeast Saccharomyces cerevisiae strain KF-7. Biomass Bioenerg 32:1037–1045
Van Soest PJ, Wine RH (1967) Use of detergents in the analysis of fibrous feeds. IV. Determination of plant cell-wall constituents. J AOAC 50:50–55
Acknowledgments
The authors acknowledge financial support from the following Brazilian Government Agencies: CAPES, CNPq and FAPEMIG.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Gouvea, B.M., Torres, C., Franca, A.S. et al. Feasibility of ethanol production from coffee husks. Biotechnol Lett 31, 1315–1319 (2009). https://doi.org/10.1007/s10529-009-0023-4
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10529-009-0023-4