Abstract
Activated carbon (AC) is widely used as an adsorbent for glycerine purification. However, after prolonged usage, adsorption capacity of the resulted spent AC (SAC) reached saturation which affects its adsorption performances. In this work, the adsorption capability of SAC was restored by thermal and chemical reactivations. Chemical reactivation was carried out at room temperature with 10 M NaOH (CRAC10) which showed the best adsorption capability, concluded by its normalised iodine number which was recorded at 904.15 mg/g. Glycerine purification test showed that free fatty acid, carotenoids, chlorophyll and ash content in crude glycerine were effectively reduced by 38.64%, 40%, 64.29% and 84.65%, respectively after the adsorption by CRAC10. The same sample also contributed to the best performance with 45.46% glycerine purification while the adsorbent dosage was optimized at 20 g/l.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Albert, D.E.: Chapter 4—methods for verifying medical device cleanliness. In: Kohli, R., Mittal, K.L. (eds.) Developments in Surface Contamination and Cleaning, pp. 109–128. William Andrew Publishing, Oxford (2015)
Ardi, M.S., Aroua, M.K., Hashim, N.A.: Progress, prospect and challenges in glycerol purification process: a review. Renew. Sustain. Energy Rev. 42, 1164–1173 (2015). https://doi.org/10.1016/j.rser.2014.10.091
Cazetta, A.L., Junior, O.P., Vargas, A.M.M., da Silva, A.P., Zou, X., Asefa, T., Almeida, V.C.: Thermal regeneration study of high surface area activated carbon obtained from coconut shell: characterization and application of response surface methodology. J. Anal. Appl. Pyrolysis 101, 53–60 (2013). https://doi.org/10.1016/j.jaap.2013.02.013
Claudete Costa, S., Barcelos, R., Magnago, R.: Solid biofuel from glycerol and agricultural waste as a source of energy. Cellul. Chem. Technol. 51, 765–774 (2017)
Cuhadaroglu, D., Aydemir Uygun, O.: Production and characterization of activated carbon from bituminous coal by chemical activation. Afr. J. Biotechnol. 7(20), 3703–3710 (2010)
Dhabhai, R., Ahmadifeijani, E., Dalai, A.K., Reaney, M.: Purification of crude glycerol using a sequential physico-chemical treatment, membrane filtration, and activated charcoal adsorption. Sep. Purif. Technol. 168, 101–106 (2016). https://doi.org/10.1016/j.seppur.2016.05.030
ElShafei, G.M.S., ElSherbiny, I.M.A., Darwish, A.S., Philip, C.A.: Artichoke as a non-conventional precursor for activated carbon: role of the activation process. J. Taibah Univ. Sci. 11(5), 677–688 (2017). https://doi.org/10.1016/j.jtusci.2016.04.006
Fadhil, A., Saleh, L.A., Altamer, D.H.: Production of biodiesel from non-edible oil, wild mustard (Brassica juncea L.) seed oil through cleaner routes. Energy Sources A. https://doi.org/10.1080/15567036.2019.1604893
Fonseca, J.M., Teleken, J.G., de Cinque, A.V., da Silva, C.: Biodiesel from waste frying oils: methods of production and purification. Energy Convers. Manag. 184, 205–218 (2019)
Gomes, M.G., Santos, D.Q., de Morais, L.C., Pasquini, D.: Purification of biodiesel by dry washing, employing starch and cellulose as natural adsorbents. Fuel 155, 1–6 (2015)
Guo, Y., Du, E.: The effects of thermal regeneration conditions and inorganic compounds on the characteristics of activated carbon used in power plant. Energy Procedia 17, 444–449 (2012)
Guo, J., Lua, A.C.: Characterization of adsorbent prepared from oil-palm shell by CO2 activation for removal of gaseous pollutants. Mater. Lett. 55(5), 334–339 (2002)
Herawan, S.G., Ahmad, M.A., Putra, A., Yusof, A.A.: Effect of CO2 flow rate on the Pinang frond-based activated carbon for methylene blue removal. Sci. World J. 2013, 545948 (2013). https://doi.org/10.1155/2013/545948
Huggins, T.M., Haeger, A., Biffinger, J.C., Ren, Z.J.: Granular biochar compared with activated carbon for wastewater treatment and resource recovery. Water Res. 94, 225–232 (2016)
Hunsom, M., Autthanit, C.: Adsorptive purification of crude glycerol by sewage sludge-derived activated carbon prepared by chemical activation with H3PO4, K2CO3 and KOH. Chem. Eng. J. 229, 334–343 (2013). https://doi.org/10.1016/j.cej.2013.05.120
Kongjao, S., Damronglerd, S., Hunsom, M.: Purification of crude glycerol derived from waste used-oil methyl ester plant. Korean J. Chem. Eng. 27(3), 944–949 (2010). https://doi.org/10.1007/s11814-010-0148-0
Kow, S.-H., Fahmi, M.R., Abidin, C.Z.A., Ong, S.-A., Ibrahim, N.: Regeneration of spent activated carbon from industrial application by NaOH solution and hot water. Desalin. Water Treat. 57(60), 29137–29142 (2016)
Li, Q., Qi, Y., Gao, C.: Chemical regeneration of spent powdered activated carbon used in decolorization of sodium salicylate for the pharmaceutical industry. J. Clean. Prod. 86, 424–431 (2015). https://doi.org/10.1016/j.jclepro.2014.08.008
