Abstract
Purpose
Surgical site infections represent a major complication of spinal surgery. The application of lyophilised vancomycin into the wound is reported to significantly decrease infection rates. As concentrations applied locally can exceed the minimal bacterial inhibitory concentration for more than a 1000-fold, toxic side effects on local tissue may be possible.
Methods
Primary osteoblast cell cultures were generated from bone tissue samples of 10 patients. Samples were incubated in absence or presence of either 3, 6 or 12 mg/cm2 vancomycin according to a planned phase I clinical trial protocol. Changes in pH, osteoblast migration, proliferation and viability were analysed. Alkaline phosphatase as well as mineralisation patterns was studied.
Results
The application of more than 3 mg/cm2 vancomycin induced a decline of pH. The migration potential of osteoblasts was decreased from 100 % (control samples) to zero (12 mg/cm2 vancomycin) in a dose-dependant manner. Cell proliferation was significantly inhibited at dosages above 3 mg/cm2. Significant cell death was observed if the dosage applied exceeded 6 mg/cm2. The synthesis of alkaline phosphatase was markedly reduced in all dosages applied and calcium deposition was significantly decreased in dosages above 3 mg/cm2.
Conclusion
As bone remodelling requires the immigration, proliferation and differentiation of osteoblasts at the fusion site, high dosages of intrawound vancomycin might interfere with regenerative processes and increase the risk of non-union. To allow an appropriate balance of infection risk and the risk of non-union, the minimal local concentration required should be determined by controlled in vivo studies.
Similar content being viewed by others
References
O’Neill KR, Smith JG, Abtahi AM et al (2011) Reduced surgical site infections in patients undergoing posterior spinal stabilization of traumatic injuries using vancomycin powder. Spine J 11:641–646. doi:10.1016/j.spinee.2011.04.025
Schuster JM, Rechtine G, Norvell DC, Dettori JR (2010) The influence of perioperative risk factors and therapeutic interventions on infection rates after spine surgery: a systematic review. Spine (Phila Pa 1976) 35:S125–S137. doi:10.1097/BRS.0b013e3181d8342c
Fang A, Hu SS, Endres N, Bradford DS (2005) Risk factors for infection after spinal surgery. Spine (Phila Pa 1976) 30:1460–1465
Olsen MA, Nepple JJ, Riew KD et al (2008) Risk factors for surgical site infection following orthopaedic spinal operations. J Bone Jt Surg Am 90:62–69. doi:10.2106/JBJS.F.01515
Borkhuu B, Borowski A, Shah SA et al (2008) Antibiotic-loaded allograft decreases the rate of acute deep wound infection after spinal fusion in cerebral palsy. Spine (Phila Pa 1976) 33:2300–2304. doi:10.1097/BRS.0b013e31818786ff
Li Y, Glotzbecker M, Hedequist D (2012) Surgical site infection after pediatric spinal deformity surgery. Curr Rev Musculoskelet Med. doi:10.1007/s12178-012-9111-5
Caroom C, Tullar JM, Benton EG et al (2013) Intrawound vancomycin powder reduces surgical site infections in posterior cervical fusion. Spine (Phila Pa 1976) 38:1183–1187. doi:10.1097/BRS.0b013e31828fcfb5
Pahys JM, Pahys JR, Cho SK et al (2013) Methods to decrease postoperative infections following posterior cervical spine surgery. J Bone Jt Surg Am 95:549–554. doi:10.2106/JBJS.K.00756
Gans I, Dormans JP, Spiegel DA et al (2013) Adjunctive vancomycin powder in pediatric spine surgery is safe. Spine (Phila Pa 1976) 38:1703–1707. doi:10.1097/BRS.0b013e31829e05d3
Molinari RW, Khera OA, Molinari WJ (2012) Prophylactic intraoperative powdered vancomycin and postoperative deep spinal wound infection: 1,512 consecutive surgical cases over a 6-year period. Eur Spine J 21(Suppl 4):S476–S482. doi:10.1007/s00586-011-2104-z
