Abstract
Little attention has been paid to investigating borehole deformation characteristics during drilling in soil and rock mixtures commonly encountered in the construction of ground anchors, micropiles, etc., raising questions as to the pile quality. This unique study investigates the deformations of micropile boreholes during rotary drilling in a compacted soil-limestone mixture (S-LM) by developing model tests. Three sets of experiments were carried out, in which three groundwater conditions (no water flow, 40 cm water level, and 80 cm water level) were applied at each of the three boreholes, which had diameters of 32, 44, and 56 mm. The variations in vertical displacement, deep horizontal displacement, pore water pressure, and soil pressure were recorded during the drilling stage. The test results showed that, in general, the vertical displacement at the ground surface, radial horizontal movement, and soil pressure induced by rotary drilling were strongly correlated with the borehole diameter. It was observed that the larger the borehole diameter was, the higher the values of these parameters. Furthermore, the 80-cm water level resulted in borehole collapse during the drilling stop periods since a negative displacement area and a soil pressure varying from negative to zero were observed. This research broadens the limited study of borehole deformation conducted on soil and rock mixtures via model tests. Additionally, it can provide a reference for micropile designers and contractors planning to drill in similar soil-rock mixtures.
Similar content being viewed by others
References
Aadnoy BS (1989) Stresses around horizontal boreholes drilled in sedimentary rocks. J Petrol Sci Eng 2(4):349–360. https://doi.org/10.1016/0920-4105(89)90009-0
Abdulhadi NO, Germaine JT, Whittle AJ (2011) Experimental study of wellbore instability in clay. J Geotech Goenviron 137(8):766–776. https://doi.org/10.1061/(ASCE)GT.1943-5606.0000495
Akl SA (2010) Wellbore instability mechanisms in clays. Dissertation, Massachusetts Institute of Technology
Apaleke AS, Al-Majed AA, Hossain M E (2012) Drilling fluid: state of the art and future trend. In: Proceedings of the North Africa Technical Conference and Exhibition, Cairo, Egypt, February 20–22. SPE 149555. https://doi.org/10.2118/149555-MS
Arenson L, Hoelzle M, Springman S (2002) Borehole deformation measurements and internal structure of some rock glaciers in Switzerland. Permafrost Periglac Process 13(2):117–135. https://doi.org/10.1002/ppp.414
ASTM (2001) Standards on disc. Section four: construction, D 2487–92. Soil and rock (I): D 420-D 5779 (CD-ROM), Vol. 04.08, West Conshohocken, Pa
Bayesteh H, Sabermahani M (2018) Full-scale field study on effect of grouting methods on bond strength of hollow-bar micropiles. J Geotech Geoenviron 144(12):04018091. https://doi.org/10.1061/(ASCE)GT.1943-5606.0001983
Bowles JE (1996) Foundation analysis and design. Wiley, Hoboken
Bruce DA (2003) The Basics of Drilling for Specialty Geotechnical Construction Processes. In: Proceedings of the Third International Conference on Grouting and Ground Treatment, New Orleans, Louisiana, February 10-12, pp 752-771. https://doi.org/10.1061/40663(2003)45
Bruce DA, Bruce MEC, Traylor RP (1999) High capacity micropiles: basic principles and case histories. In Geo-engineering for underground facilities, Geotechnical Special Publication No. 90. ASCE, Reston, Virginia, pp 188–199
Bruce DA, Dimillio AF, Juran I (1997) Micropiles: the state of practice. Part 1: characteristics, definitions and classifications. Ground Improvement 1(1): 25–35. https://doi.org/10.1680/gi.1997.010104
