Abstract
This paper reports an experimental and numerical investigation on the scaling effects in the flow hydrodynamics for confined microdroplets induced by a surface acoustic wave (SAW). The characteristic parameters of the flow hydrodynamics were studied as a function of the separation height, H, between the LiNbO3 substrate and a top glass plate, for various droplets volumes and radio-frequency powers. The ratio of the gap height to attenuation length of the SAW, H/l SAW, is shown to be an important parameter affecting the streaming flow induced in this confined regime. The reported numerical and experimental results are in good agreement over the range examined in this study and demonstrate that, at a lower gap heights of H ≤ 100 μm, a significant decrease in streaming velocity or Reynolds number is induced, with the velocity approaching zero when the gap height is decreased to ~50 μm. An increase in the gap height results in an increased streaming velocity; however, if the gap height exceeds 70 % of the SAW attenuation length, any further increase in the gap height induces a drop in the streaming velocity.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Alghane M, Chen BX et al (2010) Experimental and numerical investigation of acoustic streaming excited by using a surface acoustic wave device on a 128º YX-LiNbO3 substrate. J Micromech Microeng 21:015005
Alghane M, Fu YQ et al (2011) Streaming phenomena in microdroplets induced by Rayleigh surface acoustic wave. J Appl Phys 109:114901
Arzt RM, Salzmann E et al (1967) Elastic surface waves in quartz at 316 MHz. Appl Phys Lett 10(5):165–167
Berthier J (2008) Microdrops and digital microfluidic. William Andrew Inc, Norwich
Campbell JC, Jones WR (1968) A method for estimating optimal crystal cuts and propagation direction for excitation of piezoelectric surface waves. IEEE Trans Sonic Ultrasonics 15:209
Campbell JC, Jones WR (1970) Propagation of surface waves at the boundary between a piezoelectric crystal and a fluid medium. IEEE Trans Sonic Ultrasonics 17:71–76
Dransfeld K, Salzmann E (1970) Excitation, detection and attenuation of high-frequency elastic surface waves. In: Mason WP, Thurston RN (eds) Physical acoustics. Academic press, New York, pp 219–272
Franke TA, Wixforth A (2008) Microfluidics for miniaturized laboratories on a chip. Chem Phys Chem 9:2140–2156
Friend J, Yeo LY (2011) Microscale acoustofluidics: microfluidics driven via acoustics and ultrasonics. Rev Mod Phys 83(2):647–704
Frommelt T, Gogel TD et al (2008a) Flow patterns and transport in Rayleigh surface acoustic wave streaming. IEEE Trans Ultrasonics 55:2298–2305
Frommelt T, Kostur M et al (2008b) Microfluidic mixing via acoustically driven chaotic advection. Phys Rev Lett 100(3):034502
Furukawa S, Nomura T et al (1991) Characteristic features of leaky surface acoustic waves propagating on liquid/piezoelectric film glass structures. J Phys D Appl Phys 24(5):706–713
Gantner A, Hoppe RHW et al (2007) Numerical simulation of piezoelectrically agitated surface acoustic waves on microfluidic biochips. Comput Vis Sci 10(3):145–161
Guo H, Sun H et al (2008) Theoretical study of acoustic streaming induced cooling effect in the microscale. In: Proceedings of IEEE International Ultrasonics Symposium, pp 934–937
Gu H-h, Zhang S-y et al (2009) Study on non-contact linear motors driven by surface acoustic waves. Sens Actuators A 155:163–167
Kamakura T, Matsuda K et al (1995) Acoustic streaming induced in focused Gaussian beams. J Acoust Soc Am 97(5):2740–2746
Kang K, Lee LJ et al (2005) High shear microfluidics and its application in rheological measurement. Exp Fluids 38(2):222–232
