Abstract
Higher alcohols are the byproducts of yeasts in alcohol fermentation and are harmful to human health at high concentrations. In this study, immobilized crude enzymes extracted from Geotrichum spp. strains S12 and S13 were separately employed to treat red wine, then GC and GC-MS analyses were used to determine the profiles of volatile compounds in untreated and treated wine samples. Immobilized enzymes from S13 (SA-S13E) were more active in decreasing higher alcohols than enzymes from S12. Conditions for preparing SA-S13E were optimized, and best results were obtained at a sodium alginate concentration of 35 g/L, calcium chloride of 20 g/L, and crude enzyme dosage of 3 mL. Treatment with SA-S13E significantly increased the ester content and sensory quality of wine. After being reused three times, SA-S13E still exhibited approximately 80% activity towards 1-propanol, isobutanol, and hexanol and had certain activity even after 3 months storage at −20 °C, indicating high stability in application and storage and thus showing potential in wine processing.
Similar content being viewed by others
References
Agouridis N, Kopsahelis N, Plessas S, Koutinas AA, Kanellaki M (2008) Oenococcus oeni cells immobilized on delignified cellulosic material for malolactic fermentation of wine. Bioresour Technol 99:9017–9020. doi:10.1016/j.biortech.2008.04.026
Ancín C, Ayestarán B, Corroza M, Garrido J, González A (1996) Influence of prefermentation clarification on the higher alcohol contents of wines. Food Chem 55:241–249. doi:10.1016/0308-8146(95)00125-5
Aranaz I, Acosta N, Férnandez-Valle ME, Heras A (2015) Optimization of D-amino acid production catalyzed by immobilized multi-enzyme system in polyelectrolyte complex gel capsules. J Mol Catal B-Enzym 121:45–52. doi:10.1016/j.molcatb.2015.06.003
Armada L, Fernández E, Falqué E (2010) Influence of several enzymatic treatments on aromatic composition of white wines. LWT - Food Sci Technol 43:1517–1525. doi:10.1016/j.lwt.2010.06.009
Atacan K, Cakiroglu B, Ozacar M (2016) Improvement of the stability and activity of immobilized trypsin on modified Fe3O4 magnetic nanoparticles for hydrolysis of bovine serum albumin and its application in the bovine milk. Food Chem 212:460–468. doi:10.1016/j.foodchem.2016.06.011
Bindon K, Varela C, Kennedy J, Holt H, Herderich M (2013) Relationships between harvest time and wine composition in Vitis vinifera L. cv. Cabernet Sauvignon 1. Grape and wine chemistry. Food Chem 138:1696–1705. doi:10.1016/j.foodchem.2012.09.146
Carrau FM, Medina K, Farina L, Boido E, Henschke PA, Dellacassa E (2008) Production of fermentation aroma compounds by Saccharomyces cerevisiae wine yeasts: effects of yeast assimilable nitrogen on two model strains. FEMS Yeast Res 8:1196–1207. doi:10.1111/j.1567-1364.2008.00412.x
Chan ES, Lee BB, Ravindra P, Poncelet D (2009) Prediction models for shape and size of ca-alginate macrobeads produced through extrusion-dripping method. J Colloid Interf Sci 338:63–72. doi:10.1016/j.jcis.2009.05.027
Chang AC (2003) The effects of gamma irradiation on rice wine maturation. Food Chem 83:323–327. doi:10.1016/S0308-8146(03)00050-5
Estévez P, Gil ML, Falqué E (2004) Effects of seven yeast strains on the volatile composition of Palomino wines. Int J Food Sci Tech 39:61–69. doi:10.1046/j.0950-5423.2003.00755.x
Fan W, Qian MC (2006) Identification of aroma compounds in Chinese ‘Yanghe Daqu’ liquor by normal phase chromatography fractionation followed by gas chromatography [sol] olfactometry. Flavour Frag J 21:333–342. doi:10.1002/ffj.1621
Gueguen Y, Chemardin P, Janbon G, Arnaud A, Galzy P (1996) A very efficient β-glucosidase catalyst for the hydrolysis of flavor precusors of wines and fruit juices. J Agr Food Chem 44:2336–2340. doi:10.1021/jf950360j
Han QA, Shi JL, Zhu J, Lv HL, Du SK (2014) Enzymes extracted from apple peels have activity in reducing higher alcohols in Chinese liquors. J Agr Food Chem 62:9529–9538. doi:10.1021/jf5018862
