Abstract
Extracorporeal centrifugal pumps are widely used in various forms of mechanical circulatory support, including extracorporeal membrane oxygenation and ventricular assist device. A durable centrifugal pump was developed by implementing a new hydrodynamic bearing design that prevents the impeller from touching to the casing wall and provides sufficient washout through the pump to prevent thrombus formation in the pump. The hydrodynamic bearings of the pump are composed of dual annular paths located on both sides of the impeller. Computational fluid dynamics analyses were performed on the flow field inside the pump to estimate the leakage flow through the gap and its impact on the pump efficiency and biocompatibility. The calculations were performed for motor speeds from 3000 to 5000 rpm and flow rates from 1.0 to 9.0 L/min. The leakage flow increased linearly with increasing pressure head of the pump, and the total leakage flow ranged from 2.0 to 27.3% of the total flow. The average wall shear stresses in the casing bottom ranged from 10.6 to 40.9 Pa. The leakage flow of the centrifugal pump with the hydrodynamically levitated impeller had a measurable impact on hydraulic energy losses while enhancing the washout flow to achieve good anti-thrombogenicity.
Similar content being viewed by others
References
Palanzo D, Qiu F, et al. Evolution of the extracorporeal life support circuitry. Artif Organs. 2010;34:869–73.
Bakhtiary F, Keller H, et al. Venoarterial extracorporeal membrane oxygenation for treatment of cardiogenic shock: clinical experiences in 45 adult patients. J Thorac Cardiovasc Surg. 2008;135:382–8.
Osaki S, Edwards NM, Velez M, Johnson MR, Murray MA, Hoffmann JA, Kohmoto T. Improved survival in patients with ventricular assist device therapy: the University of Wisconsin experience. Eur J Cardiothorac Surg. 2008;34:281–8.
Kashiwa K, Nishimura T, et al. Left heart bypass support with the Rotaflow Centrifugal Pump® as a bridge to decision and recovery in an adult. J Artif Organs. 2012;15:207–10.
Aaronson KD, Slaughter MS, et al. Use of an intrapericardial, continuous-flow, centrifugal pump in patients awaiting heart transplantation. Circulation. 2012;125:3191–200.
Mehra MR, Goldstein DJ, Uriel N, et al. 2-Year outcomes with a magnetically levitated cardiac pump in heart failure. N Engl J Med. 2018;378(15):1386–95.
Mendler N, Podechtl F, et al. Seal-less centrifugal blood pump with magnetically suspended rotor: rot-a-flot. Artif Organs. 1995;19:620–4.
Yamane T, Maruyama O, et al. Antithrombogenic properties of a monopivot magnetic-suspension centrifugal pump for circulatory assist. Artif Organs. 2008;32(6):484–9.
Takami Y, Ina H, Ohara Y. Morphological changes of the pivot bearings in the Gyro Pump C1E3 after clinical use. J Artif Organs. 2001;4:156–60.
Starling RC, Moazami N, et al. Unexpected abrupt increase in left ventricular assist device thrombosis. N Engl J Med. 2014;370(1):33–40.
Mueller JP, Kuenzli A, et al. The CentriMag: a new optimized centrifugal blood pump with levitating impeller. Heart Surg Forum. 2004;7(5):E477–80.
John R, Liao K, et al. Experience with the Levitronix CentriMag circulatory support system as a bridge to decision in patients with refractory acute cardiogenic shock and multisystem organ failure. J Thorac Cardiovasc Surg. 2007;134(2):351–8.
Bhama JK, Kornos RL, et al. Clinical experience using the Levitronix CentriMag system for temporary right ventricular mechanical circulatory support. J Heart Lung Transform. 2009;28(9):971–6.
Tsukiya T, Mizuno T, Takewa Y, Tatsumi E, Taenaka Y. Preclinical study of a novel hydrodynamically levitated centrifugal pump for long-term cardiopulmonary support : In vivo performance during percutaneous cardiopulmonary support. J Artif Organs. 2015;18(4):300–6.
Kishimoto S, Takewa Y, Tsukiya T, et al. Novel temporary left ventricular assist system with hydrodynamically levitated bearing pump for bridge to decision: initial preclinical assessment in a goat model. J Artif Organs. 2018;21(1):23–30.
Shimamura J, Mizuno T, Takewa Y, Tsukiya T, et al. Miniaturized centrifugal ventricular assist device for bridge to decision: preclinical chronic study in a bovine model. Artif Organs. 2019;43(9):821–7.
Seguchi O, Fujita T, et al. A novel extracorporeal continuous-flow ventricular assist system for patients with advanced heart failure—initial clinical experience. Circ J. 2020;84(7):1090–6.
Brennen CE. Hydrodynamic of Pumps. UK: Oxford University Press; 1994.
Gülich JF. Centrifugal Pumps. Berlin: Springer; 2010.
Chua LP, Ong KS, Yu CM, Zhou T. Leakage flow rate and wall shear stress distributions in a biocentrifugal ventricular assist device. ASAIO J. 2004;50(6):530–6.
The package inserts for Biofloat® centrifugal pump (in Japanese) Pharmaceuticals and Medical Devices Agency 2017 https://www.info.pmda.go.jp/ygo/pack/530100/22800BZX00321000_A_01_01/ Accessed 21 Nov 2021.
Hori Y. Fundamentals of Journal Bearings Hydrodynamic Lubrication. Tokyo: Springer; 2006.
Zhang J, Gellman B, et al. Computational and experimental evaluation of the fluid dynamics and hemocompatibility of the centrimag blood pump. Artif Organs. 2006;30(3):168–71.
Corbett SC, et al. In Vitro and computational thrombosis on artificial surfaces with shear stress. Artif Organs. 2010;34(7):561–9.
Paul R, Apel J, et al. Shear stress related blood damage in laminar couette flow. Artif Organs. 2003;27(6):517–29.
Acknowledgements
This research received no specific grant from any funding agency in the public, commercial, or
not-for-profit sectors. The authors would like to thank NIPRO Corp. for providing geometry data for the BIOFLOAT centrifugal pump. BIOFLOAT® is a registered trademark of NIPRO Corporation.
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Conflict of interest
Tomonori Tsukiya has no conflicts of interest directly relevant to the content of this article. Tomohiro Nishinaka received research funds under contract from NIPRO Corporation.
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Supplementary Information
Below is the link to the electronic supplementary material.
Supplementary file1
(DOCX 16 KB)
Supplementary file2
(EPS 903 KB)
Supplementary file3
(DOCX 17 KB)
Rights and permissions
Springer Nature or its licensor holds exclusive rights to this article under a publishing agreement with the author(s) or other rightsholder(s); author self-archiving of the accepted manuscript version of this article is solely governed by the terms of such publishing agreement and applicable law.
About this article
Cite this article
Tsukiya, T., Nishinaka, T. Numerical simulation of the leakage flow of the hydrodynamically levitated centrifugal blood pump for extracorporeal mechanical circulatory support systems. J Artif Organs 26, 176–183 (2023). https://doi.org/10.1007/s10047-022-01351-2
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10047-022-01351-2