Bruce DA, Lyon R (2017) Recent advances in overburden and down-the-hole drilling techniques. In: Proceedings of the Grouting 2017, Honolulu, Hawaii, July 9–12, pp 82–91. https://doi.org/10.1061/9780784480793.008
Bruce DA, Lyon R (2018) Small hole drilling: the state of practice. In: Proceedings of the IFCEE 2018, Orlando, Florida, March 5–10, pp 386–394. https://doi.org/10.1061/9780784481578.038
Cadden A, Gómez J, Bruce D et al. (2004) Micropiles: recent advances and future trends. In Current practices and future trends in deep foundations, Geotechnical Special Publication No. 125. ASCE, Reston, Virginia, pp 140–165. https://doi.org/10.1061/40743(142)9
Carrubba P (1997) Skin friction on large-diameter piles socketed into rock. Can Geotech J 34(2):230–240. https://doi.org/10.1139/t96-104
Chen X, Tan CP, Haberfield CM (2000) Numerical evaluation of the deformation behaviour of thick-walled hollow cylinders of shale. Int J Rock Mech Min Sci 37(6):947–961. https://doi.org/10.1016/S1365-1609(00)00029-0
Chin WC (2018) Measurement while drilling: signal analysis, optimization and design. Wiley, Hoboken
Chinese National Standard (CNS), GB/T 50145–2007 (2007) Standard for engineering classification of soil, Beijing (in Chinese)
Chinese National Standard (CNS), GB/T 50123–1999 (1999) Standard for soil test method, Beijing (in Chinese)
Chinese National Standard (CNS), GB/T 50266–2013 (2013) Standard for tests method of engineering rock Mass, Beijing (in Chinese)
Chinese Sector Standard (CSS), SL 237–1999 (1999) Specification of soil test, Beijing (in Chinese)
Choi HY, Lee SR, Park HI et al (2013) Evaluation of lateral load capacity of bored piles in weathered granite soil. J Geotech Geoenviron 139(9):1477–1489. https://doi.org/10.1061/(ASCE)GT.1943-5606.0000831
Cuss RJ, Rutter EH, Holloway RF (2003) Experimental observations of the mechanics of borehole failure in porous sandstone. Int J Rock Mech Min Sci 40(5):747–761. https://doi.org/10.1016/S1365-1609(03)00068-6
Dafalla MA (2013) Effects of clay and moisture content on direct shear tests for clay-sand mixtures. Adv Mater Sci Eng 2013:1–8. https://doi.org/10.1155/2013/562726
Darley HCH (1969) A laboratory investigation of borehole stability. J Petrol Technol 21(07):883–892. https://doi.org/10.2118/2400-PA
Fam MA, Dusseault MB, Fooks JC (2003) Drilling in mudrocks: rock behavior issues. J Petrol Sci Eng 38(3–4):155–166. https://doi.org/10.1016/S0920-4105(03)00029-9
FHWA (2000) Micropile design and construction guidelines-implementation manual, Report No. FHWA-SA-97–070. Federal Highway Administration, US Department of Transportation, McLean, Virginia
Forth RA (2004) Groundwater and geotechnical aspects of deep excavations in Hong Kong. Eng Geol 72(3–4):253–260. https://doi.org/10.1016/j.enggeo.2003.09.003
Fox PJ (1996) Analysis of hydraulic gradient effects for laboratory hydraulic conductivity testing. Geotech Test J 19(2):181–190. https://doi.org/10.1520/GTJ10340J
Gatto MPA, Montrasio L (2021) Analysis of the behaviour of very slender piles: focus on the ultimate load. Int J Civ Eng 19(2):145–153. https://doi.org/10.1007/s40999-020-00547-y
Gentzis T, Deisman N, Chalaturnyk RJ (2009) A method to predict geomechanical properties and model well stability in horizontal boreholes. Int J Coal Geol 78(2):149–160. https://doi.org/10.1016/j.coal.2008.11.001
Ghiassian H, Ghareh S (2008) Stability of sandy slopes under seepage conditions. Landslides 5(4):397–406. https://doi.org/10.1007/s10346-008-0132-5
Groneck PB, Amour TA (2000) U.S. Patent No. 6,012,874. Washington, DC: U.S. Patent and Trademark Office
Hamidi A, Yazdanjou V, Salimi N (2009) Shear strength characteristics of sand-gravel mixtures. Int J Geotech Eng 3(1):29–38. https://doi.org/10.3328/IJGE.2009.03.01.29-38
