Abstract
In this study, ZnO micro/nanorods were grown on both glass and p-Si substrates by a simple and applicable homemade chemical spray pyrolysis method. X-ray diffraction (XRD) and scanning electron microscopy (SEM) were used to analyze the structural and morphological features of the produced ZnO layers, revealing the presence of ZnO micro/nanorods with high crystallinity of various orientations and diameters. The interface performance of these ZnO micro/nanorod arrays in the Co/p-Si device was also investigated and the rectification ratio of the fabricated Co/ZnO micro-nanorods/p-Si device at ± 1 V was calculated in the order of 103. In addition, some photodiode parameters, such as responsivity, sensitivity, and specific detectivity, were investigated depending on the increased light power intensity from 150 to 300 mW/cm2. Finally, the performance of ZnO micro/nanorod arrays during degradation of Rhodamine B dyestuff under UVA light was investigated and it was concluded that they could have good photocatalytic activity in advanced oxidation processes. All results supported that ZnO micro/nanorod arrays obtained by a simple homemade chemical spray pyrolysis method in this study have the potential for optical applications.
Similar content being viewed by others
Data availability
Data available on request from the authors.
References
A. Wibowo, M.A. Marsudi, M.I. Amal, M.B. Ananda, R. Stephanie, H. Ardy, L.J. Diguna, RSC Adv. 10, 42838 (2020)
S.A. Tawfik, H. Tran, M.J.S. Spencer, Nanoscale Adv. 4, 546 (2022)
P. Supraja, R.R. Kumar, S. Mishra, D. Haranath, P.R. Sankar, K. Prakash, N. Jayarambabu, T.V. Rao, K.U. Kumar, Sens. Actuators A Phys. 335, 113368 (2022)
A. Irshad, M. Zulfiqar, H.M. Ali, N. Shahzadi, H.H. Abd El-Gawad, C. Chokejaroenrat, C. Sakulthaew, F. Anjum, M. Suleman, Ceram. Int. 48, 29805 (2022)
H. Widiyandari, N.A. Ketut Umiati, R. Dwi Herdianti, J. Phys. Conf. Ser. 1025, 012004 (2018)
B. Palanivel, R.R. Macadangdang, M.S. Hossain, F.A. Alharthi, M. Kumar, J.-H. Chang, S. Gedi, J. Rare Earths 41, 77–84 (2023). https://doi.org/10.1016/j.jre.2022.01.009
G.M. Ali, A.K. Khalid, S.M. Swadi, J. Semicond. 41, 102103 (2020)
B. Kilic, S. Turkdogan, A. Astam, S.S. Baran, M. Asgin, E. Gur, Y. Kocak, J. Nanoparticle Res. 20, 11 (2018)
M. Yilmaz, G. Turgut, S. Aydin, M. Ertugrul, Asian J. Chem. 24, 3371 (2012)
E. Kärber, T. Raadik, T. Dedova, J. Krustok, A. Mere, V. Mikli, M. Krunks, Nanoscale Res. Lett. 6, 359 (2011)
T.H. Flemban, M.A. Haque, I. Ajia, N. Alwadai, S. Mitra, T. Wu, I.S. Roqan, A.C.S. Appl, Mater. Interfaces 9, 37120 (2017)
Y. Zhong, C. Peng, Z. He, D. Chen, H. Jia, J. Zhang, H. Ding, X. Wu, Catal. Sci. Technol. 11, 27 (2021)