Hazelwood LA, Daran JM, van Maris AJA, Pronk JT, Dickinson JR (2008) The Ehrlich pathway for fusel alcohol production: a century of research on Saccharomyces cerevisiae metabolism. Appl Environ Microbiol 74:2259–2266. doi:10.1128/AEM.02625-07
Hevia K, Castro R, Natera R, González-García JA, Barroso CG, Durán-Guerrero E (2016) Optimization of head space sorptive extraction to determine volatile compounds from oak wood in fortified wines. Chromatographia 79:763–771. doi:10.1007/s10337-016-3088-y
Klosowski G, Mikulski D, Czuprynski B, Kotarska K (2010) Characterisation of fermentation of high-gravity maize mashes with the application of pullulanase, proteolytic enzymes and enzymes degrading non-starch polysaccharides. J Biosci Bioeng 109:466–471. doi:10.1016/j.jbiosc.2009.10.024
Kodama Y, Omura F, Miyajima K, Ashikari T (2001) Control of higher alcohol production by manipulation of the BAP2 gene in brewing yeast. J Am Soc Brew Chem 59:157–162
Komes D, Ulrich D, Ganic KK, Lovric T (2007) Study of phenolic and volatile composition of white wine during fermentation and a short time of storage. Vitis 46:77–84
Kourkoutas Y, Bekatorou A, Banat IM, Marchant R, Koutinas AA (2004) Immobilization technologies and support materials suitable in alcohol beverages production: a review. Food Microbiol 21:377–397. doi:10.1016/j.fm.2003.10.005
Lee BB, Ravindra P, Chan ES (2013) Size and shape of calcium alginate beads produced by extrusion dripping. Chem Eng Technol 36:1627–1642. doi:10.1002/ceat.201300230
Lessard MH, Viel C, Boyle B, St-Gelais D, Labrie S (2014) Metatranscriptome analysis of fungal strains Penicillium camemberti and Geotrichum candidum reveal cheese matrix breakdown and potential development of sensory properties of ripened Camembert-type cheese. BMC Genomics 15:235. doi:10.1186/1471-2164-15-235
Mallouchos A, Konaitis M, Koutinas A, Kanellaki M (2003) Wine fermentations by immobilized and free cells at different temperatures. Effect of immobilization and temperature on volatile by-products. Food Chem 80:109–113. doi:10.1016/S0308-8146 (02)00247-9
Mateo C, Palomo JM, Fernandez-Lorente G, Guisan JM, Fernandez-Lafuente R (2007) Improvement of enzyme activity, stability and selectivity via immobilization techniques. Enzym Microb Technol 40:1451–1463. doi:10.1016/j.enzmictec.2007.01.018
Mdaini N, Gargouri M, Hammami M, Monser L, Hamdi M (2006) Production of natural fruity aroma by Geotrichum candidum. Appl Biochem Biotech 128:227–235. doi:10.1385/ABAB:128:3:227
Molina AM, Swiegers JH, Varela C, Pretorius IS, Agosin E (2007) Influence of wine fermentation temperature on the synthesis of yeast-derived volatile aroma compounds. Appl Microbiol Biotechnol 77:675–687. doi:10.1007/s00253-007-1194-3
Procopio S, Qian F, Becker T (2011) Function and regulation of yeast genes involved in higher alcohol and ester metabolism during beverage fermentation. Eur Food Res Technol 233:721–729. doi:10.1007/s00217-011-1567-9
Rodriguez-Bencomo JJ, Munoz-Gonzalez C, Andujar-Ortiz I, Martin-Alvarez PJ, Moreno-Arribas MV, Pozo-Bayon MA (2011) Assessment of the effect of the non-volatile wine matrix on the volatility of typical wine aroma compounds by headspace solid phase microextraction/gas chromatography analysis. J Sci Food Agr 91:2484–2494. doi:10.1002/jsfa.4494
Rous CV, Snow R, Kunkee RE (1983) Reduction of higher alcohols by fermentation with a leucine-auxotrophic mutant of wine yeast. J Inst Brew 89:274–278. doi:10.1002/j.2050-0416.1983.tb04185.x
Schoffelen S, van Hest JCM (2012) Multi-enzyme systems: bringing enzymes together in vitro. Soft Matter 8:1736–1746. doi:10.1039/C1SM06452E
Servili M, Begliomini AL, Montedoro G, Petruccioli M, Federici F (1992) Utilisation of a yeast pectinase in olive oil extraction and red wine making processes. J Sci Food Agr 58:253–260. doi:10.1002/jsfa.2740580214
Shen N, Wang JJ, Liu CF, Li YX, Li Q (2014) Domesticating brewing yeast for decreasing acetaldehyde production and improving beer flavor stability. Eur Food Res Technol 238:347–355. doi:10.1007/s00217-014-2169-0
