Abstract
Undoped (ZnO) and Al-doped ZnO (AZO) aerogels were synthesized in different supercritical alcohols (acetone, ethanol and isopropanol). The effects of supercritical solvent on structural, morphological and optical properties of ZnO and AZO aerogels were studied. XRD patterns reveal that the aerogels were polycrystalline and monophasic, indicating that Al3+ ions have been successfully incorporated into ZnO lattice. SEM images show that morphology and size of the grains are dependent on supercritical drying conditions. FTIR results indicate that the intensity and the position of Zn–O vibration band are dependent on doping atoms and supercritical solvent. The UV–visible studies put into evidence that the optical band gap decreases after Al doping and the absorption intensity is affected by the drying conditions. TGA measurements indicate that Al-doped ZnO aerogels are chemically pure and their thermal behavior is independent on the used supercritical organic alcohol. Room temperature PL studies reveal that the supercritical solvent properties affect considerably the defect concentrations during the elaboration process. Al doping leads to the diminution of the overall PL intensity of ZnO nanostructures elaborated in acetone and ethanol, whereas, the opposite behavior is obtained when isopropanol is used. These results could be of great interest for optical applications.
Similar content being viewed by others
References
T. Zhai, X. Fang, M. Liao, X. Xu, H. Zeng, B. Yoshio, D. Golberg, A comprehensive review of one-dimensional metal-oxide nanostructure photodetectors. Sensors 9, 6504–6529 (2009)
D.C. Look, B. Claflin, YaI Alivov, S.J. Park, The future of ZnO light emitters. Phys. Stat. Sol. (a) 201(10), 2203–2212 (2004)
K.M. Lee, C.W. Lai, K.S. Ngai, J.C. Juan, Recent developments of zinc oxide based photocatalyst in water treatment technology: a review. Water Res. 88, 428–448 (2016)
T.K. Gupta, Applications of zinc oxide varistors. J. Am. Ceram. Soc. 73(7), 1817–1840 (1990)
M.C. Carotta, A. Cervi, V. di Natale, S. Gherardi, A. Giberti, V. Guidi, D. Puzzovio, B. Vendemiati, G. Martinelli, M. Sacerdoti, D. Calestani, A. Zappettini, M. Zha, L. Zanotti, ZnO gas sensors: a comparison between nanoparticles and nanotetrapods-based thick films. Sens. Actuat. B Chem. 137, 164–169 (2009)
O. Lupan, S. Shishiyanu, V. Ursaki, H. Khallaf, L. Chow, T. Shishiyanu, V. Sontea, E. Monaico, S. Railean, Synthesis of nanostructured Al-doped zinc oxide films on Si for solar cells applications. Sol. Energy Mater. Sol. Cells 93, 1417–1422 (2009)
J. Jiang, J. Pi, J. Cai, The advancing of zinc oxide nanoparticles for biomedical applications. Bioinorg. Chem. Appl. 2018, 1–18 (2018)
P.K. Mishra, H. Mishra, A. Ekielski, S. Talegaonkar, B. Vaidya, Zinc oxide nanoparticles: a promising nanomaterial for biomedical applications. Drug Discov. Today 22, 1825–1834 (2017)
X. Chong, L. Li, X. Yan, D. Hu, H. Li, Y. Wan, Synthesis, characterization and room temperature photoluminescence properties of Al doped ZnO nanorods. Physica E 44, 1399–1405 (2012)
G. Kaurn, A. Mitra, K.L. Yadav, Pulsed laser deposited Al-doped ZnO thin films for optical applications. Prog. Nat. Sci. Mater. 25, 12–21 (2015)
G. Srinet, R. Kumarn, V. Sajal, Effects of aluminum doping on structural and photoluminescence properties of ZnO nanoparticles. Ceram. Int. 40, 4025–4031 (2014)