H.R. Mazandarani, B. Ghafary, S.N. Alam, Opt. Mater. (Amst). 126, 112047 (2022)
I.-C. Yao, T.-Y. Tseng, P. Lin, Sens. Actuators A Phys. 178, 26 (2012)
Z. Karcıoğlu Karakaş, J. Phys. Chem. Solids 170, 110927 (2022)
Y. Deng, R. Zhao, Curr. Pollut. Reports 1, 167 (2015)
T. Lv, J. Li, N. Arif, L. Qi, J. Lu, Z. Ye, Y.-J. Zeng, Matter 5, 2685 (2022)
L. Liu, H. Huang, Chem. A Eur. J. (2022). https://doi.org/10.1002/ejic.202200368
J.L. Capelo-Martı́nez, P. Ximénez-Embún, Y. Madrid, C. Cámara, Trends Anal. Chem. 23, 331 (2004)
C.B. Ong, L.Y. Ng, A.W. Mohammad, Renew. Sustain. Energy Rev. 81, 536 (2018)
D. Alrousan, A. Afkhami, K. Bani-Melhem, P. Dunlop, Water 12, 2811 (2020)
C. Liu, Y. Tian, Y. An, Q. Yang, S. Xiong, J. Feng, Y. Qian, Chem. Eng. J. 430, 132748 (2022)
M. Abd El-Aal, M.R. Saleh, H.M. El-Bery, Sustain. Energy Fuels 6, 3371 (2022)
O. Zakir, A. Ait Karra, R. Idouhli, M. Elyaagoubi, M. Khadiri, B. Dikici, A. Aityoub, A. Abouelfida, A. Outzourhit, J. Solid State Electrochem. 26, 2247 (2022)
P. Dash, A. Manna, N.C. Mishra, S. Varma, Phys. E Low-Dimensional Syst. Nanostruct. 107, 38 (2019)
S. Sakthivel, B. Neppolian, M.V. Shankar, B. Arabindoo, M. Palanichamy, V. Murugesan, Sol. Energy Mater. Sol. Cells 77, 65 (2003)
Y. Lin, H. Hu, Y.H. Hu, Appl. Surf. Sci. 502, 144202 (2020)
S. Aydogan, A. Kocyigit, B.B. Cirak, E. Erdogan, M. Yilmaz, J. Mater. Sci. Mater. Electron. 33, 6059 (2022)
B. Bozkurt Çırak, B. Caglar, T. Kılınç, S. Morkoç Karadeniz, Y. Erdoğan, S. Kılıç, E. Kahveci, A. Ercan Ekinci, Ç. Çırak, Mater. Res. Bull. 109, 160 (2019)
U. Alver, T. Kılınç, E. Bacaksız, S. Nezir, Mater. Chem. Phys. 106, 227 (2007)
U. Alver, T. Kılınç, E. Bacaksız, T. Küçükömeroğlu, S. Nezir, İH. Mutlu, F. Aslan, Thin Solid Films 515, 3448 (2007)
S. Güner, O. Gürbüz, S. Çalışkan, V.I. Nuzhdin, R. Khaibullin, M. Öztürk, N. Akdoğan, Appl. Surf. Sci. 310, 235 (2014)
E. Karaköse, H. Çolak, Energy 140, 92 (2017)
A. Tursucu, S. Aydogan, A. Kocyigit, A. Ozmen, M. Yilmaz, JOM 74, 777 (2022)
R. Saravanan, E. Thirumal, V.K. Gupta, V. Narayanan, A. Stephen, J. Mol. Liq. 177, 394 (2013)
R. Torkamani, B. Aslibeiki, H. Naghshara, M. Darbandi, Opt. Mater. (Amst). 127, 112295 (2022)
K. Ocakoglu, S.A. Mansour, S. Yildirimcan, A.A. Al-Ghamdi, F. El-Tantawy, F. Yakuphanoglu, Spectrochim Acta Part A Mol. Biomol. Spectrosc. 148, 362 (2015)
V. Mote, Y. Purushotham, B. Dole, J. Theor. Appl. Phys. 6, 6 (2012)
K. PradeevRaj, K. Sadaiyandi, A. Kennedy, R. Thamizselvi, Mater. Chem. Phys. 183, 24 (2016)
M.S. Roslan, Z. Haider, K.T. Chaudhary, Mater. Today Commun. 25, 101285 (2020)
E. Ozugurlu, J. Alloys Compd. 861, 158620 (2021)
