Skip to main content
SpringerLink
Log in

Rehabilitation of Achilles tendon ruptures: is early functional rehabilitation daily routine?

  • Trauma Surgery
  • Published:
Archives of Orthopaedic and Trauma Surgery Aims and scope Submit manuscript

Abstract

Introduction

Ruptures of the Achilles tendon are the most common tendon injuries of the lower extremities. Besides the initial operative or non-operative treatment, rehabilitation of patients plays a crucial role for tendon healing and long-term outcome. As only limited evidence is available for optimized rehabilitation regimen and guidelines for the initial (e.g., first 6 weeks) rehabilitation are limited, this study investigated the current rehabilitation concepts after Achilles tendon rupture.

Materials and methods

We analyzed 213 written rehabilitation protocols that are provided by orthopedic and trauma surgery institutions throughout Germany in terms of recommendations for weight-bearing, range of motion (ROM), physiotherapy, and choice of orthosis. All protocols for operatively and non-operatively treated Achilles tendon ruptures were included. Descriptive analysis was carried out and statistical analysis applied where appropriate.

Results

Of 213 institutions, 204 offered rehabilitation protocols for Achilles tendon rupture and, therefore, 243 protocols for operative and non-operative treatment could be analyzed. While the majority of protocols allowed increased weight-bearing over time, significant differences were found for durations of fixed plantar flexion between operative (o) and non-operative (n) treatments [fixed 30° (or 20)° to 15° (or 10)°: 3.6 weeks (±0.1; o) vs 4.7 weeks (±0.3; n) (p ≤ 0.0001) and fixed 15° (or 10)° to 0°: 5.8 weeks (±0.1; o) vs 6.6 weeks (±0.2; n) (p ≤ 0.001)]. The mean time of the recommended start of physiotherapy is at 2.9 weeks (±0.2; o) vs 3.3 weeks (±0.4; n), respectively.

Conclusion

Our study shows that a huge variability in rehabilitation after Achilles tendon rupture exists. This study shows different strategies in rehabilitation of Achilles tendon ruptures using a convertible vacuum brace system. To improve patient care, further clinical as well as biomechanical studies need to be conducted. This study might serve as basis for prospective randomized controlled trials to optimize rehabilitation for Achilles tendon ruptures.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3

Similar content being viewed by others

References

  1. Lopes AD, Hespanhol Jr MLC, Yeung SS, Costa LOP (2012) What are the main running-related musculoskeletal injuries? Sports Med 42:891–905

    Article  PubMed  PubMed Central  Google Scholar 

  2. Claessen FMAP, de Vos R-J, Reijman M, Meuffels DE (2014) Predictors of primary Achilles tendon ruptures. Sports Med 44:1241–1259. doi:10.1007/s40279-014-0200-z

    Article  PubMed  Google Scholar 

  3. Maffulli N, Wong J, Almekinders LC (2003) Types and epidemiology of tendinopathy. Clin Sports Med 22:675–692

    Article  PubMed  Google Scholar 

  4. Weinreb JH, Sheth C, Apostolakos J, et al (2014) Tendon structure, disease, and imaging. Muscles Ligaments Tendons J 4:66–73.

    PubMed  PubMed Central  Google Scholar 

  5. Riley G (2003) The pathogenesis of tendinopathy. A molecular perspective. Rheumatology 43:131–142. doi:10.1093/rheumatology/keg448

    Article  PubMed  Google Scholar 

  6. Khan K, Cook J (2003) The painful nonruptured tendon: clinical aspects. Clin Sports Med 22:711–725

    Article  PubMed  Google Scholar 

  7. Nilsson-Helander K, Silbernagel KG, Thomee R et al (2010) Acute Achilles tendon rupture: a randomized, controlled study comparing surgical and nonsurgical treatments using validated outcome measures. Am J Sports Med 38:2186–2193. doi:10.1177/0363546510376052

    Article  PubMed  Google Scholar 

  8. Jiang N, Wang B, Chen A et al (2012) Operative versus nonoperative treatment for acute Achilles tendon rupture: a meta-analysis based on current evidence. Int Orthop 36:765–773. doi:10.1007/s00264-011-1431-3