Han HX, Yin S (2018) Determination of in-situ stress and geomechanical properties from borehole deformation. Energies 11(1):131. https://doi.org/10.3390/en11010131
Hashemi SS, Momeni AA, Melkoumian N (2014a) Investigation of borehole stability in poorly cemented granular formations by discrete element method. J Petrol Sci Eng 113:23–35. https://doi.org/10.1016/j.petrol.2013.11.031
Hashemi SS, Taheri A, Melkoumian N (2014b) Shear failure analysis of a shallow depth unsupported borehole drilled through poorly cemented granular rock. Eng Geol 183:39–52. https://doi.org/10.1016/j.enggeo.2014.10.003
Hashemi SS, Taheri A, Melkoumian N (2015) An experimental study on the relationship between localised zones and borehole instability in poorly cemented sands. J Petrol Sci Eng 135:101–117. https://doi.org/10.1016/j.petrol.2015.08.009
He C, Hu X, Tannant DD et al (2018) Response of a landslide to reservoir impoundment in model tests. Eng Geol 247:84–93. https://doi.org/10.1016/j.enggeo.2018.10.021
Hoek E, Kaiser PK, Bawden WF (2000) Support of underground excavations in hard rock. CRC Press, Boca Raton
Hwang JH, Liang N, Chen CH (2001) Ground response during pile driving. J Geotech Geoenviron 127(11):939–949. https://doi.org/10.1061/(ASCE)1090-0241(2001)127:11(939)
JAMP (2002) Execution manual for seismic retrofitting of existing pile foundations with high capacity micropiles. Structures Research Group, Public Works Research Institute, Japan, Foundation Engineering Research Team
Karni J (1995) Gypsum in construction: origin and properties. Mater Struct 28(2):92–100. https://doi.org/10.1007/BF02473176
Kristiansen TG, Mandziuch K, Heavey P et al. (1999) Minimizing drilling risk in extended-reach wells at Valhall using geomechanics, geoscience and 3D visualization technology. In: Proceedings of the SPE/IADC Drilling Conference, Amsterdam, Netherlands, March 9–11. SPE 52863. https://doi.org/10.2118/52863-MS
Lamens P, Askarinejad A, Sluijsmans RW et al (2020) Ground response during offshore pile driving in a sandy slope. Géotechnique 70(4):281–291. https://doi.org/10.1680/jgeot.18.P.023
Lan H, Moore ID (2018) Practical criteria for assessment of horizontal borehole instability in saturated clay. Tunn Undergr Space Technol 75:21–35. https://doi.org/10.1016/j.tust.2018.02.002
Lande EJ, Karlsrud K, Langford J et al (2020) Effects of drilling for tieback anchors on surrounding ground: results from field tests. J Geotech Geoenviron 146(8):05020007. https://doi.org/10.1061/(ASCE)GT.1943-5606.0002274
Li X, Liao QL, He JM (2004) In-situ tests and a stochastic structural model of rock and soil aggregate in the three gorges reservoir area, China. Int J Rock Mech Min Sci 41:702–707. https://doi.org/10.1016/j.ijrmms.2004.03.122
Liu Q, Cheng Y, Yuan L et al (2014) A new effective method and new materials for high sealing performance of cross-measure CMM drainage boreholes. J Nat Gas Sci Eng 21:805–813. https://doi.org/10.1016/j.jngse.2014.10.023
Liu J, Ding W, Yang H et al (2017) 3D geomechanical modeling and numerical simulation of in-situ stress fields in shale reservoirs: a case study of the lower Cambrian Niutitang formation in the Cen’gong block, South China. Tectonophysics 712:663–683. https://doi.org/10.1016/j.tecto.2017.06.030
Lizzi F (1982) The pali radice (root piles). Symposium on soil and rock improvement techniques including geotextiles, reinforced earth and modern piling methods, Bangkok, Paper D-3
Lv A, Masoumi H, Walsh SDC et al (2019) Elastic-softening-plasticity around a borehole: an analytical and experimental study. Rock Mech Rock Eng 52(4):1149–1164. https://doi.org/10.1007/s00603-018-1650-7