P. Bindu, S. Thomas, J. Theor. Appl. Phys. 8, 123 (2014)
J. Sun, J. Bian, L. Chen, Y. Wang, Y. Gong, Y. Li, K. Liu, C. Chang, M. Li, G. Du, Appl. Surf. Sci. 276, 782 (2013)
Z. Yao, K. Tang, Z. Xu, J. Ma, S. Gu, Opt. Mater. Express 9, 652 (2019)
H. Ghayour, A.A. Nourbakhsh, S. Mirdamadi, H.R. Rezaei, J. Nanosci. Nanotechnol. 10, 7455 (2010)
S. Hosseini, L. Dejam, H. Elahi, Opt. Quantum Electron. 54, 183 (2022)
N. Baydogan, O. Karacasu, H. Cimenoglu, J. Sol-Gel Sci. Technol. 61, 620 (2012)
S. Sharma, C. Periasamy, Superlattices Microstruct. 73, 12 (2014)
Y. Caglar, F. Yakuphanoglu, S. Ilican, M. Caglar, J. Optoelectron. Adv. Mater. 10, 2584 (2008)
A. Özmen, S. Aydogan, M. Yilmaz, Ceram. Int. 45, 14794 (2019)
M. Yilmaz, Y. Demir, S. Aydogan, M.L. Grilli, Energies 14, 7983 (2021)
K. Liu, M. Sakurai, M. Aono, Sensors 10, 8604 (2010)
A. Karabulut, D.E. Yıldız, D.A. Köse, M. Yıldırım, Mater. Sci. Semicond. Process. 146, 106647 (2022)
A. Kocyigit, M. Yıldırım, D.A. Kose, D.E. Yıldız, Polym. Bull. 79, 11389–11408 (2022). https://doi.org/10.1007/s00289-021-04021-0
H.H. Gullu, D.E. Yildiz, A. Kocyigit, M. Yıldırım, J. Alloys Compd. 827, 154279 (2020)
M. Benhaliliba, Superlattices Microstruct. 163, 107140 (2021). https://doi.org/10.1016/j.spmi.2021.107140
S.O. Tan, H. Uslu Tecimer, O. Çiçek, H. Tecimer, İ Orak, Ş Altındal, J. Mater. Sci. Mater. Electron. 27, 8340 (2016)
K. Karthick, P. Kathirvel, R. Marnadu, S. Chakravarty, M. Shkir, Phys. B Condens. Matter 612, 412971 (2021)
A. Dere, M. Soylu, F. Yakuphanoglu, Mater. Sci. Semicond. Process. 90, 129 (2019)
R.O. Ocaya, F. Yakuphanoğlu, Measurement 186, 110105 (2021)
S. Oussalah, W. Filali, E. Garoudja, B. Zatout, F. Lekoui, R. Amrani, N. Sengouga, M. Henini, Microelectronics J. 122, 105409 (2022)
M. Bashahu, D. Ngendabanyikwa, P. Nyandwi, J. Mod. Phys. 13, 285 (2022)
S.K. Cheung, N.W. Cheung, Appl. Phys. Lett. 49, 85 (1986)
M.O. Erdal, A. Kocyigit, M. Yıldırım, Mater. Sci. Semicond. Process. 103, 104620 (2019)
H.C. Card, E.H. Rhoderick, J. Phys. D. Appl. Phys. 4, 319 (1971)
E. Erdogan, M. Yilmaz, S. Aydogan, U. Incekara, Y. Sahin, Opt. Mater. (Amst). 121, 111613 (2021)
A. Mekki, A. Dere, K. Mensah-Darkwa, A. Al-Ghamdi, R.K. Gupta, K. Harrabi, W.A. Farooq, F. El-Tantawy, F. Yakuphanoglu, Synth. Met. 217, 43 (2016)
S. Ruzgar, M. Caglar, Mater. Sci. Semicond. Process. 115, 105076 (2020)
H. Kacus, M. Yilmaz, U. Incekara, A. Kocyigit, S. Aydogan, Sens. Actuators A Phys. 330, 112856 (2021)
R. Singh, S. Dutta, Nano-Struct. Nano-Objects 18, 100250 (2019)
R. Singh, S. Dutta, Fuel 220, 607 (2018)
T.V. Arsha Kusumam, T. Panakkal, T. Divya, M.P. Nikhila, M. Anju, K. Anas, N.K. Renuka, Ceram. Int. 42, 3769 (2016)
