Abstract
The objective of this study was to evaluate the delivery of inhaled pharmaceutical aerosols using an enhanced condensational growth (ECG) approach in an airway model extending from the oral cavity to the end of the tracheobronchial (TB) region. The geometry consisted of an elliptical mouth-throat (MT) model, the upper TB airways extending to bifurcation B3, and a subsequent individual path model entering the right lower lobe of the lung. Submicrometer monodisperse aerosols with diameters of 560 and 900 nm were delivered to the mouth inlet under control (25 °C with subsaturated air) or ECG (39 or 42 °C with saturated air) conditions. Flow fields and droplet characteristics were simulated using a computational fluid dynamics model that was previously demonstrated to accurately predict aerosol size growth and deposition. Results indicated that both the control and ECG delivery cases produced very little deposition in the MT and upper TB model (approximately 1%). Under ECG delivery conditions, large size increases of the aerosol droplets were observed resulting in mass median aerodynamic diameters of 2.4–3.3 μm exiting B5. This increase in aerosol size produced an order of magnitude increase in aerosol deposition within the TB airways compared with the controls, with TB deposition efficiencies of approximately 32–46% for ECG conditions. Estimates of downstream pulmonary deposition indicted near full lung retention of the aerosol during ECG delivery. Furthermore, targeting the region of TB deposition by controlling the inlet temperature conditions and initial aerosol size also appeared possible.
Similar content being viewed by others
References
Asgharian, B., and O. T. Price. Airflow distribution in the human lung and its influence on particle deposition. Inhal. Toxicol. 18:795–801, 2006.
Asgharian, B., O. T. Price, and W. Hofmann. Prediction of particle deposition in the human lung using realistic models of lung ventilation. Aerosol Sci. 37:1209–1221, 2006.
Azarmi, S., W. H. Roa, and R. Lobenberg. Targeted delivery of nanoparticles for the treatment of lung diseases. Adv. Drug Deliv. Rev. 60:863–875, 2008.
Borgstrom, L., B. Olsson, and L. Thorsson. Degree of throat deposition can explain the variability in lung deposition of inhaled drugs. J. Aerosol Med. 19:473–483, 2006.
Byron, P. R. Drug delivery devices: issues in drug development. Proc. Am. Thorac. Soc. 1:321–328, 2004.
Chan, T. L., and M. Lippmann. Experimental measurements and empirical modeling of the regional deposition of inhaled particles in humans. Am. Ind. Hyg. Assoc. J. 41:399–409, 1980.
Cheng, Y. S. Aerosol deposition in the extrathoracic region. Aerosol Sci. Technol. 37:659–671, 2003.
Cheng, K. H., Y. S. Cheng, H. C. Yeh, and D. L. Swift. Measurements of airway dimensions and calculation of mass transfer characteristics of the human oral passage. J. Biomech. Eng. 119:476–482, 1997.
Cheng, Y. S., C. S. Fu, D. Yazzie, and Y. Zhou. Respiratory deposition patterns of salbutamol pMDI with CFC and HFA-134a formulations in a human airway replica. J. Aerosol Med. 14(2):255–266, 2001.
Ferron, G. A., B. Haider, and W. G. Kreyling. Conditions for measuring supersaturation in the human lung using aerosols. J. Aerosol Sci. 15:211–215, 1984.
Ferron, G. A., G. Oberdorster, and R. Hennenberg. Estimation of the deposition of aerosolised drugs in the human respiratory tract due to hygroscopic growth. J. Aerosol Med. 2:271, 1989.
Finlay, W. H. Estimating the type of hygroscopic behavior exhibited by aqueous droplets. J. Aerosol Med. 11(4):221–229, 1998.
Finlay, W. H., and A. R. Martin. Recent advances in predictive understanding of respiratory tract deposition. J. Aerosol Med. Pulm. Drug Deliv. 21(2):189–205, 2008.
Gemci, T., V. Ponyavin, Y. Chen, H. Chen, and R. Collins. Computational model of airflow in upper 17 generations of human respiratory tract. J. Biomech. 41(9):2047–2054, 2008.
Hammersley, J. R., and D. E. Olson. Physical models of the smaller pulmonary airways. J. Appl. Physiol. 72:2402–2414, 1992.
Heistracher, T., and W. Hofmann. Physiologically realistic models of bronchial airway bifurcations. J. Aerosol Sci. 26(3):497–509, 1995.
Hindle, M., and P. W. Longest. Evaluation of enhanced condensational growth (ECG) for controlled respiratory drug delivery in a mouth-throat and upper tracheobronchial model. Pharm. Res. 27:1800–1811, 2010.
Horsfield, K., G. Dart, D. E. Olson, and G. Cumming. Models of the human bronchial tree. J. Appl. Physiol. 31:207–217, 1971.
ICRP. Human Respiratory Tract Model for Radiological Protection. New York: Elsevier Science Ltd., 1994.
Jaques, P. A., and C. S. Kim. Measurement of total lung deposition of inhaled ultrafine particles in healthy men and women. Inhal. Toxicol. 12(8):715–731, 2000.
