Abstract
The aim of the presented study was an analysis of two apatite coatings: hydroxyapatite (HA) and octacalcium phosphate (OCP) as coatings materials for metallic implants. Both layers were deposited by means of the PLD method. As a target material, synthetic, powdered and pressed hydroxyapatite was used. HA was deposited on 316L steel substrate in two temperature ranges for obtaining different coatings: 150±30°C and 430±30°C for OCP and HA, respectively. As an intermediate layer, the nanocrystalline diamond layer (NCD) was deposited. Examined calcium phosphate layers were tested for adhesion of osteoblast cell culture (MG-63). Analytical methods (AFM, FTIR) showed the usefulness of the PLD method for deposition of the apatite layers on metallic implants. Both examined layers showed biocompatibility with human osteoblast cells and presented favorable conditions for their proliferation.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
W.E. Brown, N. Eidelman, B. Tomazic, Adv. Dent. Res. 1(2), 306 (1987)
P. Bodier-Houllé, P. Steuer, J.C. Voegel, Acta Crystallogr. D, Biol. Crystallogr. 54, 1377 (1998)
R.Z. Le Geros, J. Dent. Res. 53(1), 45 (1974)
M.S. Tung, W.E. Brown, Calcif. Tissue Int. 37(3), 329 (1985)
J. Zhang, G.H. Nancollas, J. Phys. Chem. 96, 5478 (1992)
A. Bigi, E. Boanini, G. Cojazzi, Cryst. Growth Des. 1, 239 (2001)
M.J. Arellano-Jimenez, R. Garcia-Garcıa, J. Reyes-Gasga, J. Phys. Chem. Solids 70, 390 (2009)
G. Socol, P. Torricelli, B. Bracci, Biomaterials 25, 2539 (2004)
I.N. Mihailescu, P. Torricelli, A. Bigi, Appl. Surf. Sci. 248, 344 (2005)
W. Jakubowski, G. Bartosz, P. Niedzielski, Diam. Relat. Mater. 13, 1761 (2004)
S. Mitura, K. Mitura, P. Niedzielski, J. Achiev. Mater. Manuf. Eng. 16, 9 (2006)
W. Okrój, M. Kamińska, L. Klimek, Diam. Relat. Mater. 15, 1535 (2006)
X. Xiao, J. Wang, C. Liu, J. Biomed. Mater. Res. B, Appl. Biomater. 77B, 273 (2006)
L. Tang, C. Tsai, W.W. Gerberich, Biomaterials 16, 483 (1995)
D. Steinmueller-Nethl, F.R. Kloss, M.N.U. Haq, Biomaterials 27, 4547 (2006)
S. Wenmackers, P. Christiaens, M. Daenen, Phys. Status Solidi 202, 2212 (2005)
J.R. Retama, J. Hernando, B. Lopez-Ruiz, Langmuir 22, 5837 (2006)
P.S. Siew, K.P. Loh, W.C. Poh, Diam. Relat. Mater. 14, 426 (2005)
A. Mitura, E. Mitura, A. Mitura, Diam. Relat. Mater. 4, 302 (1995)
B. Płytycz, M. Chadzińska, Hodowla tkanek w immunologii, Wydawnictwo Naukowe (2004). (In Polish)
R.J. Gillies, N. Didier, M. Denton, Anal. Biochem. 159, 1 (1986)
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
Open Access This is an open access article distributed under the terms of the Creative Commons Attribution Noncommercial License (https://creativecommons.org/licenses/by-nc/2.0), which permits any noncommercial use, distribution, and reproduction in any medium, provided the original author(s) and source are credited.
About this article
Cite this article
Mróz, W., Bombalska, A., Budner, B. et al. Comparative study of hydroxyapatite and octacalcium phosphate coatings deposited on metallic implants by PLD method. Appl. Phys. A 101, 713–716 (2010). https://doi.org/10.1007/s00339-010-5926-3
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00339-010-5926-3