Abstract
Composite latex particles consisting of epoxidised natural rubber (ENR) and poly(methyl methacrylate) (PMMA) were synthesised to obtain interpenetrating polymer networks. Among the ENR latices having 9 to 36 mol% epoxide, prepared by in situ reaction using performic acid, the ENR latex with 25 mol% epoxide was selected for prevulcanisation by sulphur or γ-radiation system. The swelling ratios of sheets cast from the sulphur-prevulcanised ENR (SPENR) latices decreased with increasing prevulcanisation time while those cast from the γ-radiation-prevulcanised ENR latices were also inversely proportional to the irradiation dose. By applying the phase transfer/bulk polymerisation/transmission electron microscopy (TEM) technique, a homogeneous network structure in each of the SPENR particles and also a relative dense network near the surface in γ-radiation (RV) ENR particle were noticed. When 10 to 30 wt% of MMA swollen in ENR particles was polymerised, the mesh structure was observed in each particle. The dense network near the RVENR particle surface might be used as additional evidence that the degree of epoxidation and, hence, the presence of swollen n-butyl acrylate in the outer zone were higher than in the internal region.
Similar content being viewed by others
References
Lu G, Li ZF, Li SD, Xie J (2002) J Appl Polym Sci 85:1736
Lee DY, Subramaniam N, Fellows CM, Gilbert RG (2002) J Polym Sci A Polym Chem 40:809
Varkey JT, Rao SS, Thomas S (1996) J Appl Polym Sci 62:2169
Claramma NM, Mathew NM (1997) J Appl Polym Sci 65:1913
Makuuchi K, Hagiwara M (1984) J Appl Polym Sci 29:965
Hill DJT, O’Donnell JH, Perera MSC, Pomery PJ, Smetser P (1995) J Appl Polym Sci 57:1155
Porter M, Rawi R, Rahim SA (1992) J Nat Rubber Res 7:85
Ho CC, Khew MC (1999) Langmuir 15:6208
Hamzah S, Gomez JB, Rama RPS (1987) J Nat Rubber Res 2:118
Cook S, Cudby PEF, Davies RT, Morris MD (1997) Rubber Chem Technol 70:549
Tangboriboonrat P, Lerthititrakul C (2002) Colloid Polym Sci 280:1097
Tangboriboonrat P, Tiyapiboonchaiya C (1999) J Appl Polym Sci 71:133
Tangboriboonrat P, Tanunchai T, Tiyapiboonchaiya C (1999) Plast Rubber Compos 25:357
Hourston DJ, Romaine J (1989) Eur Polym J 25:695
Hourston DJ, Romaine J (1990) J Appl Polym Sci 39:1587
Sperling LH, Mishra V (1996) Polym Adv Technol 7:197
Schneider M, Pith T, Lambla MJ (1996) J Appl Polym Sci 62:273
Hashim AS, Kohjiya S (1993) Kautsch Gummi Kunstst 46:208
Gelling IR, Morrison NJ (1985) Rubber Chem Technol 58:243
Kumar RN, Kong WC, Abubakar A (1999) J Coat Technol 71:79
Ratnam CT, Nasir M, Baharin A, Zaman K (2000) Polym Int 49:1693
Tangboriboonrat P, Rakdee C (2000) Plast Rubber Compos 29:258
Blackley DC (1987) Latices. In: Mark HF, Bikaks NM, Overberger CG (eds) Encyclopedia of polymer science and engineering, vol 8, 2nd edn. Wiley, p 647
Perera MCS, Elix JA, Bradbury JH (1988) J Polym Sci A Polym Chem 26:637
Burfield DR, Lim KL, Law KS, Ng S (1984) Polymer 25:995
Sanguansap K, Suteewong T, Saendee P, Buranabunya U, Tangboriboonrat P (2005) Polymer 46:1373
Vernekar SP, Sabne MB, Patil SD, Patil AS, Idage SB, Avadhani CV, Sivaram S (1992) J Appl Polym Sci 44:2107
Blackley DC, Aisah AAN, Twaits R (1979) Plastics and rubber: materials and applications, May:77
Brandrup J, Immergut EH (1975) Polymer handbook, 2nd edn. Wiley-Interscience, New York
Lua CM, Gomez JB, Subramanium A (1985) Proceedings of the international rubber conference, Kuala Lumpur, Malaysia, p 525
Acknowledgements
The authors gratefully acknowledge the Thailand Research Fund (TRF) for the financial support. Special thanks go to the Office of Atomic Energy for Peace (Thailand) for allowing us to use the 60Co γ-ray source.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Saendee, P., Tangboriboonrat, P. Latex interpenetrating polymer networks of epoxidised natural rubber/poly(methyl methacrylate): an insight into the mechanism of epoxidation. Colloid Polym Sci 284, 634–643 (2006). https://doi.org/10.1007/s00396-005-1437-8
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00396-005-1437-8