Sweet FA, Roh M, Sliva C (2011) Intrawound application of vancomycin for prophylaxis in instrumented thoracolumbar fusions: efficacy, drug levels, and patient outcomes. Spine (Phila Pa 1976) 36:2084–2088. doi:10.1097/BRS.0b013e3181ff2cb1
Godil SS, Parker SL, O’Neill KR et al (2013) Comparative effectiveness and cost-benefit analysis of local application of vancomycin powder in posterior spinal fusion for spine trauma: clinical article. J Neurosurg Spine 19:331–335. doi:10.3171/2013.6.SPINE121105
Mariappan R, Manninen P, Massicotte EM, Bhatia A (2013) Circulatory collapse after topical application of vancomycin powder during spine surgery. J Neurosurg Spine 19:381–383. doi:10.3171/2013.6.SPINE1311
Sweet F, Sliva C, Roh M (2009) Intra-wound application of vancomycin for prophylaxis in instrumented thoracolumbar fusions. Spine J 9:5S. doi:10.1016/j.spinee.2009.08.014
Soriano A, Marco F, Martínez JA et al (2008) Influence of vancomycin minimum inhibitory concentration on the treatment of methicillin-resistant Staphylococcus aureus bacteremia. Clin Infect Dis 46:193–200. doi:10.1086/524667
Dose escalation trial of intrasite vancomycin pharmacokinetics—full text view—clinicaltrials.gov. http://clinicaltrials.gov/show/NCT01764750. Accessed 18 Mar 2015
Chakkalakal DA, Mashoof AA, Novak J et al (1994) Mineralization and pH relationships in healing skeletal defects grafted with demineralized bone matrix. J Biomed Mater Res 28:1439–1443. doi:10.1002/jbm.820281209
Lee G-H, Hwang J-D, Choi J-Y et al (2011) An acidic pH environment increases cell death and pro-inflammatory cytokine release in osteoblasts: the involvement of BAX inhibitor-1. Int J Biochem Cell Biol 43:1305–1317. doi:10.1016/j.biocel.2011.05.004
Vacanti CA, Pietrzak WS (2008) Musculoskeletal tissue regeneration: biological materials and methods (Google eBook). p 670
Golub EE, Harrison G, Taylor AG et al (1992) The role of alkaline phosphatase in cartilage mineralization. Bone Miner 17:273–278
Wang S (2011) Antibiotic-impregnated cement temporary spacer for surgical treatment of osteomyelitis and nonunion of bone caused by intramedullary nailing. Zhongguo Xiu Fu Chong Jian Wai Ke Za Zhi 25:972–975
Shyam AK, Sancheti PK, Patel SK et al (2009) Use of antibiotic cement-impregnated intramedullary nail in treatment of infected non-union of long bones. Indian J Orthop 43:396–402. doi:10.4103/0019-5413.55468
Murray WR (1984) Use of antibiotic-containing bone cement. Clin Orthop Relat Res 89–95
Cui L, Iwamoto A, Lian JQ et al (2006) Novel mechanism of antibiotic resistance originating in vancomycin-intermediate Staphylococcus aureus. Antimicrob Agents Chemother 50(2):428–438
Bourgeois-Nicolaos N, Massias L, Couson B et al (2007) Dose dependance of emergence of resistance to linezolid in Enterococcus faecalis in vivo. J Infect Dis 195:1480–1488
Acknowledgments
We would like to thank Mrs P. Gludovatz, M.Sc. (pharm) for providing the vancomycin used in our experiments, Mrs Julia Hahne, M. Sc. for statistical advice, Mrs Maria Gusenbauer and the staff from the central sterilisation unit for the great cooperation and Mr. P. Pleininger for IT-support. We would also like to thank Mr. Erwin Falkner for monitoring GLP compliance of experimental documentation.
Conflict of interest
None.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Eder, C., Schenk, S., Trifinopoulos, J. et al. Does intrawound application of vancomycin influence bone healing in spinal surgery?. Eur Spine J 25, 1021–1028 (2016). https://doi.org/10.1007/s00586-015-3943-9
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00586-015-3943-9