Advertisement

Acta Mechanica Sinica

, Volume 34, Issue 5, pp 839–854 | Cite as

Lagrangian-based numerical investigation of aerodynamic performance of an oscillating foil

  • Mengjie Zhang
  • Qin Wu
  • Biao Huang
  • Guoyu Wang
Research Paper
  • 102 Downloads

Abstract

The dynamic stall problem for blades is related to the general performance of wind turbines, where a varying flow field is introduced with a rapid change of the effective angle of attack (AOA). The objective of this work is to study the aerodynamic performance of a sinusoidally oscillating NACA0012 airfoil. The coupled \(k{-}\omega \) Menter’s shear stress transport (SST) turbulence model and \(\gamma {-}Re_{\uptheta }\) transition model were used for turbulence closure. Lagrangian coherent structures (LCS) were utilized to analyze the dynamic behavior of the flow structures. The computational results were supported by the experiments. The results indicated that this numerical method can well describe the dynamic stall process. For the case with reduced frequency \(K = 0.1\), the lift and drag coefficients increase constantly with increasing angle prior to dynamic stall. When the AOA reaches the stall angle, the lift and drag coefficients decline suddenly due to the interplay between the first leading- and trailing-edge vortex. With further increase of the AOA, both the lift and drag coefficients experience a secondary rise and fall process because of formation and shedding of the secondary vortex. The results also reveal that the dynamic behavior of the flow structures can be effectively identified using the finite-time Lyapunov exponent (FTLE) field. The influence of the reduced frequency on the flow structures and energy extraction efficiency in the dynamic stall process is further discussed. When the reduced frequency increases, the dynamic stall is delayed and the total energy extraction efficiency is enhanced. With \(K = 0.05\), the amplitude of the dynamic coefficients fluctuates more significantly in the poststall process than in the case of \(K = 0.1\).

Keywords

Oscillating foil Dynamic stall Lagrangian coherent structures Computational fluid dynamics (CFD) 

List of symbols

\(\mu \)

Dynamic viscosity \((\hbox {kg}/\hbox {m} {\cdot } \hbox {s})\)

\(u_{i}\)

Velocity in the i-th direction (m/s)

x

Position (m)

k

Turbulent kinetic energy \((\hbox {m}^{2}/\hbox {s}^{2})\)

\(\omega \)

Specific turbulent dissipation rate (1/s)

Re

Reynolds number

w

Angular velocity (1/s)

\(\delta \)

Lyapunov exponent

\(\omega _{z}\)

z-vorticity (1/s)

Q

Second invariant of velocity gradient tensor (\(1/\hbox {s}^{2}\))

\(\Delta {t}\)

Time step (s)

M(t)

Torque \((\hbox {N}{\cdot }\hbox {m})\)

T

Time period of one cycle (s)

\(w_\mathrm{p}(t)\)

Pitching angular velocity (1/s)

\(\rho \)

Density (\(\hbox {kg/m}^{3}\))

Notes

Acknowledgements

This work was supported by the National Postdoctoral Program for Innovative Talents (Grant BX201700126), the China Postdoctoral Science Foundation (Grant 2017M620043), the National Natural Science Foundation of China (Grants 51679005 and 91752105), and the National Natural Science Foundation of Beijing (Grant 3172029).