Kim, C. S. Deposition of aerosol particles in human lungs: in vivo measurement and modeling. Biomarkers 14(S1):54–58, 2009.
Kleinstreuer, C., and Z. Zhang. An adjustable triple-bifurcation unit model for air–particle flow simulations in human tracheobronchial airways. J. Biomech. Eng. 131:021007, 2009.
Koblinger, L., and W. Hofmann. Monte Carlo modeling of aerosol deposition in human lungs. Part I: simulation of particle transport in a stochastic lung structure. J. Aerosol Sci. 21(5):661–674, 1990.
Lai, S. K., Y.-Y. Wang, and J. Hanes. Mucus-penetrating nanoparticles for drug and gene delivery to mucosal tissues. Adv. Drug Deliv. Rev. 61:158–171, 2009.
Li, Z., C. Kleinstreuer, and Z. Zhang. Particle deposition in the human tracheobronchial airways due to transient inspiratory flow patterns. Aerosol Sci. 38:625–644, 2007.
Lin, C.-L., M. H. Tawhai, G. McLennan, and E. A. Hoffman. Characteristics of the turbulent laryngeal jet and its effect on airflow in the human intra-thoracic airways. Respir. Physiol. Neurobiol. 157:295–309, 2007.
Lin, C.-L., M. H. Tawhai, G. McLennan, and E. A. Hoffman. Multiscale simulation of gas flow in subject-specific models of the human lung. IEEE Eng. Med. Biol. 28:25–33, 2009.
Longest, P. W., and M. Hindle. Evaluation of the Respimat Soft Mist inhaler using a concurrent CFD and in vitro approach. J. Aerosol Med. Pulm. Drug Deliv. 22(2):99–112, 2009.
Longest, P. W., and M. Hindle. CFD simulations of enhanced condensational growth (ECG) applied to respiratory drug delivery with comparisons to in vitro data. J. Aerosol Sci. 41:805–820, 2010.
Longest, P. W., and M. J. Oldham. Mutual enhancements of CFD modeling and experimental data: a case study of one micrometer particle deposition in a branching airway model. Inhal. Toxicol. 18(10):761–772, 2006.
Longest, P. W., and S. Vinchurkar. Effects of mesh style and grid convergence on particle deposition in bifurcating airway models with comparisons to experimental data. Med. Eng. Phys. 29(3):350–366, 2007.
Longest, P. W., and S. Vinchurkar. Validating CFD predictions of respiratory aerosol deposition: effects of upstream transition and turbulence. J. Biomech. 40:305–316, 2007.
Longest, P. W., and J. Xi. Effectiveness of direct Lagrangian tracking models for simulating nanoparticle deposition in the upper airways. Aerosol Sci. Technol. 41:380–397, 2007.
Longest, P. W., and J. Xi. Condensational growth may contribute to the enhanced deposition of cigarette smoke particles in the upper respiratory tract. Aerosol Sci. Technol. 42:579–602, 2008.
Longest, P. W., M. Hindle, S. Das Choudhuri, and P. R. Byron. Numerical simulations of capillary aerosol generation: CFD model development and comparisons with experimental data. Aerosol Sci. Technol. 41:952–973, 2007.
Longest, P. W., M. Hindle, S. Das Choudhuri, and J. Xi. Comparison of ambient and spray aerosol deposition in a standard induction port and more realistic mouth-throat geometry. J. Aerosol Sci. 39:572–591, 2008.
Longest, P. W., M. Hindle, and S. Das Choudhuri. Effects of generation time on spray aerosol transport and deposition in models of the mouth-throat geometry. J. Aerosol Med. Pulm. Drug Deliv. 22(3):67–84, 2009.
Longest, P. W., J. T. McLeskey, and M. Hindle. Characterization of nanoaerosol size change during enhanced condensational growth. Aerosol Sci. Technol. 44:473–483, 2010.
Ma, B., and K. R. Lutchen. CFD simulations of aerosol deposition in an anatomically based human large-medium airway model. Ann. Biomed. Eng. 37(2):271–285, 2009.
Martonen, T. B., Y. Yang, and Z. Q. Xue. Influences of cartilaginous rings on tracheobronchial fluid dynamics. Inhal. Toxicol. 6(3):185–198, 1994.
Matida, E. A., W. H. Finlay, and L. B. Grgic. Improved numerical simulation of aerosol deposition in an idealized mouth-throat. J. Aerosol Sci. 35:1–19, 2004.
Matida, E. A., W. H. Finlay, M. Breuer, and C. F. Lange. Improving prediction of aerosol deposition in an idealized mouth using large-eddy simulation. J. Aerosol Med. 19(3):290–300, 2006.
Newman, S. Respiratory Drug Delivery: Essential Theory and Practice. Richmond: RDD Online, 2009.
Nikander, K., I. Prince, S. Coughlin, S. Warren, and G. Taylor. Mode of breathing-tidal or slow and deep-through the I-neb adaptive delivery (ADD) system affects lung deposition of 99mTc-DTPA. J. Aerosol Med. 23(S1):S37–S43, 2010.
