Skip to main content
SpringerLink
Log in

Validated numerical analysis of vortical structures in 3D AC electro-osmotic flows

  • Research Paper
  • Published:
Microfluidics and Nanofluidics Aims and scope Submit manuscript

Abstract

This paper presented an experimental validation of a numerical study on the vortical structures in AC electro-osmotic (ACEO) flows. First, the 3D velocity field of ACEO vortices above the symmetric electrodes was experimentally investigated using astigmatism microparticle tracking velocimetry. The experimentally obtained velocities were used to validate an extended nonlinear Gouy–Chapman–Stern model accounting for the surface conduction effect. A qualitative agreement between the simulations and experiments was found for the velocity field when changing AC voltage (from 0.5 to 2 V) and the frequency (from 50 to 3,000 Hz). However, the predicted magnitude of the velocity profiles was much higher than the experimentally obtained ones, except in some cases at low frequency. For frequencies higher than 200 Hz, a correction factor was introduced to make the numerical results quantitatively comparable to the experimental ones. In addition, the primary circulation, given in terms of the spanwise component of vorticity, was numerically and experimentally analyzed as function of frequency and amplitude of the AC voltage. The outline of the vortex boundary was determined via the eigenvalues of the strain-rate tensor estimated from the velocity field. It revealed that the experimental circulation was frequency dependent, tending to zero at both low and high frequency and the maximum changing from around 600 Hz for 1 V to 300 Hz for 2 V. The variation in the predicted vortex circulation as function of frequency and voltage, after using the above correction factor, was in good correspondence with the experiments. These results yield first insights into the characteristics of 3D ACEO flows and the ability of current numerical models to adequately describe them.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8
Fig. 9
Fig. 10
Fig. 11
Fig. 12

Similar content being viewed by others

References

  • Ajdari A (2000) Pumping liquids using asymmetric electrode arrays. Phys Rev E 61:R45–R48

    Article  Google Scholar 

  • Bazant MZ, Kilic MS, Storey BD, Ajdari A (2009) Towards an understanding of induced-charge electrokinetics at large applied voltages in concentrated solutions. Adv Colloid Interface Sci 152:48–88

    Article  Google Scholar 

  • Castellanos A, Ramos A, Gonzalez A, Green NG, Morgan H (2003) Electrohydrodynamics and dielectrophoresis in microsystems: scaling laws. J Phys D 36:2584–2597

    Article  Google Scholar 

  • Chen S, Angarita-Jaimes N, Angarita-Jaimes D, Pelc B, Greenaway AH, Towers CE, Lin D, Towers DP (2009) Wavefront sensing for three-component three-dimensional flow velocimetry in microfluidics. Exp Fluids 47:849–863

    Article  Google Scholar 

  • Cierpka C, Segura R, Hain R, Kähler CJ (2010) A simple single camera 3C3D velocity measurement technique without errors due to depth of correlation and spatial averaging for micro fluidics. Meas Sci Technol 21:045401

    Article  Google Scholar 

  • Cierpka C, Rossi M, Segura R, Kähler CJ (2010) On the calibration of astigmatism particle tracking velocimetry for microflows. Meas Sci Technol 22:015401

    Article  Google Scholar 

  • Das S, Chakrakorty S, Mitra SK (2012) Redefining electrical double layer thickness in narrow confinements: effect of solvent polarization. Phys Rev E 85:051508

    Article  Google Scholar 

  • Garcia D (2011) A fast all-in-one method for automated post-processing of PIV data. Exp Fluids 50:1247–1259

    Article  Google Scholar 

  • Green NG, Morgan H (1999) Dielectrophoresis of submicrometer latex spheres. 1. Experimental results. J Phys Chem B 103(1):41–50

    Article  Google Scholar 

  • Green NG, Ramos A, Gonzalez A, Morgan H, Castellanos A (2000) Fluid flow induced by nonuniform ac electric fields in electrolytes on microelectrodes. I. Experimental measurements. Phys Rev E 61:40114018

    Google Scholar 

  • Green NG, Ramos A, Gonzalez A, Morgan H, Castellanos A (2002) Fluid flow induced by nonuniform ac electric fields in electrolytes on microelectrodes. III. Observation of streamlines and numerical simulation. Phys Rev E 66:026305