Li, T., Xu, J., Wu, H., Wang, G., Dai, S., Fan, J., He, H., Xiang, W.: A saponification method for chlorophyll removal from microalgae biomass as oil feedstock. Mar. Drugs 14(9), 162 (2016). https://doi.org/10.3390/md14090162
Lu, P.-J., Lin, H.-C., Yu, W.-T., Chern, J.-M.: Chemical regeneration of activated carbon used for dye adsorption. J. Taiwan Inst. Chem. Eng. 42(2), 305–311 (2011). https://doi.org/10.1016/j.jtice.2010.06.001
Maroto-Valer, M.M., Dranca, I., Clifford, D., Lupascu, T., Nastas, R., Leon y Leon CA: Thermal regeneration of activated carbons saturated with ortho- and meta-chlorophenols. Thermochim. Acta 444(2), 148–156 (2006). https://doi.org/10.1016/j.tca.2006.03.004
Mopoung, S., Moonsri, P., Palas, W., Khumpai, S.: Characterization and properties of activated carbon prepared from tamarind seeds by KOH activation for Fe(III) adsorption from aqueous solution. Sci. World J. (2015). https://doi.org/10.1155/2015/415961
Nahm, S.W., Shim, W.G., Park, Y.-K., Kim, S.C.: Thermal and chemical regeneration of spent activated carbon and its adsorption property for toluene. Chem. Eng. J. 210, 500–509 (2012). https://doi.org/10.1016/j.cej.2012.09.023
Ndi Nsami, J., Ketcha Mbadcam, J.: The adsorption efficiency of chemically prepared activated carbon from cola nut shells by ZnCl2 on methylene blue. J. Chem. (2013). https://doi.org/10.1155/2013/469170
Perrich, J.R.: Activated Carbon Adsorption for Wastewater Treatment. CRC Press, Boca Raton (2018)
Pohndorf, R.S., Cadaval, T.R.S., Pinto, L.A.A.: Kinetics and thermodynamics adsorption of carotenoids and chlorophylls in rice bran oil bleaching. J. Food Eng. 185, 9–16 (2016). https://doi.org/10.1016/j.jfoodeng.2016.03.028
Román, S., Ledesma, B., Álvarez-Murillo, A., González, J.F.: Comparative study on the thermal reactivation of spent adsorbents. Fuel. Process. Technol. 116, 358–365 (2013). https://doi.org/10.1016/j.fuproc.2013.07.019
Sabah, E.: Decolorization of vegetable oils: chlorophyll-a adsorption by acid-activated sepiolite. J. Colloid Interface Sci. 310(1), 1–7 (2007). https://doi.org/10.1016/j.jcis.2007.01.044
Sabio, E., González, E., González, J.F., González-Garcı́a CM, Ramiro A, Gañan J: Thermal regeneration of activated carbon saturated with p-nitrophenol. Carbon 42(11), 2285–2293 (2004). https://doi.org/10.1016/j.carbon.2004.05.007
Santos, F.D., da Conceição, L.R.V., Ceron, A., de Castro, H.F.: Chamotte clay as potential low cost adsorbent to be used in the palm kernel biodiesel purification. Appl. Clay Sci. 149, 41–50 (2017)
Silva, S.M., Sampaio, K.A., Ceriani, R., Verhé, R., Stevens, C., De Greyt, W., Meirelles, A.J.A.: Adsorption of carotenes and phosphorus from palm oil onto acid activated bleaching earth: equilibrium, kinetics and thermodynamics. J. Food Eng. 118(4), 341–349 (2013). https://doi.org/10.1016/j.jfoodeng.2013.04.026
So, J.-Y., Cho, H.-R.: Thermal characteristics of spent activated carbon generated from air cleaning units in Korean nuclear power plants. Nucl. Eng. Technol. 49(4), 873–880 (2017). https://doi.org/10.1016/j.net.2017.01.020
Soleimani, M., Kaghazchi, T.: Gold recovery from loaded activated carbon using different solvents. J. Chin. Inst. Chem. Eng. 39(1), 9–11 (2008). https://doi.org/10.1016/j.jcice.2007.11.004
Strebeyko, P.: Size and power of chlorophyll a molecule. Photosynthetica 38(1), 159–160 (2000). https://doi.org/10.1023/A:1026720729911
Sutter, L.L., Bentz, D.P.: Chapter 9—assessing ash quality and performance. In: Robl, T., Oberlink, A., Jones, R. (eds.) Coal Combustion Products (CCP’s), pp. 225–254. Woodhead Publishing, Cambridge (2017)
Ulfah, M., Raharjo, S., Hastuti, P., Darmadji, P.: Adsorption of β-carotene in isopropyl alcohol with decolorized activated carbon as model for β-carotene adsorption in crude palm oil. Indones. J. Chem. 17(1), 105–112 (2017)
Yakout, S.M., Sharaf El-Deen, G.: Characterization of activated carbon prepared by phosphoric acid activation of olive stones. Arab. J. Chem. 9, S1155–S1162 (2016). https://doi.org/10.1016/j.arabjc.2011.12.002
Yin, C.Y., Aroua, M.K., Daud, W.M.A.W.: Review of modifications of activated carbon for enhancing contaminant uptakes from aqueous solutions. Sep. Purif. Technol. 52(3), 403–415 (2007). https://doi.org/10.1016/j.seppur.2006.06.009
Acknowledgements
The authors would like to acknowledge the financial support provided by USM RU Top-Down (870051) and Ministry of Education PPRN 2.0 (6314057), as well as to express their gratitude to Wilmar Industries and IOI AcidChem for providing spent activated carbon and crude glycerine respectively.
Author information
Authors and Affiliations
Corresponding author
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Khok, YT., Ooi, CH., Matsumoto, A. et al. Reactivation of spent activated carbon for glycerine purification. Adsorption 26, 1015–1025 (2020). https://doi.org/10.1007/s10450-020-00210-x
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10450-020-00210-x