Abstract
The research on materials and systems for tunable microwave devices has gained attraction within the last years. The radio frequency characterization and the component design of tunable microwave components based on dielectric ceramics especially barium-strontium-titanate (BST) are presented in this second part, whereas the basic material properties are discussed in detail in the first part. After a short introduction to the processing technology used for the fabrication of tunable components based on a BST thick film, the relations between microwave properties and material properties as well as the microstructure are presented in detail. The design process for tunable microwave components based on BST thick films is described. Especially the considerations related to micro- and macrostructure and their connection are highlighted. The paper closes with two different application examples: a reconfigurable array antenna for satellite communication and varactors for high power applications.
Similar content being viewed by others
References
Alexiou A, Haardt M (2004) Smart antenna technologies for future wireless systems: trends and challenges. IEEE Commun Mag 42(9):90–97. doi:10.1109/MCOM.2004.1336725
Arlt G, Hennings D, de With G (1985) Dielectric properties of fine-grained barium titanate ceramics. J Appl Phys 58(4):1619–1625. doi:10.1063/1.336051
De Los Santos H, Fischer G, Tilmans H, van Beek J (2004) RF MEMS for ubiquitous wireless connectivity. Part II. Application. IEEE Microw 5(4):50–65. doi:10.1109/MMW.2004.1380278(410)
Gevorgian S, Martinsson T, Linner P, Kollberg E (1996) CAD models for multilayered substrate interdigital capacitors. IEEE Trans Microw Theory Tech 44(6):896–904. doi:10.1109/22.506449
Gevorgian S, Vorobiev A, Lewin T (2006) dc field and temperature dependent acoustic resonances in parallel-plate capacitors based on SrTiO3 and Ba0.25Sr0.75TiO3 films: experiment and modeling. J Appl Phys 99(12):124112. doi:010.1063/1.2209727
Giere A, Scheele P, Damm C, Jakoby R (2005) Optimization of uniplanar multilayer structures using nonlinear tunable dielectrics. In: Proceedings of the European microwave conference 2005, vol 1. doi:10.1109/EUMC.2005.1608918
Giere A, Damm C, Scheele P, Jakoby R (2006) LH phase shifter using ferroelectric varactors. In: Proceedings of the IEEE radio and wireless symposium, pp 403–406. doi:10.1109/RWS.2006.1615180
Giere A, Scheele P, Zheng Y, Jakoby R (2007) Characterization of the field-dependent permittivity of Nonlinear ferroelectric films using tunable coplanar lines. IEEE Microw Wirel Compon Lett 17(6):442–444. doi:10.1109/LMWC.2007.897795
Heinrich W (1993) Quasi-TEM description of MMIC coplanar lines including conductor-loss effects. IEEE Trans Microw Theory Tech 41(1):45–52. doi:10.1109/22.210228
Jeon JH (2004) Effect of SrTiO3 concentration and sintering temperature on microstructure and dielectric constant of Ba1-xSrxTiO3. J Eur Ceram Soc 24(6):1045–1048. doi:10.1016/S0955-2219(03)00385-6
Karabey OH, Bildik S, Fritzsch C, Strunck S, Gaebler A, Jakoby R, Manabe A (2010) Liquid crystal based rekonfigurable antenna arrays. In: Proceedings of the 32nd ESA Antenna workshop
Kozyrev A, Soldatenkov O, Ivanov A (1998) Switching time of planar ferroelectric capacitors using strontium titanate and barium strontium titanate films. Tech Phys Lett 24:755–757. doi:10.1134/1.1262255
Laur V, Rousseau A, Tanne G, Laurent P, Huret F, Guilloux-Viry M, Della B (2005) Tunable microwave components based on KTxNb1-xO3 ferroelectric material. In: Proceedings of the European Microwave Conference 2005, vol 1. doi:10.1109/EUMC.2005.1608938
Maune H, Sazegar M, Zheng Y, Jakoby R (2010a) Ferroelectric thick-film varactors based on barium-strontium-titanate for high power applications. In: IEEE radio and wireless symposium (RWS), pp 424–427. doi:10.1109/RWS.2010.5434186