References

  1. 1.
    Melício, R., Mendes, V.M.F., Catalão, J.P.S.: Transient analysis of variable-speed wind turbines at wind speed disturbances and a pitch control malfunction. Appl. Energy 88, 1322–1330 (2011)CrossRefGoogle Scholar
  2. 2.
    González, L.G., Figueres, E., Garcerá, G., et al.: Maximum-power-point tracking with reduced mechanical stress applied to wind-energy-conversion-systems. Appl. Energy 87, 2304–2312 (2010)CrossRefGoogle Scholar
  3. 3.
    Karbasian, H.R., Esfahani, J.A., Barati, E.: The power extraction by flapping foil hydrokinetic turbine in swing arm mode. Renew. Energy 88, 130–142 (2016)CrossRefGoogle Scholar
  4. 4.
    Hang, L., Zhou, D., Lu, J., et al.: The impact of pitch motion of a platform on the aerodynamic performance of a floating vertical axis wind turbine. Energy 119, 369–383 (2017)CrossRefGoogle Scholar
  5. 5.
    Mckenna, R., Leye, P.O.V.D., Fichtner, W.: Key challenges and prospects for large wind turbines. Renew. Sustain. Energy Rev. 53, 1212–1221 (2016)CrossRefGoogle Scholar
  6. 6.
    Lu, K., Xie, Y., Zhang, D., et al.: Systematic investigation of the flow evolution and energy extraction performance of a flapping-airfoil power generator. Energy 89, 138–147 (2015)CrossRefGoogle Scholar
  7. 7.
    Huang, B., Wu, Q., Wang, G.Y.: Numerical simulation of unsteady cavitating flows around a transient pitching hydrofoil. Sci. China Technol. Sci. 57, 101–116 (2014)CrossRefGoogle Scholar
  8. 8.
    Lee, T.: Effect of flap motion on unsteady aerodynamic loads. J. Aircr. 44, 334–338 (2015)Google Scholar
  9. 9.
    Birch, D.M., Lee, T.: Tip vortex behind a wing undergoing deep-stall oscillation. AIAA J. 43, 2081–2092 (2015)CrossRefGoogle Scholar
  10. 10.
    Liu, T.T., Huang, B., Wang, G.Y., et al.: Experimental investigation of the flow pattern for ventilated partial cavitating flows with effect of Froude number and gas entrainment. Ocean Eng. 129, 343–351 (2017)CrossRefGoogle Scholar
  11. 11.
    Wang, Y.W., Xu, C., Wu, X.C., et al.: Ventilated cloud cavitating flow around a blunt body close to the free surface. Phys. Rev. Fluids 2, 084303 (2017)CrossRefGoogle Scholar
  12. 12.
    Long, X.P., Cheng, H.Y., Ji, B., et al.: Large eddy simulation and Euler–Lagrangian coupling investigation of the transient cavitating turbulent flow around a twisted hydrofoil. Int. J. Multiph. Flow 100, 41–56 (2018)MathSciNetCrossRefGoogle Scholar
  13. 13.
    Wang, G.Y., Wu, Q., Huang, B.: Dynamics of cavitation–structure interaction. Acta Mech. Sin. 33, 685–708 (2017)CrossRefGoogle Scholar
  14. 14.
    Huang, B., Zhao, Y., Wang, G.Y.: Large eddy simulation of turbulent vortex-cavitation interactions in transient sheet/cloud cavitating flows. Comput. Fluids 92, 113–124 (2014)CrossRefGoogle Scholar
  15. 15.
    Choudhry, A., Arjomandi, M., Kelso, R.: Methods to control dynamic stall for wind turbine applications. Renew. Energy 86, 26–37 (2016)CrossRefGoogle Scholar
  16. 16.
    Hameed, M.S., Afaq, S.K.: Design and analysis of a straight bladed vertical axis wind turbine blade using analytical and numerical techniques. Ocean Eng. 57, 248–255 (2013)CrossRefGoogle Scholar
  17. 17.
    Huang, B., Young, Y.L., Wang, G.Y., et al.: Combined experimental and computational investigation of unsteady structure of sheet/cloud cavitation. J. Fluids Eng. Trans. ASME 135, 071301 (2013)CrossRefGoogle Scholar
  18. 18.
    Ferreira, C.S., Bussel, G.V., Kuik, G.V.: 2D CFD simulation of dynamic stall on a vertical axis wind turbine: verification and validation with PIV measurements. In: 45th AIAA Aerospace Sciences Meeting and Exhibit (2006)Google Scholar
  19. 19.