Ma J, Tang H, Hu X et al (2017) Model testing of the spatial–temporal evolution of a landslide failure. Bull Eng Geol Env 76(1):323–339. https://doi.org/10.1007/s10064-016-0884-4
Mangushev RA (2016) Pile construction technology. ASV Construction, Stockholm, Sweden
Maeso C, Tribe I (2001) Hole shape from ultrasonic calipers and density while drilling-a tool for drillers. In: Proceedings of the SPE Annual Technical Conference and Exhibition, New Orleans, Louisiana, September 30-October 3. SPE 71395. https://doi.org/10.2118/71395-MS
McLean MR, Addis MA (1990) Wellbore stability analysis: a review of current methods of analysis and their field application. In: Proceedings of the IADC/SPE Drilling Conference, Houston, Texas, February 27–March 2. SPE 19941. https://doi.org/10.2118/19941-MS
Merrill RH, Peterson J (1961) Deformation of a borehole in rock. US Department of the Interior, Bureau of Mines, Washington
Misra A, Chen CH (2004) Analytical solution for micropile design under tension and compression. Geotech Geol Eng 22(2):199–225. https://doi.org/10.1023/B:GEGE.0000018356.85647.79
Mohiuddin MA, Khan K, Abdulraheem A et al (2007) Analysis of wellbore instability in vertical, directional, and horizontal wells using field data. J Petrol Sci Eng 55(1–2):83–92. https://doi.org/10.1016/j.petrol.2006.04.021
NKB Report No. 36 (1978) Recommendation for loading and safety regulations for structural design. Nordic Committee on Building Regulation
Papamichos E, Tronvoll J, Skjærstein A et al (2010) Hole stability of Red Wildmoor sandstone under anisotropic stresses and sand production criterion. J Petrol Sci Eng 72(1–2):78–92. https://doi.org/10.1016/j.petrol.2010.03.006
Papamichos E, Van den Hoek PJ (1995) Size dependency of Castlegate and Berea sandstone hollow-cylinder strength on the basis of bifurcation theory. In: Proceedings of the 35th US Symposium on Rock Mechanics, Reno, Nevada, June 5–7, pp 301–306
Papanastasiou P, Thiercelin M (2011) Modeling borehole and perforation collapse with the capability of predicting the scale effect. Int J Geomech 11(4):286–293. https://doi.org/10.1061/(ASCE)GM.1943-5622.0000013
Papanastasiou PC, Vardoulakis IG (1992) Numerical treatment of progressive localization in relation to borehole stability. Int J Numer Anal Meth Geomech 16(6):389–424. https://doi.org/10.1002/nag.1610160602
Rausche F, Renkung S, Likins GE (1991) Comparison of pulse echo and transient response pile integrity test methods. Transp Res Rec 1331:21–27
Ravaji B, Mashadizade S, Hashemi A (2018) Introducing optimized validated meshing system for wellbore stability analysis using 3D finite element method. J Nat Gas Sci Eng 53:74–82. https://doi.org/10.1016/j.jngse.2018.02.0
Rowles R (2017) Drilling for water: a practical manual. Routledge, New York
Sang H, Zhang D, Gao Y et al (2019) Strain distribution based geometric models for characterizing the deformation of a sliding zone. Eng Geol 263:105300. https://doi.org/10.1016/j.enggeo.2019.105300
Shu B, Ma B (2015) Study of ground collapse induced by large-diameter horizontal directional drilling in a sand layer using numerical modeling. Can Geotech J 52(10):1562–1574. https://doi.org/10.1139/cgj-2014-0388
Sun SW, Zhu BZ, Wang JC (2003) Design method for stabilization of earth slopes with micropiles. Soils Found 53(4):487–497. https://doi.org/10.1016/j.sandf.2013.06.002
Tang J, Xu D, Liu H (2018) Effect of gravel content on shear behavior of sand-gravel mixture. Rock and soil mechanics (1): 13. [in Chinese]. https://doi.org/10.16285/j.rsm.2017.1527
Theinat AK (2015) 3D numerical modelling of micropiles interaction with soil & rock. Dissertation, Missouri University of Science and Technology