Shi SB, Si T, Liu ZH, Zhang HF, Ang EL, Zhao HM (2016) Metabolic engineering of a synergistic pathway for n-butanol production in Saccharomyces cerevisiae. Sci Rep-UK 6:25675. doi:10.1038/srep25675
Shrinivas D, Kumar R, Naik GR (2012) Enhanced production of alkaline thermostable keratinolytic protease from calcium alginate immobilized cells of thermoalkalophilic Bacillus halodurans JB 99 exhibiting dehairing activity. J Ind Microbiol Biotechnol 39:93–98. doi:10.1007/s10295-011-1003-y
Song JQ, Li H, Liang YY, Tao YS, Mi CQ, Qian MC, Wang H (2013) Characterisation of volatile components of red and sparkling wines from a new wine grape cultivar 'Meili' (Vitis vinifera L.) Vitis 52:41–48
Stribny J, Gamero A, Pérez-Torrado R, Querol A (2015) Saccharomyces kudriavzevii and Saccharomyces uvarum differ from Saccharomyces cerevisiae during the production of aroma-active higher alcohols and acetate esters using their amino acidic precursors. Int J Food Microbiol 205:41–46. doi:10.1016/j.ijfoodmicro.2015.04.003
Vidal EE, de Billerbeck GM, Simoes DA, Schuler A, Francois JM, de Morais MA (2013) Influence of nitrogen supply on the production of higher alcohols/esters and expression of flavour-related genes in cachaca fermentation. Food Chem 138:701–708. doi:10.1016/j.foodchem.2012.10.147
Vilanova M, Siebert TE, Varela C, Pretorius IS, Henschke PA (2012) Effect of ammonium nitrogen supplementation of grape juice on wine volatiles and non-volatiles composition of the aromatic grape variety Albariño. Food Chem 133:124–131. doi:10.1016/j.foodchem.2011.12.082
Xu R, Si YF, Wu XT, Li FT, Zhang BR (2014) Triclosan removal by laccase immobilized on mesoporous nanofibers: strong adsorption and efficient degradation. Chem Eng J 255:63–70. doi:10.1016/j.cej.2014.06.060
Zhang CY, Qi YN, Ma HX, Li W, Dai LH, Xiao DG (2015) Decreased production of higher alcohols by Saccharomyces cerevisiae for Chinese rice wine fermentation by deletion of bat aminotransferases. J Ind Microbiol Biot 42:617–625. doi:10.1007/s10295-015-1583-z
Zhang J, Shi J, Lv H, Liu Y (2013) Induction of hexanol dehydrogenase in Geotrichum spp. by the addition of hexanol. Appl Microbiol Biotechnol 97:1279–1287. doi:10.1007/s00253-012-4280-0
Zhen D, Lv M, Chen MB, Luo JJ, Liu DQ (2014) Effects of a mutated yeast plus addition of sucrose and nitrogen on the total higher alcohol levels of a plum wine fermentation. J Inst Brew 120:571–574. doi:10.1002/jib.163
Zhu J, Lu K, Xu X, Wang X, Shi J (2017) Purification and characterization of a novel glutamate dehydrogenase from Geotrichum candidum with higher alcohol and amino acid activity. AMB Express 7:9. doi:10.1186/s13568-016-0307-8
Zhu J, Shi JL, Lu Y, Liu LP, Liu YL (2016) Application of strains of Geotrichum spp. to decrease higher alcohols and to increase esters. J Inst Brew 122:147–155. doi:10.1002/jib.287
Acknowledgements
This study was supported by the National Key Technology R&D Program (No. 2015BAD16B02); the Agriculture Department of China (Grant No. CARS-30); the Fundamental Research Funds for the Central Universities (3102016QD089); the Fundamental Research Funds for the Central Universities (3102016QD075); the Provincial Scientific Project of Henan (Grant No. 152102210221); and the Scientific Project of Xinyang (Grant No. 150018).
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Conflict of interest
The authors declare that they have no conflict of interest.
Ethical statement
This article does not contain any studies with human participants or animals performed by any of the authors.
Electronic supplementary material
ESM 1
(PDF 260 kb)
Rights and permissions
About this article
Cite this article
Lu, Y., Zhu, J., Shi, J. et al. Immobilized enzymes from Geotrichum spp. improve wine quality. Appl Microbiol Biotechnol 101, 6637–6649 (2017). https://doi.org/10.1007/s00253-017-8424-0
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00253-017-8424-0