P. Díaz-Chao, F. Giovannelli, O. Lebedev, D. Chateigner, L. Lutterotti, F. Delorme, E. Guilmeau, Textured Al-doped ZnO ceramics with isotropic grains. J. Eur. Ceram. Soc. 34, 4247–4256 (2014)
N.L. Hadipour, A.A. Peyghan, H. Soleymanabadi, Theoretical study on the Al-doped ZnO nanoclusters for CO chemical sensors. J. Phys. Chem. C 119, 6398–6404 (2015)
K. Hagedorn, W. Li, Q. Liang, S. Dilger, M. Noebels, M.R. Wagner, J.S. Reparaz, A. Dollinger, J. Schmedt auf der Günne, T. Dekorsy, L. Schmidt-Mende, S. Polarz, Catalytically doped semiconductors for chemical gas sensing: aerogel-like aluminum-containing zinc oxide materials prepared in the gas phase. Adv. Funct. Mater. 26, 3424–3437 (2016)
X. Sun, W. Luo, L. Chen, L. Zheng, C. Bao, P. Sun, N. Huang, Y. Sun, L. Fang, L. Wang, Synthesis of porous Al doped ZnO nanosheets with high adsorption and photodecolorizative activity and the key role of Al doping for methyl orange removal. RSC Adv. 6, 2241–2251 (2016)
Z.L. Wang, Zinc oxide nanostructures: growth, properties and applications. J. Phys. Condens. Matter 16, R829–R858 (2004)
Z. Ait Abdelouhab, D. Djouadi, A. Chelouche, L. Hammiche, T. Touam, Effects of precursors and caustic bases on structural and vibrational properties of ZnO nanostructures elaborated by hydrothermal method. Solid State Sci. 89, 93–99 (2019)
L. Xu, Y.-L. Hu, C. Pelligra, C.-H. Chen, L. Jin, H. Huang, S. Sithambaram, M. Aindow, R. Joesten, S.L. Suib, ZnO with different morphologies synthesized by solvothermal methods for enhanced photocatalytic activity. Chem. Mater. 21, 2875–2885 (2009)
A. Khorsand Zak, M. Ebrahimizadeh Abrishami, WHAbd Majid, R. Yousefi, S.M. Hosseini, Effects of annealing temperature on some structural and optical properties of ZnO nanoparticles prepared by a modified sol–gel combustion method. Ceram. Int. 37, 393–398 (2011)
D. Djouadi, M. Meddouri, A. Chelouche, Structural and optical characterizations of ZnO aerogel nanopowder synthesized from zinc acetate ethanolic solution. Opt. Mater. 37, 567–571 (2014)
K. Byrappa, S. Ohara, T. Adschiri, Nanoparticles synthesis using supercritical fluids technology-towards biomedical applications. Adv. Drug Deliv. Rev. 60, 299–327 (2008)
R.S. Oakes, A.A. Clifford, C.M. Rayner, The use of supercritical fluids in synthetic organic chemistry. J. Chem. Soc. Perkin Trans. 1, 917–941 (2001)
C. Aymonier, A. Loppinet-Serani, H. Reveron, Y. Garrabos, F. Cansell, Review of supercritical fluids in inorganic materials science. J. Supercrit. Fluids 38, 242–251 (2006)
T. Adschiri, A. Yoko, Supercritical fluids for nanotechnology. J. Supercrit. Fluids 134, 167–175 (2018)
R. Campardelli, L. Baldino, E. Reverchon, Supercritical fluids applications in nanomedicine. J. Supercrit. Fluids 101, 193–214 (2015)
O. Slimi, D. Djouadi, L. Hammiche, A. Chelouche, T. Touam, Structural and optical properties of Cu-doped ZnO aerogels synthesized in supercritical ethanol. J. Porous Mater. 25, 595–601 (2018)
M. Meddouri, D. Djouadi, A. Chelouche, T. Touam, A. Chergui, Effect of co-solvent on structural and morphological properties of ZnO aerogel prepared by a modified sol–gel process. Eur. Phys. J. Appl. Phys. 66, 10402–10406 (2014)
F. Ren, R. Xin, X. Ge, Y. Leng, Characterization and structural analysis of zinc substituted hydroxyapatites. Acta Biomater. 5(8), 3141–3149 (2009)
J. Becker, K.R. Raghupathi, J.S. Pierre, D. Zhao, R.T. Koodali, Tuning of the crystallite and particle sizes of ZnO nanocrystalline materials in solvothermal synthesis and their photocatalytic activity for dye degradation. J. Phys. Chem. C 115, 13844–13850 (2011)