Phalen, R. F., H. C. Yeh, G. M. Schum, and O. G. Raabe. Application of an idealized model to morphometry of the mammalian tracheobronchial tree. Anat. Rec. 190:167–176, 1978.
Robinson, R. J., J. Russo, and R. L. Doolittle. 3D airway reconstruction using visible human data set and human casts with comparison to morphometric data. Anat. Rec. 292:1028–1044, 2009.
Russo, J., R. Robinson, and M. J. Oldham. Effects of cartilage rings on airflow and particle deposition in the trachea and main bronchi. Med. Eng. Phys. 30:581–589, 2008.
Schroeter, J. D., C. J. Musante, D. M. Hwang, R. Burton, R. Guilmette, and T. B. Martonen. Hygroscopic growth and deposition of inhaled secondary cigarette smoke in human nasal pathways. Aerosol Sci. Technol. 34(1):137–143, 2001.
Smaldone, G. C. Advances in aerosols: adult respiratory disease. J. Aerosol Med. 19(1):36–46, 2006.
Stahlhofen, W., G. Rudolf, and A. C. James. Intercomparison of experimental regional aerosol deposition data. J. Aerosol Med. 2(3):285–308, 1989.
Sung, J. C., B. L. Pulliam, and D. A. Edwards. Nanoparticles for drug delivery to the lungs. Trends Biotechnol. 25:563–570, 2007.
Vinchurkar, S., and P. W. Longest. Evaluation of hexahedral, prismatic and hybrid mesh styles for simulating respiratory aerosol dynamics. Comput. Fluids 37:317–331, 2008.
Vinchurkar, S., P. W. Longest, and J. Peart. CFD simulations of the Andersen cascade impactor: model development and effects of aerosol charge. J. Aerosol Sci. 40:807–822, 2009.
Xi, J., and P. W. Longest. Transport and deposition of micro-aerosols in realistic and simplified models of the oral airway. Ann. Biomed. Eng. 35(4):560–581, 2007.
Xi, J., and P. W. Longest. Effects of oral airway geometry characteristics on the diffusional deposition of inhaled nanoparticles. ASME J. Biomech. Eng. 130:011008, 2008.
Xi, J., P. W. Longest, and T. B. Martonen. Effects of the laryngeal jet on nano- and microparticle transport and deposition in an approximate model of the upper tracheobronchial airways. J. Appl. Physiol. 104:1761–1777, 2008.
Xie, Y., P. Zeng, R. Siegel, T. S. Wiedmann, B. E. Hammer, and P. W. Longest. Magnetic deposition of aerosols composed of aggregated superparamagnetic nanoparticles. Pharm. Res. 27(5):855–865, 2010.
Yeh, H. C., and G. M. Schum. Models of human lung airways and their application to inhaled particle deposition. Bull. Math. Biol. 42:461–480, 1980.
Yin, Y., J. Choi, E. A. Hoffman, M. H. Tawhai, and C.-L. Lin. Simulation of pulmonary air flow with a subject-specific boundary condition. J. Biomech. 43:2159–2163, 2010.
Zhang, Y., and W. H. Finlay. Measurement of the effect of cartilaginous rings on particle deposition in a proximal lung bifurcation model. Aerosol Sci. Technol. 39:394–399, 2005.
Zhang, Z., C. Kleinstreuer, and C. S. Kim. Water vapor transport and its effects on the deposition of hygroscopic droplets in a human upper airway model. Aerosol Sci. Technol. 40:52–67, 2006.
Zhang, Y., K. Gilbertson, and W. H. Finlay. In vivo–in vitro comparison of deposition in three mouth-throat models with Qvar and Turbuhaler inhalers. J. Aerosol Med. 20(3):227–235, 2007.
Zhang, Z., C. Kleinstreuer, and C. S. Kim. Comparison of analytical and CFD models with regard to micron particle deposition in a human 16-generation tracheobronchial airway model. Aerosol Sci. 40:16–28, 2009.
Zhou, Y., and Y. S. Cheng. Particle deposition in a cast of human tracheobronchial airways. Aerosol Sci. Technol. 39:492–500, 2005.
Acknowledgments
This study was supported by Award Number R21 HL094991 from the National Heart, Lung, And Blood Institute. The content is solely the responsibility of the authors and does not necessarily represent the official views of the National Heart, Lung, And Blood Institute or the National Institutes of Health.
Author information
Authors and Affiliations
Corresponding author
Additional information
Associate Editor Kenneth R. Lutchen oversaw the review of this article.
Rights and permissions
About this article
Cite this article
Tian, G., Longest, P.W., Su, G. et al. Characterization of Respiratory Drug Delivery with Enhanced Condensational Growth using an Individual Path Model of the Entire Tracheobronchial Airways. Ann Biomed Eng 39, 1136–1153 (2011). https://doi.org/10.1007/s10439-010-0223-z
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10439-010-0223-z