Kondoh J, Shimizu N et al (2005) Temperature-control system for small droplet using surface acoustic wave device. Sensors, 2005 IEEE
Lighthill J (1978) Internal waves in fluids. Cambridge University Press, Cambridge
Luong T-D, Phan V-N et al (2011) High-throughput micromixers based on acoustic streaming induced by surface acoustic wave. Microfluid Nanofluid 10(3):619–625
Min-Chien T, Tzong-Shyng L (2007) The study of flexible plate wave device for micro pumping system. In: 2nd IEEE International Conference, Nano/Micro Engineered and Molecular Systems, 2007 (NEMS ‘07)
Nam-Trung N, White RM (2000) Acoustic streaming in micromachined flexural plate wave devices: numerical simulation and experimental verification. Ultrasonics, Ferroelectrics and Frequency Control. IEEE Trans 47(6):1463–1471
Nguyen NT, White RM (1999) Design and optimization of an ultrasonic flexural plate wave micropump using numerical simulation. Sens Actuators A 77(3):229–236
Patankar SV (1980) Numerical heat transfer and fluid flow. Hemisphere Publishing Corporation, New York
Sankaranarayanan SKRS, Cular S et al (2008) Flow induced by acoustic streaming on surface-acoustic-wave devices and its application in biofouling removal: a computational study and comparisons to experiment. Phys Rev E 77(6):066308
Schmid L, Wixforth A et al (2011) Novel surface acoustic wave (SAW)-driven closed PDMS flow chamber. Microfluid Nanofluid 12:1–7
Shiokawa S, Matsui Y et al (1989a) Liquid streaming and droplet formation caused by leaky Rayleigh waves. In: Proceedings of IEEE Ultrasonics Symposium, 1989
Shiokawa S, Matsui Y et al (1989b) Experimental study on liquid streaming by SAW. Jpn J Appl Phys 28(Suppl 28-1):126–128
Shiokawa S, Matsui Y et al (1990) Study on acoustic streaming and its application to fluid devices. Jpn J Appl Phys 29:137–139
Tan M, Friend J et al (2007) Surface acoustic wave driven microchannel flow. In: Proceedings of 16th Australasian Fluid Mech Conference, Gold Coast, Australia
Tan MK, Yeo LL et al (2009) Inducing rapid fluid flows in microchannels with surface acoustic waves. In: IEEE International Ultrasonics Symposium (IUS)
Tan MK, Yeo LY et al (2010) Unique flow transitions and particle collection switching phenomena in a microchannel induced by surface acoustic waves. Appl Phys Lett 97(23):234106-3
Tzong-Shyng L, Horng-Jiann S (2009) New pumping mechanism by surface waves in a microchannel. In: 4th IEEE International Conference on Nano/Micro Engineered and Molecular Systems, 2009 (NEMS 2009)
Weilin Q, Mohiuddin Mala G et al (2000) Pressure-driven water flows in trapezoidal silicon microchannels. Int J Heat Mass Transf 43(3):353–364
Wixforth A (2003) Acoustically driven planar microfluidics. Superlattices Microstruct 33:389–396
Zeng Q, Guo F et al (2011) Milliseconds mixing in microfluidic channel using focused surface acoustic wave. Sens Actuators B Chem 160(1):1552–1556
Acknowledgments
The authors acknowledge the support from the Innovative electronic Manufacturing Research Centre (IeMRC) through the EPSRC funded flagship project SMART MICROSYSTEMS (FS/01/02/10). Financial support from Royal Society-Research Grant (RG090609), Carnegie Trust Funding, and the Royal Society of Edinburgh is also acknowledged. Y. Li and A. J. Walton would like to acknowledge the financial support from BBSRC and EPSRC (RASOR Project No. BBC5115991).
Author information
Authors and Affiliations
Corresponding authors
Rights and permissions
About this article
Cite this article
Alghane, M., Fu, Y.Q., Chen, B.X. et al. Scaling effects on flow hydrodynamics of confined microdroplets induced by Rayleigh surface acoustic wave. Microfluid Nanofluid 13, 919–927 (2012). https://doi.org/10.1007/s10404-012-1010-y
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10404-012-1010-y