Abstract
We have developed a novel microchip equipped with a microchannel and Pt microelectrode array for electrochemically controlling valences of actinide (An) species. The square wave voltammograms of the redox reaction of potassium hexacyanoferrate(II) in the microchannel were measured. We found that the fabricated Pt microelectrode array has superior performances for the detection of the electrochemically active species in the microchannel. Therefore, the potentiostatic electrolysis experiments of uranium ions were carried out in the microchannel, and the concentration changes of uranium ions accompanied by the potentiostatic electrolysis were examined using thermal lens microscope. The results showed that the redox reactions between U(VI) and U(IV) can be performed completely in a microchannel in a few minutes, that is, the microscale reaction is accelerated by a factor of more than 10 compared with the bulk solution reactions taking hours mostly. The developed microchip was found to have enough performances for realizing rapid and highly efficient redox reactions for An species, which are impossible in the bulk reactions.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Aoki K, Morita M, Niwa O, Tabei H (1988) Quantitative analysis of reversible diffusion-controlled currents of redox soluble species at interdigitated array electrodes under steady-state conditions. J Electroanal Chem 256:269–282
Baisden PA, Choppin GR (2007) Nuclear waste management and the nuclear fuel cycle; radiochemistry and nuclear chemistry. In: Nagy Sándor (ed) Encyclopedia of life support systems (EOLSS). Eolss Publishers, Oxford (Developed under the Auspices of the UNESCO)
Ban Y, Kikutani Y, Tokeshi M, Morita Y (2011) Extraction of Am(III) at the interface of organic-aqueous two-layer flow in a microchannel. J Nucl Sci Tech 48:1313–1318
Cha W, Tung Y-C, Meyerhoff ME, Takayama S (2010) Patterned electrode-based amperometric gas sensor for direct nitric oxide detection within microfluidic devices. Anal Chem 82:3300–3305
Chatterjee D, Shepherd H, Garrell RL (2009) Electromechanical model for actuating liquids in a two-plate droplet microfluidic device. Lab Chip 9:1219–1229
Dittrich PS, Tachikawa K, Manz A (2006) Micro total analysis systems. Latest advancements and trends. Anal Chem 8:3887–3908
Hotokezaka H, Tokeshi M, Harada M, Kitamori T, Ikeda Y (2005) Development of the innovative nuclide separation system for high-level radioactive waste using microchannel chip-extraction behavior of metal ions from aqueous phase to organic phase in microchannel. Prog Nucl Energy 47:439–447
Kimura T, Akatsu J (1991) Extraction chromatography in the DHDECMP-HNO3 system II. characteristics of the DHDECMP/XAD-4 resin on separation of trivalent actinide elements. J Radioanal Nucl Chem 149:25–34
Kitamori T, Tokeshi M, Hibara A, Sato K (2004) Thermal lens microscopy and microchip chemistry. Anal Chem 76:52A–60A
Mawatari K, Kazoe Y, Aota A, Tsukahara T, Sato K, Kitamori T (2011) Microflow systems for chemical synthesis and analysis: approaches to full integration of chemical process. J Flow Chem 1:3–12
NEA/NSC/DOC(97)19 NEA Nuclear Science Committee (1997) Actinide separation chemistry in nuclear waste streams and materials. Nuclear Energy Agency OECD, Paris
Nichols KP, Pompano RR, Li L, Gelis AV, Ismagilov RF (2011) Toward mechanistic understanding of nuclear reprocessing chemistries by quantifying lanthanide solvent extraction kinetics via microfluidics with constant interfacial area and rapid mixing. J Am Chem Soc 133:15721–15729
Sasaki Y, Sugo Y, Suzuki S, Kimura T (2005) A method for the determination of extraction capacity and its application to N, N, N’, N’- tetraalkyl derivatives of diglycolamide- monoamide/n-dodecane media. Anal Chim Acta 543:31–37
Sasaki N, Kitamori T, Kim H-B (2006) AC electroosmotic micromixer for chemical processing in a microchannel. Lab Chip 6:550–554
So J-H, Dickey MD (2011) Inherently aligned microfluidic electrodes composed of liquid metal. Lab Chip 11:905–911
Tsukahara T, Ikeda Y (2011) Mutual separation of strontium, cerium, and uranium using pressure-driven flow in 100 nm-sized nanofluidic channels. Prog Nucl Energy 53:935–939
Acknowledgments
The present work was partially supported by “the Funding Program for Next Generation World-Leading Researchers (NEXT program)” from the Japan Society for the Promotion of Science (JSPS).
Author information
Authors and Affiliations
Corresponding authors
Electronic supplementary material
Below is the link to the electronic supplementary material.
Rights and permissions
About this article
Cite this article
Tsukahara, T., Hotokezaka, H., Harada, M. et al. Highly efficient electrochemical valence control of uranium using microfluidic chip equipped with microelectrodes. Microfluid Nanofluid 14, 989–994 (2013). https://doi.org/10.1007/s10404-012-1106-4
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10404-012-1106-4