Skip to main content

Advertisement

SpringerLink
Log in

Phase separation of parallel laminar flow for aqueous two phase systems in branched microchannel

  • Original Paper
  • Published:
Microfluidics and Nanofluidics Aims and scope Submit manuscript

Abstract

Aqueous two phase systems (ATPSs) have good biocompatibility and special selectivity. Their phase equilibrium and applications in biological analysis have received much attention. Herein, parallel laminar flow (PLF) in the microchannel can provide an effective platform to enhance mass transfer and preserve separate phases simultaneously. As fundamentals in feasible and convenient sampling of PLF for ATPS, the phase separation methods and rules in branched microchannel were studied in this work, selecting PEG 4000 + Na2SO4 + H2O as a model system. The exploration of flow pattern showed that a stable PFL was easily to form in the shallow microchannel of 200 μm (depth) × 600 μm (width), as long as the velocity of lower phase was higher than 0.51 mm/s. The phase interface of PLF could be easily controlled by the flow ratio of two phases. Single-phase separation could be reliably achieved in T-junction outlets when the flow rate of outlet ascertains to be smaller or larger than that of inlet on the same side. The trifurcate outlets with an extra middle channel could help realize a simultaneous two-phase separation. The flow rate of the extra channel is the key for the phase separation performance, the range of which available for simultaneous two-phase separation is determined by the resistance balance and the flow rates deviation offsetting as well. It is favor for increasing phase separation efficiency to make the products of flow rate, viscosity, and the length of corresponding outlet channel close with each other for the upper phase and the lower phase. The adjustable lengths of three channels can provide flexible choices to enhance simultaneous two-phase separation of diversified ATPSs at various operating flow ratios. A multiport microchip with T-junction inlets and trifurcate outlets designed for adjusting the lengths of branched channels on-chip is a convenient tool for PLF contact and in situ phase separation of ATPSs in varieties of application.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8
Fig. 9
Fig. 10
Fig. 11
Fig. 12

Similar content being viewed by others

References

  • Allman R, Coakley W (1994) Ultrasound enhanced phase partition of microorganisms. Bioseparation 4(1):29–38

    Google Scholar 

  • Aota A, Nonaka M, Hibara A, Kitamori T (2007) Countercurrent laminar microflow for highly efficient solvent extraction. Angew Chem Int Ed 46(6):878–880

    Article  Google Scholar 

  • Aota A, Mawatari K, Kitamori T (2009) Parallel multiphase microflows: fundamental physics, stabilization methods and applications. Lab Chip 9(17):2470–2476

    Article  Google Scholar 

  • Atencia J, Beebe DJ (2005) Controlled microfluidic interfaces. Nature 437(7059):648–655

    Article  Google Scholar 

  • Bermejo R, Ruiz E, Acien FG (2007) Recovery of B-phycoerythrin using expanded bed adsorption chromatography: scale-up of the process. Enzyme Microb Technol 40(4):927–933

    Article  Google Scholar 

  • Berthier J, Tran V, Mittler F, Sarrut N (2009) The physics of a coflow micro-extractor: interface stability and optimal extraction length. Sens Actuator A 149(1):56–64

    Article  Google Scholar 

  • Duarte S, Fortes A, Prazeres D, Marcos JC (2007) Integration of plasmid DNA purification and molecular therapy agent preparation using aqueous two-phase systems. J Biotechnol 131(2):S6–S7

    Article  Google Scholar 

  • Edahiro J, Nakamura M, Seki M, Furusaki S (2005a) Enhanced accumulation of anthocyanin in cultured strawberry cells by repetitive feeding of L-phenylalanine into the medium. J Biosci Bioeng 99(1):43–47

    Article  Google Scholar 

  • Edahiro J, Yamada M, Seike S, Kakigi Y, Miyanaga K, Nakamura M, Kanamori T, Seki M (2005b) Separation of cultured strawberry cells producing anthocyanins in aqueous two-phase system. J Biosci Bioeng 100(4):449–454