    Article  Google Scholar 

  • Gregersen MM, Andersen MB, Soni G, Meinhart C, Bruus H (2009) Numerical analysis of finite Debye-length effects in induced-charge electro-osmosis. Phys Rev E 79:066316

    Article  Google Scholar 

  • Jeong J, Hussain F (1995) On the identification of a vortex. J Fluid Mech 285:69–94

    Article  MATH  MathSciNet  Google Scholar 

  • Khair AS, Squires TM (2008) Surprising consequences of ion conservation in electro-osmosis over a surface charge discontinuity. J Fluid Mech 615:323–334

    Article  MATH  Google Scholar 

  • Kilic MS, Bazant MZ, Ajdari A (2007) Steric effects in the dynamics of electrolytes at large applied voltages. II. Modified Poisson–Nernst–Planck equations. Phys Rev E 75:021503

    Article  Google Scholar 

  • Kim BJ, Yoon SY, Lee KH, Sung HJ (2009) Development of a microfluidic device for simultaneous mixing and pumping. Exp Fluids 46:85–95

    Article  Google Scholar 

  • Liu Z, Speetjens MFM, Frijns AJH, van Steenhoven AA (2014) Application of astigmatism μ-PTV to analyze the vortex structure of AC electroosmotic flows. Microfluid Nanofluid 16:553–569. doi:10.1007/s10404-013-1253-2

    Google Scholar 

  • Lyklema J (1995) Solid–liquid interfaces, Vol. II of Fundamentals of interface and colloid science. Academic Press, San Diego

    Google Scholar 

  • Morgan H, Green NG (2002) AC electrokinetic: colloids and nanoparticles. Research Studies Press, Hertfordshire

    Google Scholar 

  • Olesen LH, Bruus H, Ajdari A (2006) AC electrokinetic micropumps: the effect of geometrical confinement, faradaic current injection, and nonlinear surface capacitance. Phys Rev E 73:056313

    Article  Google Scholar 

  • Ramos A, Morgan H, Green NG, Castellanos A (1998) AC electrokinetics: a review of forces in microelectrode structures. J Phys D Apply Phys 31:2338–2353

    Article  Google Scholar 

  • Ramos A, Morgan H, Green NG, Castellanos A (1999) AC electric field-induced fluid flow in microelectrodes. J Colloid Interface Sci 217:420–422

    Article  Google Scholar 

  • Ramos A, Gonzalez A, Castellanos A, Green NG, Morgan H (2003) Pumping of liquid with ac voltage applied to asymmetric pairs of microelectrodes. Phys Rev E 67:056302

    Article  Google Scholar 

  • Soni G, Squires TM, Meinhart CD (2007) Nonlinear phenomena in induced charge electroosmosis. In: 2007 ASME international mechanical engineering congress and exposition, Seattle, USA

  • Speetjens MFM, Wispelaeere HNL, van Steenhoven AA (2011) Multi-functional Lagrangian flow structures in three-dimensional ac electro-osmotic micro-flows. Fluid Dyn Res 43:035503

    Article  MathSciNet  Google Scholar 

  • Storey BD, Edwards LR, Kilic MS, Bazant MZ (2006) Steric effects on ac electro-osmosis in dilute electrolytes. Phys Rev E 77:036317

    Article  Google Scholar 

  • Vollmers H (2001) Detection of vortices and quantitative evaluation of their main parameters from experimental velocity data. Meas Sci Technol 12:1199–1207

    Article  Google Scholar 

Download references

Author information

Authors and Affiliations

  1. Department of Mechanical Engineering, Eindhoven University of Technology, P.O. Box 513, 5600 MB, Eindhoven, The Netherlands

    Zhipeng Liu, Michel F. M. Speetjens, Arjan J. H. Frijns & Anton A. van Steenhoven

Authors
  1. Zhipeng Liu
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Michel F. M. Speetjens
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Arjan J. H. Frijns
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Anton A. van Steenhoven
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Arjan J. H. Frijns.

Rights and permissions

Reprints and permissions

About this article

Cite this article

Liu, Z., Speetjens, M.F.M., Frijns, A.J.H. et al. Validated numerical analysis of vortical structures in 3D AC electro-osmotic flows. Microfluid Nanofluid 16, 1019–1032 (2014). https://doi.org/10.1007/s10404-014-1377-z

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s10404-014-1377-z

Keywords

Search

Navigation