    Wernert, P., Geissler, W., Raffel, M., et al.: Experimental and numerical investigations of dynamic stall on a pitching airfoil. AIAA J. 34, 982–989 (1996)CrossRefGoogle Scholar
  20. 20.
    Lee, T., Gerontakos, P.: Investigation of flow over an oscillating airfoil. J. Fluid Mech. 512, 313–341 (2004)CrossRefGoogle Scholar
  21. 21.
    Carr, L.W.: Progress in analysis and prediction of dynamic stall. J. Aircr. 25, 6–17 (1988)CrossRefGoogle Scholar
  22. 22.
    Ekaterinaris, J.A., Platzer, M.F.: Computational prediction of airfoil dynamic stall. Prog. Aerosp. Sci. 33, 759–846 (1997)CrossRefGoogle Scholar
  23. 23.
    Simpson, B.J., Hover, F.S., Triantafyllou, M.S.: Experiments in direct energy extraction through flapping foils. in: the Eighteenth International Offshore and Polar Engineering Conference, 2008Google Scholar
  24. 24.
    Shehata, A.S., Xiao, Q., Saqr, K.M., et al.: Passive flow control for aerodynamic performance enhancement of airfoil with its application in wells turbine—under oscillating flow condition. Ocean Eng. 136, 31–53 (2017)CrossRefGoogle Scholar
  25. 25.
    Tseng, C.C., Hu, H.A.: Dynamic behaviors of the flow past a pitching foil based on Eulerian and Lagrangian viewpoints. AIAA J. 54, 712–727 (2016)CrossRefGoogle Scholar
  26. 26.
    Ducoin, A., Astolfi, J.A., Deniset, F., et al.: Computational and experimental investigation of flow over a transient pitching hydrofoil. Eur. J. Mech. B Fluids 28, 728–743 (2009)MathSciNetCrossRefGoogle Scholar
  27. 27.
    Bhat, S.S., Govardhan, R.N.: Stall flutter of NACA 0012 airfoil at low Reynolds numbers. J. Fluids Struct. 41, 166–174 (2013)CrossRefGoogle Scholar
  28. 28.
    Wang, S., Ingham, D.B., Ma, L., et al.: Numerical investigations on dynamic stall of low Reynolds number flow around oscillating airfoils. Comput. Fluids 39, 1529–1541 (2010)CrossRefGoogle Scholar
  29. 29.
    Huang, B., Ducoin, A., Young, L.Y.: Physical and numerical investigation of cavitating flows around a pitching hydrofoil. Phys. Fluids 25, 102109 (2013)CrossRefGoogle Scholar
  30. 30.
    Chen, Y.L., Zhan, J.P., Wu, J., et al.: A fully-activated flapping foil in wind gust: energy harvesting performance investigation. Ocean Eng. 138, 112–122 (2017)CrossRefGoogle Scholar
  31. 31.
    Teng, L., Deng, J., Pan, D., et al.: Effects of non-sinusoidal pitching motion on energy extraction performance of a semi-active flapping foil. Renew. Energy 85, 810–818 (2016)CrossRefGoogle Scholar
  32. 32.
    Lai, J.C.S., Platzer, M.F.: Jet characteristics of a plunging airfoil. AIAA J. 37, 1529–1537 (2015)CrossRefGoogle Scholar
  33. 33.
    Gharali, K., Johnson, D.A.: Dynamic stall simulation of a pitching airfoil under unsteady freestream velocity. J. Fluids Struct. 42, 228–244 (2013)CrossRefGoogle Scholar
  34. 34.
    Guo, Q., Zhou, L., Wang, Z.: Comparison of BEM-CFD and full rotor geometry simulations for the performance and flow field of a marine current turbine. Renew. Energy 75, 640–648 (2015)CrossRefGoogle Scholar
  35. 35.
    Wu, Q., Wang, Y.N., Wang, G.Y.: Experimental investigation of cavitating flow-induced vibration of hydrofoils. Ocean Eng. 144, 50–60 (2017)CrossRefGoogle Scholar
  36. 36.
    Wu, Q., Huang, B., Wang, G.Y., et al.: Experimental and numerical investigation of hydroelastic response of a flexible hydrofoil in cavitating flow. Int. J. Multiph. Flow 74, 19–33 (2015)CrossRefGoogle Scholar
  37. 37.
    Menter, F,R.: Improved two-equation \(k-\omega \) turbulence models for aerodynamic flows. NASA Tech. Memo. 34, 103975 (1992)Google Scholar
  38. 38.
    Langtry, R.B., Menter, F.R., Likki, S.R., et al.: A correlation-based transition model using local variables-part I: model formulation. J. Turbomach. 128, 413–422 (2006)CrossRefGoogle Scholar