    Article  PubMed  Google Scholar 

  9. Olsson N, Silbernagel KG, Eriksson BI et al (2013) Stable surgical repair with accelerated rehabilitation versus nonsurgical treatment for acute Achilles tendon ruptures: a randomized controlled study. Am J Sports Med 41:2867–2876. doi:10.1177/0363546513503282

    Article  PubMed  Google Scholar 

  10. Jielile J, Badalihan A, Qianman B, et al (2015) Clinical outcome of exercise therapy and early post-operative rehabilitation for treatment of neglected Achilles tendon rupture: a randomized study. Knee Surg Sports Traumatol Arthrosc Off J ESSKA. doi:10.1007/s00167-015-3598-4

    Google Scholar 

  11. Kangas J, Pajala A, Siira P et al (2003) Early functional treatment versus early immobilization in tension of the musculotendinous unit after Achilles rupture repair: a prospective, randomized, clinical study. J Trauma 54:1171-1180-1181. doi:10.1097/01.TA.0000047945.20863.A2

    Article  Google Scholar 

  12. Holm C, Kjaer M, Eliasson P (2015) Achilles tendon rupture–treatment and complications: a systematic review. Scand J Med Sci Sports 25:e1–e10. doi:10.1111/sms.12209

    Article  CAS  PubMed  Google Scholar 

  13. Rantanen J, Hurme T, Paananen M (1993) Immobilization in neutral versus equinus position after Achilles tendon repair. A review of 32 patients. Acta Orthop Scand 64:333–335

    Article  CAS  PubMed  Google Scholar 

  14. Mortensen NHM, Skov O, Jensen PE (1999) Early motion of the ankle after operative treatment of a rupture of the Achilles tendon. A prospective, randomized clinical and radiographic study*. J Bone Jt Surg Am 81:983–990

    Article  CAS  Google Scholar 

  15. Porter MD, Shadbolt B (2015) Randomized controlled trial of accelerated rehabilitation versus standard protocol following surgical repair of ruptured Achilles tendon. ANZ J Surg 85:373–377. doi:10.1111/ans.12910

    Article  PubMed  Google Scholar 

  16. Häggmark T, Eriksson E (1979) Hypotrophy of the soleus muscle in man after Achilles tendon rupture. Discussion of findings obtained by computed tomography and morphologic studies. Am J Sports Med 7:121–126

    Article  PubMed  Google Scholar 

  17. Maxwell LC, Enwemeka CS (1992) Immobilization-induced muscle atrophy is not reversed by lengthening the muscle. Anat Rec 234:55–61. doi:10.1002/ar.1092340107

    Article  CAS  PubMed  Google Scholar 

  18. Khan RJ, Fick D, Keogh A et al (2005) Treatment of acute Achilles tendon ruptures. J Bone J Surg 87:2202–2210

    Google Scholar 

  19. Mark-Christensen T, Troelsen A, Kallemose T, Barfod KW (2014) Functional rehabilitation of patients with acute Achilles tendon rupture: a meta-analysis of current evidence. Knee Surg Sports Traumatol Arthrosc Off J ESSKA. doi:10.1007/s00167-014-3180-5

    Google Scholar 

  20. Jackson G, Sinclair VF, McLaughlin C, Barrie J (2013) Outcomes of functional weight-bearing rehabilitation of Achilles tendon ruptures. Orthopedics 36:e1053–e1059. doi:10.3928/01477447-20130724-23

    Article  PubMed  Google Scholar 

  21. Groetelaers RPTGC, Janssen L, van der Velden J et al (2014) Functional treatment or cast immobilization after minimally invasive repair of an acute Achilles tendon rupture: prospective, randomized trial. Foot Ankle Int 35:771–778. doi:10.1177/1071100714536167