Wang X, Sterling RL (2007) Stability analysis of a borehole wall during horizontal directional drilling. Tunn Undergr Space Technol 22(5–6):620–632. https://doi.org/10.1016/j.tust.2007.01.002
Wang Q, Gao H, Jiang B et al (2020) Real-time method of obtaining rock mechanics parameters based on the core drilling test. Geotech Test J 43(2):480–494. https://doi.org/10.1520/GTJ20180080
Williamson HS (2000) Accuracy prediction for directional measurement while drilling. SPE Drill Complet 15(04):221–233. https://doi.org/10.2118/67616-PA
Xie X, Fjær E, Detournay E (2019) Time-dependent closure of a borehole in a viscoplastic rock. Geomech Energy Environ 19
Xu WJ, Hu RL, Tan RJ (2007) Some geomechanical properties of soil–rock mixtures in the Hutiao Gorge area. China Geotechnique 57(3):255–264. https://doi.org/10.1680/geot.2007.57.3.255
Yang SY, Yeh HD (2007) A closed-form solution for a confined flow into a tunnel during progressive drilling in a multi-layer groundwater flow system. Geophys Res Lett 34(7):248–265. https://doi.org/10.1029/2007GL029285
Zhai C, Xu Y, Xiang X et al (2015) A novel active prevention technology for borehole instability under the influence of mining activities. J Nat Gas Sci Eng 27:1585–1596. https://doi.org/10.1016/j.jngse.2015.10.024
Zhang J, Roegiers JC (2005) Double porosity finite element method for borehole modeling. Rock Mech Rock Eng 38(3):217–242. https://doi.org/10.1007/s00603-005-0052-9
Zhang H, Yin S, Aadnoy BS (2018a) Poroelastic modeling of borehole breakouts for in-situ stress determination by finite element method. J Petrol Sci Eng 162:674–684. https://doi.org/10.1016/j.petrol.2017.10.085
Zhang Y, Hu X, Tannant DD et al (2018b) Field monitoring and deformation characteristics of a landslide with piles in the Three Gorges Reservoir area. Landslides 15(3):581–592. https://doi.org/10.1007/s10346-018-0945-9
Zhang Y, Tang H, Li C et al (2018c) Design and testing of a flexible inclinometer probe for model tests of landslide deep displacement measurement. Sensors 18(1):224. https://doi.org/10.3390/s18010224
Zhao Y, Feng Z, Xi B et al (2015) Deformation and instability failure of borehole at high temperature and high pressure in hot dry rock exploitation. Renewable Energy 77:159–165. https://doi.org/10.1016/j.renene.2014.11.086
Zheng G, Wang RZ, Cheng XS et al. (2019) Mechanism of borehole group effect induced by pile foundation construction in soft soils. Journal of Tianjin University (Science and Technology) 52(1), 1–8. [in Chinese]. https://doi.org/10.11784/tdxbz201902028
Zhussupbekov A, Omarov A (2016) Modern advances in the field geotechnical testing investigations of pile foundations. Procedia Engineering 165:88–95. https://doi.org/10.1016/j.proeng.2016.11.739
Funding
This work was supported by the National Key Research and Development Program of China (2017YFC1501302) and the Key Program of National Natural Science Foundation of China (41630643). China Scholarship Council provided a scholarship (201906410044) to Chunye Ying for this research, which was conducted while he was a visiting Ph.D. student at the University of British Columbia.
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Conflict of interest
The authors declare no competing interests.
Rights and permissions
About this article
Cite this article
Ying, C., Hu, X., Siddiqua, S. et al. Model tests for observing the deformation characteristics of micropile boreholes during drilling in a soil-limestone mixture. Bull Eng Geol Environ 80, 6373–6393 (2021). https://doi.org/10.1007/s10064-021-02319-x
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10064-021-02319-x