C.H. Zhai, R.J. Zhang, X. Chen, Y.X. Zheng, S.Y. Wang, J. Liu, N. Dai, L.Y. Chen, Effects of Al doping on the properties of ZnO thin films deposited by atomic layer deposition. Nanoscale Res. Lett. 11, 407–408 (2016)
S. Salam, M. Islam, A. Akram, Sol–gel synthesis of intrinsic and aluminum-doped zinc oxide thin films as transparent conducting oxides for thin film solar cells. Thin Solid Films 529, 242–247 (2013)
M.K. Song, M.Y. Lee, J.H. Seo, M.H. Kim, S.Y. Yang, Synthesis of high crystalline Al-doped ZnO nanopowders from Al2O3 and ZnO by radio-frequency thermal plasma. J. Nanomater. 2015, 151532–151536 (2015)
M. Nafees, W. Liaqut, S. Ali, M.A. Shafique, Synthesis of ZnO/Al: ZnO nanomaterial: structural and band gap variation in ZnO nanomaterial by Al doping. Appl. Nanosci. 3, 49–55 (2013)
K. Spyrou, G. Potsi, E.K. Diamanti, X. Ke, E. Serestatidou, I.I. Verginadis, A.P. Velalopoulou, A.M. Evangelou, Y. Deligiannakis, G. Van Tendeloo, Towards novel multifunctional pillared nanostructures: effective intercalation of adamantylamine in graphene oxide and smectite clays. Adv. Funct. Mater. 24, 5841–5850 (2014)
V. Ischenko, S. Polarz, D. Grote, V. Stavarache, K. Fink, M. Driess, Zinc oxide nanoparticles defects. Adv. Funct. Mater. 15(12), 1945–1954 (2003)
M.J. Robles-Águila, J.A. Luna-López, Á.D. Hernández de la Luz, J. Martínez-Juárez, M.E. Rlabana, Synthesis and characterization of nanocrystalline ZnO doped with Al3+ and Ni2+ by a sol–gel method coupled with ultrasound irradiation. Crystals 8, 406–410 (2018)
B.A. Anandh, A. Shankar Ganesh, R. Thangarasu, R. Sakthivel, R. Kannusamy, K. Tamilselvan, Structural, morphological and optical properties of aluminium doped ZnO thin film by dip-coating method. Orient. J. Chem. 34(3), 1619–1624 (2018)
C.H. Xia, C.G. Hu, C.H. Hu, Z. Ping, F. Wang, Room-temperature ferromagnetic properties of Cu-doped ZnO rod arrays. Bull. Mater. Sci. 34, 1083–1087 (2011)
S. Chattopadhyay, S.K. Neogi, P. Pandit, S. Dutta, T. Rakshit, D. Jana, S. Chattopadhyay, A. Sarkar, S.K. Ray, Disorder driven optical processes in nanocrystalline ZnO. J. Lumin. 132, 6–11 (2012)
H.Y. He, Q. Liang, Enhancement in the optical transmittance of ZnO:Al powders by Mo co-doping. Curr. Appl. Phys. 12, 865–869 (2012)
H.-Y. He, J.-F. Huang, Z. He, J. Lu, Q. Shen, Microstructural and optical properties of transparent conductive ZnO:Al:Mo films deposited by template-assisted sol–gel method. Bull. Mater. Sci. 37, 1–7 (2014)
S.B. Zhang, S.H. Wei, A. Zunger, Intrinsic n-type versus p-type doping asymmetry and the defect physics of ZnO. Phys. Rev. B 63, 075205–75207 (2001)
T.M.K. Thandavan, S.M.A. Gani, C.S. Wong, M.R. Nor, Enhanced photoluminescence and Raman properties of Al-doped ZnO nanostructures prepared using thermal chemical vapor deposition of methanol assisted with heated brass. PLoS O ne 10, e0121756–e121818 (2015)
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Conflict of interest
On behalf of all the authors, the corresponding author states that there is no conflict of interest.
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Mouzaia, F., Djouadi, D., Chelouche, A. et al. Structural and optical investigations of pure and Al-doped ZnO nano-aerogels: effects of supercritical organic solvent. Appl. Phys. A 125, 637 (2019). https://doi.org/10.1007/s00339-019-2929-6
Received:
Accepted:
Published:
DOI: https://doi.org/10.1007/s00339-019-2929-6