Maune H, Sazegar M, Zhou X, Zheng Y, Jakoby R (2010b) Ferroelectric thick-film varactors for efficiency enhancement of power amplifiers. In: Proceeding of the IEEE power amplifier symposium, pp 63–64
Meyer R, Stephens M (1975) Distortion in variable-capacitance diodes. IEEE J Solid State Circuits 10(1):47–54
Mitola J (1995) The software radio architecture. IEEE Commun Mag 33(5):26–38. doi:10.1109/35.393001
Müller S, Mössinger A, Marin R, Gölden F, Lapanik A, Haase W, Jakoby R (2007) Liquid crystals—microwave characterization and tunable devices. Frequenz 61:217–223
Park J, Lut J, Stemmert S, York R (2005) Microwave planar capacitors employing low loss, high-K, and tunable BZN thin films. In: IEEE MTT-S international microwave symposium digest. doi:10.1109/MWSYM.2005.1516673
Parker D, Zimmermann D (2002) Phased arrays—part 1: theory and architectures. IEEE Trans Microw Theory Tech 50(3):678–687. doi:10.1109/22.989953
Pärssinen A (2009) RF system and architecture challenges for multi-standard mobile devices. In: Workshop—proceedings of the international microwave symposium 2009
Sazegar M, Zheng Y, Maune H, Damm C, Zhou X, Binder J, Jakoby R (2010a) Low cost phased array antenna using compact tunable phase shifters based on ferroelectric ceramics. IEEE Trans Microw Theory Tech (Submitted)
Sazegar M, Zheng Y, Maune H, Zhou X, Damm C, Jakoby R (2010b) Compact artificial line phase shifter on ferroelectric thick-film ceramics. In: IEEE MTT-S international microwave symposium digest, pp 860–863. doi:10.1109/MWSYM.2010.5518181
Scheele P, Giere A, Zheng Y, Goelden F, Jakoby R (2007) Modeling and applications of ferroelectric-thick film devices with resistive electrodes for linearity improvement and tuning-voltage reduction. IEEE Trans Microwave Theory Tech 55(2):383–390. doi:10.1109/TMTT.2006.889351
Sherman VO, Tagantsev AK, Setter N, Iddles D, Price T (2006) Ferroelectric-dielectric tunable composites. J Appl Phys 99(7):074104. doi:10.1063/1.2186004
Tagantsev AK, Sherman VO, Astafiev KF, Venkatesh J, Setter N (2003) Ferroelectric materials for microwave tunable applications. J Electroceram 11(1−2):5–66. doi:10.1023/B:JECR.0000015661.81386.e6
Tappe S, Böttger U, Waser R (2004) Electrostrictive resonances in (Ba0.7Sr0.3)TiO3 thin films at microwave frequencies. Appl Phys Lett 85(4):624–626. doi:10.1063/1.1775880
Weil C (2003) Passiv steuerbare Mikrowellenphasenschieber auf der Basis nichtlinearer Dielektrika. PhD thesis, Technische Universität Darmstadt
Xu J, Menesklou W, Ivers-Tiffée E (2005) Investigation of BZT thin films for tunable microwave applications J Eur Ceram Soc 25:2289–2293
Zheng Y, Hristov A, Giere A, Jakoby R (2008) Suppression of harmonic radiation of tunable PIFA by thick-film BST varactor loading. In: IEEE MTT-S international microwave symposium digest, pp 959–962. doi:10.1109/MWSYM.2008.4632993
Zimmermann F, Menesklou W, Ivers-TiffTe E (2004a) Investigation of Ag(Ta,Nb)O3 as tunable microwave dielectric. J Eur Ceram Soc 24(6):1811–1814. doi:10.1016/S0955-2219(03)00486-2
Zimmermann F, Voigts M, Menesklou W, Ivers-Tiffée E (2004b) Ba0.6Sr0.4TiO3 and BaZr0.3Ti0.7O3 thick films as tunable microwave dielectrics. J Eur Ceram Soc 24(6):1729–1733. doi:10.1016/S0955-2219(03)00481-3
Acknowledgments
This work was partly supported by the DFG Research Training Group “Tunable integrated components in microwave technology and optics” (TICMO).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Maune, H., Sazegar, M., Zheng, Y. et al. Nonlinear ceramics for tunable microwave devices. Microsyst Technol 17, 213–224 (2011). https://doi.org/10.1007/s00542-011-1235-9
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00542-011-1235-9