Abstract
The electrochemical corrosion of the porous layer system nickel/chromium was investigated combining classical open circuit measurements, cyclic voltammetry, and zero-resistance Ammeter experiments. Under moderate conditions as there are low chloride concentration, pH 6, and high oxygen content the nickel layer acts as sacrificial anode, whereas at the chromium top layer oxygen reduction takes place. Under conditions of limited access of oxygen into pores potential oscillations occur which indicates a change of corrosion mechanism. Thereby the anode reaction changes between nickel and chromium dissolution. The respective cathode reaction is oxygen reduction or hydrogen evolution. The modeling of the potential oscillation reveals the character of the potential-dependent Flade potential as function of the proton concentration.
Similar content being viewed by others
References
Cicek V, Al-Numan B (2011) Corrosion chemistry. Wiley, New York
Etminanfar MR, Sohi MH (2012) Thin Solid Films 520:5322–5327
Bauer G, Donner C, Hartmann Ph,Wachter Ph (2010) Calciumchlorid Korrosion an dekorativ verchromten Auto Aussenteilen. Galvanotechnik 9
Ostwald W (1900) Z Phys Chem 35:33
Brauer E (1901) Über das elektrische Verhalten des Chroms bei der Auflösung in Säuren. Universitat Leipzig
Nicolis G, Prigogine I (1977) Self-organization in nonequilibrium systems. Wiley-Interscience, New York
Zaikin AN, Zhabotinsky AM (1970) Concentration wave propagation in two-dimensional liquid-phase self-oscillating system. Nature 225:535
Weil KG, Bonhoeffer KF (1955) Zur Passivität des Eisens in neutralen und schwach sauren Lösungen. Z PhysChem 4(3_4):175–191
Franck UF, Weil KG (1952) Z Elektrochem 56:814
Krischer K (1999) Principles of temporal and spatial pattern formation in electrochemical systems. In: Conway BE, Bockris Jo’M, White RE (eds) Modern aspects of electrochemistry, vol 32. Plenum Press, New York, pp 1–142
Krischer K (2003) Nonlinear dynamics in electrochemical systems. In: Alkire RC, Kolb DM (eds) Advances in Electrochemical Science and Engineering. 8: 89–208, Wiley, New York
Orlik M (2012) Self-organization in electrochemical systems. I. General principles of self-organization. Temporal instabilities. In: Scholz F (ed) Monographs in electrochemistry. Springer, Berlin
Orlik M (2012) Self-organization in electrochemical systems. II. Spatiotemporal patterns and control of chaos. In: Scholz F (ed) Monographs in electrochemistry. Springer, Berlin
Avrami M (1941) Kinetics of phase change. III: Granulation, phase change and microstructure. J Chem Phys 9:177–184
Milchev A (2002) Electrocrystallization: fundamentals of nucleation and growth. Springer, Berlin
Pohlmann L, Donner C, Baumgärtel H (1997) J Phys Chem B 101 49:10198–10204
Franck UF, FitzHugh R (1961) Z Elektrochem 65:156–168
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Pohlmann, L., Bauer, G., Hartmann, P. et al. Oscillatory passive active transition during the corrosion in nickel chromium layer systems. J Solid State Electrochem 17, 489–496 (2013). https://doi.org/10.1007/s10008-012-1949-3
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10008-012-1949-3