L. Sun, T. An, S. Wan, G. Li, N. Bao, X. Hu, J. Fu, G. Sheng, Sep. Purif. Technol. 68, 83 (2009)
X. Li, J. Wang, J. Yang, J. Lang, S. Lü, M. Wei, X. Meng, C. Kou, X. Li, J. Alloys Compd. 580, 205 (2013)
H. Liu, J. Yang, J. Liang, Y. Huang, C. Tang, J. Am. Ceram. Soc. 91, 1287 (2008)
N. Kumaresan, M.M.A. Sinthiya, M. Praveen Kumar, S. Ravichandran, R. Ramesh Babu, K. Sethurman, K. Ramamurthi, Arab. J. Chem. 13, 2826 (2020)
M. Ahmad, M.T. Qureshi, W. Rehman, N.H. Alotaibi, A. Gul, R.S. Abdel Hameed, M. Al Elaimi, M.F.H. Abd el-kader, M. Nawaz, R. Ullah, J. Alloys Compd. 895, 162636 (2022)
M. Sohaib, T. Iqbal, S. Afsheen, M.B. Tahir, A. Masood, M. Rafique, K.N. Riaz, M.A. Sayed, A.F. AbdEl-Rehim, A.M. Ali, Environ. Dev. Sustain. (2022). https://doi.org/10.1007/s10668-022-02543-9
T.T. Truong, T.T. Pham, T.T.T. Truong, T.D. Pham, Environ. Sci. Pollut. Res. 29, 22576 (2022)
X. Hou, Mater. Lett. 139, 201 (2015)
K. Tanji, M. Zouheir, M. Hachhach, H. Ahmoum, I. Jellal, H. El Masaoudi, Y. Naciri, T.-P. Huynh, K. Nouneh, M. Benaissa, J. Naja, A. Kherbeche, React. Kinet. Mech. Catal. 134, 1017 (2021)
J. Fan, T. Li, H. Heng, Bull. Mater. Sci. 39, 19 (2016)
M.A. El-Aal, H.M. Ali, S.M. Ibrahim, ACS Omega 7, 26777 (2022)
H.M. Ali, S.M. Ibrahim, E.F. Abo Zeid, A.F. Al-Hossainy, M.A. El-Aal, RSC Adv. 12, 16496 (2022)
I. H. Karakaş and Z. Karcioğlu Karakaş, Color. Technol. (2022). https://doi.org/10.1111/cote.12647
B. Caglar, E.K. Guner, S. Ersoy, S. Caglar, A.O. Özdemir, K.V. Özdokur, B. Doğan, F. İçer, Ç. Çırak, J. Alloys Compd. 885, 160964 (2021)
L. Wang, X. Fu, Y. Han, E. Chang, H. Wu, H. Wang, K. Li, X. Qi, J. Nanomater. 2013, 1 (2013)
F.-X. Xiao, S.-F. Hung, H.B. Tao, J. Miao, H. Bin Yang, B. Liu, Nanoscale 6, 14950 (2014)
Acknowledgements
The authors would like to thank Fatma Yıldırım and Zeynep Orhan for their technical assistance in this study.
Author information
Authors and Affiliations
Corresponding authors
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
Springer Nature or its licensor (e.g. a society or other partner) holds exclusive rights to this article under a publishing agreement with the author(s) or other rightsholder(s); author self-archiving of the accepted manuscript version of this article is solely governed by the terms of such publishing agreement and applicable law.
About this article
Cite this article
Yilmaz, M., Cirak, C., Canpolat, N. et al. ZnO micro/nanorods: their performance in the photocatalytic degradation and photodiode. Appl. Phys. A 129, 224 (2023). https://doi.org/10.1007/s00339-023-06514-3
Received:
Accepted:
Published:
DOI: https://doi.org/10.1007/s00339-023-06514-3