    Article  Google Scholar 

  • Flygare S, Wikstrom P, Johansson G, Larsson PO (1990) Magnetic aqueous 2-phase separation in preparative applications. Enzyme Microb Technol 12(2):95–103

    Article  Google Scholar 

  • Groisman A, Enzelberger M, Quake SR (2003) Microfluidic memory and control devices. Science 300(5621):955–958

    Article  Google Scholar 

  • Guillot P, Colin A (2005) Stability of parallel flows in a microchannel after a T junction. Phys Rev E 72(6):1–4

    Article  Google Scholar 

  • Guillot P, Moulin T, Kotitz R, Guirardel M, Dodge A, Joanicot M, Colin A, Bruneau CH, Colin T (2008) Towards a continuous microfluidic rheometer. Microfluid Nanofluid 5(5):619–630

    Google Scholar 

  • Hatch A, Kamholz AE, Hawkins KR, Munson MS, Schilling EA, Weigl BH, Yager P (2001) A rapid diffusion immunoassay in a T-sensor. Nat Biotechnol 19(5):461–465

    Article  Google Scholar 

  • Helfrich R, El-Kouedi M, Etherton M, Keating CD (2005) Partitioning and assembly of metal particles and their bioconjugates in aqueous two-phase systems. Langmuir 21(18):8478–8486

    Article  Google Scholar 

  • Hibara A, Nonaka M, Hisamoto H, Uchiyama K, Kikutani Y, Tokeshi M, Kitamori T (2002) Stabilization of liquid interface and control of two-phase confluence and separation in glass microchips by utilizing octadecylsilane modification of microchannels. Anal Chem 74(7):1724–1728

    Article  Google Scholar 

  • Hoettges KF, Stevenson D, Homewood KP, Gwilliam RM (2003) Liquid–liquid separation. International patent WO 03/082429A2

  • Johansson HO, Ishii M, Minaguti M, Feitosa E, Penna TCV, Pessoa A (2008) Separation and partitioning of green fluorescent protein from Escherichia coli homogenate in poly(ethylene glycol)/sodium-poly(acrylate) aqueous two-phase systems. Sep Purif Technol 62(1):166–174

    Article  Google Scholar 

  • Kashid MN, Harshe YM, Agar DW (2007) Liquid–liquid slug flow in a capillary: an alternative to suspended drop or film contactors. Ind Eng Chem Res 46(25):8420–8430

    Article  Google Scholar 

  • Kenis PJA, Ismagilov RF, Whitesides GM (1999) Microfabrication inside capillaries using multiphase laminar flow patterning. Science 285(5424):83–85

    Article  Google Scholar 

  • Kikutani Y, Mawatari K, Hibara A, Kitamori T (2009) Circulation microchannel for liquid–liquid microextraction. Microchim Acta 164(3–4):241–247

    Article  Google Scholar 

  • Li SW, Xu JH, Wang YJ, Lu YC, Luo GS (2009) Low-temperature bonding of poly-(methyl methacrylate) microfluidic devices under an ultrasonic field. J Micromech Microeng 19(1):015035

    Article  Google Scholar 

  • Maruyama T, Uchida J, Ohkawa T, Futami T, Katayama K, Nishizawa K, Sotowa K, Kubota F, Kamiyaa N, Goto M (2003) Enzymatic degradation of p-chlorophenol in a two-phase flow microchannel system. Lab Chip 3(4):308–312

    Article  Google Scholar 

  • Maruyama T, Matsushita H, Uchida J, Kubota F, Kamiya N, Goto M (2004) Liquid membrane operations in a microfluidic device for selective separation of metal ions. Anal Chem 76(15):4495–4500

    Article  Google Scholar 

  • Meagher RJ, Light YK, Singh AK (2008) Rapid, continuous purification of proteins in a microfluidic device using genetically-engineered partition tags. Lab Chip 8(4):527–532

    Article  Google Scholar 

  • Mohamadi S, Omidinia E (2007) Purification of recombinant phenylalanine dehydrogenase by partitioning in aqueous two-phase systems. J Chromatogr B 184(1–2):273–278