    Article  PubMed  Google Scholar 

  22. Huang J, Wang C, Ma X et al (2015) Rehabilitation regimen after surgical treatment of acute Achilles tendon ruptures: a systematic review with meta-analysis. Am J Sports Med 43:1008–1016. doi:10.1177/0363546514531014

    Article  PubMed  Google Scholar 

  23. McCormack R, Bovard J (2015) Early functional rehabilitation or cast immobilisation for the postoperative management of acute Achilles tendon rupture? A systematic review and meta-analysis of randomised controlled trials. Br J Sports Med 49:1329–1335. doi:10.1136/bjsports-2015-094935

    Article  CAS  PubMed  Google Scholar 

  24. Brumann M, Baumbach SF, Mutschler W, Polzer H (2014) Accelerated rehabilitation following Achilles tendon repair after acute rupture—development of an evidence-based treatment protocol. Injury 45:1782–1790. doi:10.1016/j.injury.2014.06.022

    Article  PubMed  Google Scholar 

  25. Young SW, Patel A, Zhu M et al (2014) Weight-bearing in the nonoperative treatment of acute Achilles tendon ruptures: a randomized controlled trial. J Bone Joint Surg Am 96:1073–1079. doi:10.2106/JBJS.M.00248

    Article  PubMed  Google Scholar 

  26. Osarumwense D, Wright J, Gardner K, James L (2013) Conservative treatment for acute Achilles tendon rupture: survey of current practice. J Orthop Surg 21:44

    Article  Google Scholar 

  27. Eyfferth T, Bak P, Hoffmann R (2011) Rehabilitation und Belastungsaufbau nach Frakturen: Oberes Sprunggelenk und Pilon tibiale. Trauma Berufskrankh 13:183–190. doi:10.1007/s10039-011-1751-y

    Article  Google Scholar 

  28. Suchak AA, Spooner C, Reid DC, Jomha NM (2006) Postoperative rehabilitation protocols for Achilles tendon ruptures: a meta-analysis. Clin Orthop 445:216–221. doi:10.1097/01.blo.0000203458.05135.74

    PubMed  Google Scholar 

  29. Kearney RS, McGuinness KR, Achten J, Costa ML (2012) A systematic review of early rehabilitation methods following a rupture of the Achilles tendon. Physiotherapy 98:24–32. doi:10.1016/j.physio.2011.04.349

    Article  PubMed  Google Scholar 

  30. Wills CA, Washburn S, Caiozzo V, Prietto CA (1986) Achilles tendon rupture. A review of the literature comparing surgical versus nonsurgical treatment. Clin Orthop 156–163

  31. Smart GW, Taunton JE, Clement DB (1980) Achilles tendon disorders in runners—a review. Med Sci Sports Exerc 12:231–243

    Article  CAS  PubMed  Google Scholar 

  32. Gillies H, Chalmers J (1970) The management of fresh ruptures of the tendo achillis. J Bone Jt Surg Am 52:337–343

    Article  CAS  Google Scholar 

  33. Gruber J, Giza E, Zachazewski J, Mandelbaum BR (2013) Achilles tendon repair and rehbilitation. In: Maxey L, Magnusson J (eds) Rehabil. Postsurgical Orthop. Patient, 3rd ed. Elsevier/Mosby, St. Louis, pp 554–578

    Chapter  Google Scholar 

  34. Saleh M, Marshall PD, Senior R, MacFarlane A (1992) The Sheffield splint for controlled early mobilisation after rupture of the calcaneal tendon. A prospective, randomised comparison with plaster treatment. J Bone Joint Surg Br 74:206–209

    CAS  PubMed  Google Scholar 

  35. Khan RJK, Fick D, Brammar TJ, et al (2004) Interventions for treating acute Achilles tendon ruptures. Cochrane Database Syst Rev. doi:10.1002/14651858.CD003674.pub2

    Google Scholar 

  36. Sorrenti SJ (2006) Achilles tendon rupture: effect of early mobilization in rehabilitation after surgical repair. Foot Ankle Int 27:407–410