  39. 39.
    Langtry, R.B., Menter, F.R., Likki, S.R., et al.: A correlation-based transition model using local variables-part II: test cases and industrial applications. J. Turbomach. 128, 423–434 (2006)CrossRefGoogle Scholar
  40. 40.
    Menter, F.R., Langtry, R.B., Völker, S.: Transition modeling for general purpose CFD codes. Flow Turbul. Combust. 77, 277–303 (2006)CrossRefGoogle Scholar
  41. 41.
    Haller, G., Yuan, G.: Lagrangian coherent structures and mixing in two-dimensional turbulence. Phys. D 147, 352–370 (2000)MathSciNetCrossRefGoogle Scholar
  42. 42.
    Wu, Q., Huang, B., Wang, G.: Lagrangian-based investigation of the transient flow structures around a pitching hydrofoil. Acta Mech. Sin. 32, 64–74 (2016)MathSciNetCrossRefGoogle Scholar
  43. 43.
    Tseng, C.C., Liu, P.B.: Dynamic behaviors of the turbulent cavitating flows based on the Eulerian and Lagrangian viewpoints. Int. J. Heat Mass Transf. 102, 479–500 (2016)CrossRefGoogle Scholar
  44. 44.
    Wang, Z.Y., Huang, B., Zhang, M.D., et al.: Experimental and numerical investigation of ventilated cavitating flow structures with special emphasis on vortex shedding dynamics. Int. J. Multiph. Flow 98, 79–95 (2018)CrossRefGoogle Scholar
  45. 45.
    Roache, P.J.: Quantification of uncertainty in computational fluid dynamics. Annu. Rev. Fluid Mech. 29, 123–160 (2003)MathSciNetCrossRefGoogle Scholar
  46. 46.
    Gohil, P.P., Saini, R.P.: Effect of temperature, suction head and flow velocity on cavitation in a Francis turbine of small hydro power plant. Energy 93, 613–624 (2015)CrossRefGoogle Scholar
  47. 47.
    Roache, P.J.: Verification of codes and calculations. AIAA J. 36, 696–702 (2012)CrossRefGoogle Scholar
  48. 48.
    Kwasniewski, L.: Application of grid convergence index in FE computation. Bull. Pol. Acad. Sci. Tech. Sci. 61, 123–128 (2013)Google Scholar
  49. 49.
    Kleinhans, M.G., Jagers, H.R.A., Mosselman, E., et al.: Procedure of estimation and reporting of uncertainty due to discretization in CFD applications. J. Fluids Eng. 130, 078001 (2008)CrossRefGoogle Scholar
  50. 50.
    Hunt, J.C.R., Wray, A.A., Moin, P.: Eddies, stream, and convergence zones in turbulent flows. Center for Turbulence Research Report CTR-S88. pp. 193–208 (1988)Google Scholar
  51. 51.
    Choudhry, A., Leknys, R., Arjomandi, M., et al.: An insight into the dynamic stall lift characteristics. Exp. Therm. Fluid Sci. 58, 188–208 (2014)CrossRefGoogle Scholar
  52. 52.
    Martinat, G., Braza, M., Hoarau, Y., et al.: Turbulence modeling of the flow past a pitching NACA0012 airfoil at 105 and 106 Reynolds numbers. J. Fluids Struct. 24, 1294–1303 (2008)CrossRefGoogle Scholar
  53. 53.
    Velkova, C., Todorov, M., Dobrev, I., et al.: Approach for numerical modeling of airfoil dynamic stall. in: Proceedings of BulTrans-2012, 26–28 September, Sozopol, 1–6 (2012)Google Scholar
  54. 54.
    Tseng, C.C., Cheng, Y.E.: Numerical investigations of the vortex interactions for a flow over a pitching foil at different stages. J. Fluids Struct. 58, 291–318 (2015)CrossRefGoogle Scholar

Copyright information

© The Chinese Society of Theoretical and Applied Mechanics; Institute of Mechanics, Chinese Academy of Sciences and Springer-Verlag GmbH Germany, part of Springer Nature 2018

Authors and Affiliations

  • Mengjie Zhang
    • 1
  • Qin Wu
    • 1
    • 2
  • Biao Huang
    • 1
  • Guoyu Wang
    • 1
  1. 1.School of Mechanical EngineeringBeijing Institute of TechnologyBeijingChina
  2. 2.Department of Thermal EngineeringTsinghua UniversityBeijingChina

Personalised recommendations