    Article  Google Scholar 

  • Mokhtarani B, Karimzadeh R, Amini MH, Manesh SD (2008) Partitioning of ciprofloxacin in aqueous two-phase system of poly(ethylene glycol) and sodium sulphate. Biochem Eng J 38(2):241–247

    Article  Google Scholar 

  • Müenchow G, Hardt S, Kutter JP, Drese KS (2007) Electrophoretic partitioning of proteins in two-phase microflows. Lab Chip 7(1):98–102

    Article  Google Scholar 

  • Nam KH, Chang WJ, Hong H, Lim SM, Kim DI, Koo YM (2005) Continuous-flow fractionation of animal cells in microfluidic device using aqueous two-phase extraction. Biomed Microdevices 7(3):189–195

    Article  Google Scholar 

  • Reddy V, Zahn JD (2005) Interfacial stabilization of organic-aqueous two-phase microflows for a miniaturized DNA extraction module. J Colloid Interface Sci 286(1):158–165

    Article  Google Scholar 

  • Smirnova A, Shimura K, Hibara A, Proskurnin MA, Kitamori T (2007) Application of a micro multiphase laminar flow on a microchip for extraction and determination of derivatized carbamate pesticides. Anal Sci 23(1):103–107

    Article  Google Scholar 

  • Theos CW, Clark WM (1995) Electroextraction-2-phase electrophoresis. Appl Biochem Biotechnol 54(1–3):143–157

    Article  Google Scholar 

  • Tokeshi M, Minagawa T, Uchiyama K, Hibara A, Sato K, Hisamoto H, Kitamori T (2002) Continuous-flow chemical processing on a microchip by combining microunit operations and a multiphase flow network. Anal Chem 74(7):1565–1571

    Article  Google Scholar 

  • Tsukamoto M, Taira S, Yamamura S, Morita Y, Nagatani N, Takamura Y, Tamiya E (2009) Cell separation by an aqueous two-phase system in a microfluidic device. Analyst 134(10):1994–1998

    Article  Google Scholar 

  • Wu YT, Zhu ZQ (1999) Modeling of interfacial tension of aqueous two-phase systems. Chem Eng Sci 54(4):433–440

    Article  MathSciNet  Google Scholar 

  • Yamada M, Kasim V, Edahiro J, Edahiro J, Seki M (2004) Continuous cell partitioning using an aqueous two-phase flow system in microfluidic devices. Biotechnol Bioeng 88(4):489–494

    Article  Google Scholar 

  • Zhao B, Moore JS, Beebe DJ (2001) Surface-directed liquid flow inside microchannels. Science 291(5506):1023–1026

    Article  Google Scholar 

  • Zhao B, Moore JS, Beebe DJ (2002) Principles of surface-directed liquid flow in microfluidic channels. Anal Chem 74(16):4259–4268

    Article  Google Scholar 

Download references

Acknowledgments

We gratefully acknowledge the financial support of the National Natural Science Foundation of China (20876084) and National Basic Research Program of China (2007CB714302) on this work.

Author information

Authors and Affiliations

  1. The State Key Lab of Chemical Engineering, Department of Chemical Engineering, Tsinghua University, Beijing, 100084, China

    Yangcheng Lu, Yang Xia & Guangsheng Luo

Authors
  1. Yangcheng Lu
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Yang Xia
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Guangsheng Luo
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Yangcheng Lu.

Electronic supplementary material

Below is the link to the electronic supplementary material.

Supplementary material 1 (DOCX 587 kb)

Rights and permissions

Reprints and permissions

About this article

Cite this article

Lu, Y., Xia, Y. & Luo, G. Phase separation of parallel laminar flow for aqueous two phase systems in branched microchannel. Microfluid Nanofluid 10, 1079–1086 (2011). https://doi.org/10.1007/s10404-010-0736-7

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s10404-010-0736-7

Keywords

Search

Navigation