    Article  PubMed  Google Scholar 

  37. Porter DA, Barnes AF, Rund AM et al (2014) Acute Achilles tendon repair: strength outcomes after an acute bout of exercise in recreational athletes. Foot Ankle Int 35:123–130. doi:10.1177/1071100713514228

    Article  PubMed  Google Scholar 

  38. Soroceanu A, Sidhwa F, Aarabi S et al (2012) Surgical versus nonsurgical treatment of acute Achilles tendon rupture: a meta-analysis of randomized trials. J Bone Jt Surg Am 94:2136. doi:10.2106/JBJS.K.00917

    Article  Google Scholar 

  39. Costa ML, MacMillan K, Halliday D et al (2006) Randomised controlled trials of immediate weight-bearing mobilisation for rupture of the tendo Achillis. J Bone Joint Surg Br 88:69–77

    Article  CAS  PubMed  Google Scholar 

  40. Lea RB, Smith L (1972) Non-surgical treatment of tendo achillis rupture. J Bone Joint Surg Am 54:1398–1407

    Article  CAS  PubMed  Google Scholar 

  41. Carden DG, Noble J, Chalmers J, et al (1987) Rupture of the calcaneal tendon. The early and late management. J Bone Joint Surg Br 69:416–420

    CAS  PubMed  Google Scholar 

  42. Williams JGP (1986) Achilles tendon lesions in sport. Sports Med 3:114–135

    Article  CAS  PubMed  Google Scholar 

  43. Palmes D, Spiegel HU, Schneider TO et al (2002) Achilles tendon healing: long-term biomechanical effects of postoperative mobilization and immobilization in a new mouse model. J Orthop Res Off Publ Orthop Res Soc 20:939–946. doi:10.1016/S0736-0266(02)00032-3

    Article  CAS  Google Scholar 

  44. Rantanen J, Hurme T, Kalimo H (1999) Calf muscle atrophy and Achilles tendon healing following experimental tendon division and surgery in rats. Comparison of postoperative immobilization of the muscle-tendon complex in relaxed and tensioned positions. Scand J Med Sci Sports 9:57–61

    Article  CAS  PubMed  Google Scholar 

  45. Stöckle U, König B, Tempka A, Südkamp NP (2000) Cast Immobilization or Vacuum Stabilizing System? Unfallchirurg 103:215–219

    Article  PubMed  Google Scholar 

  46. Carter TR, Fowler PJ, Blokker C (1992) Functional postoperative treatment of Achilles tendon repair. Am J Sports Med 20:459–462

    Article  CAS  PubMed  Google Scholar 

  47. Ecker TM, Bremer AK, Krause FG et al (2016) Prospective use of a standardized nonoperative early weightbearing protocol for Achilles tendon rupture: 17 years of experience. Am J Sports Med. doi:10.1177/0363546515623501

    PubMed  Google Scholar 

  48. Thermann H (1998) Die Behandlung der Achillessehnenruptur. Unfallchirurg 101:299–314

    Article  CAS  PubMed  Google Scholar 

Download references

Author information

Authors and Affiliations

  1. Department of Trauma and Orthopedic Surgery, FIFA-Medical Centre of Excellence, University Medical Centre Regensburg, Franz-Josef-Strauss Allee 11, 93053, Regensburg, Germany

    B. Frankewycz, W. Krutsch, J. Weber, A. Ernstberger, M. Nerlich & Christian G. Pfeifer

Authors
  1. B. Frankewycz
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. W. Krutsch
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. J. Weber
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. A. Ernstberger
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. M. Nerlich
    View author publications

    You can also search for this author in PubMed Google Scholar

  6. Christian G. Pfeifer
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Christian G. Pfeifer.

Ethics declarations

Conflict of interest

All authors declare no potential conflict of interest.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Frankewycz, B., Krutsch, W., Weber, J. et al. Rehabilitation of Achilles tendon ruptures: is early functional rehabilitation daily routine?. Arch Orthop Trauma Surg 137, 333–340 (2017). https://doi.org/10.1007/s00402-017-2627-9

Download citation

  • Received:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s00402-017-2627-9

Keywords

Search

Navigation