Skip to main content
SpringerLink
Log in

Drying characteristics of zucchini slices under periodic infrared-microwave vacuum conditions

  • Original
  • Published:
Heat and Mass Transfer Aims and scope Submit manuscript

Abstract

The purpose of the presented study was to describe the effects of various drying conditions on the drying behavior of zucchini slices as well as specifications of diffusivity, activation energy, shrinkage, and color. Zucchini samples, as the richest fount of macronutrient and micronutrient, were subjected to periodic microwave vacuum drying (at 450 W) at three levels of temperature (40, 50 and 60 °C), absolute pressure (20, 40 and 60 kPa) and exposure time (20–3, 30–4.5 and 40–6 s-min). An increase in the drying temperature and exposure time along with a decrease in absolute pressure caused a reduction in total drying time, however, greater heat damages and adversely texture and color effects were observed in this case. The effective moisture diffusivity of zucchini varied between 5.41×10−10 and 1.75×10−9, indicating that under circumstances of high temperature, long exposure time and low absolute pressure water was able to rapidly diffuse out of the tissue in the experimental domain. Lowering the absolute pressure of vacuum flask and increasing the exposure time led to the reduction in the activation energy of samples. The shrinkage coefficient was within the range of 79.91 to 84.92%. As such, the greatest total color difference was calculated between the color of raw and dried samples for those experiments with the largest increase in temperature, exposure time and a decrease in absolute pressure.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8
Fig. 9

Similar content being viewed by others

References

  1. Eissa HA, Bareh GF, Ibrahim AA, Moawad RK, Ali HS (2013) The effect of different drying methods on the nutrients and non-nutrients composition of zucchini (green squash) rings. J Appl Sci Res 9(8):5380–5389

    Google Scholar 

  2. De Bruin W, Rossouw W, Korsten L (2016) Comparison of safe alternative dipping treatments to maintain quality of zucchini. J Food Qual 39:109–115

    Article  Google Scholar 

  3. Alaei B, Amiri Chayjan R (2015) Modelling of nectarin drying under near infrared-vacuum conditions. Acta Sci Pol Technol Aliment 14(1):15–27

    Article  Google Scholar 

  4. Sledz M, Nowacka M, Wiktor A, Witrowa-Rajchert D (2013) Selected physico-chemical properties of microwave convective drying herbs. Food Bioprod Process 91(4):421–428

    Article  Google Scholar 

  5. Zhang M, Tang JM, Mujumdar AS (2006) Trends in microwave-related drying of fruits and vegetables. Trends Food Sci Technol 17(10):524–534

    Article  Google Scholar 

  6. Mujumdar AS (2004) Guide to the industrial drying, 2nd edition. Color publication Pvt. Ltd, Mumbai

    Google Scholar 

  7. Alaei B, Amiri Chayjan R (2014) Drying characteristics of pomegranate arils under near infrared-vacuum conditions. J Food Process Preserv 39(5):469–479

    Article  Google Scholar 

  8. Wang Y, Zhang M, Mujumdar AS, Mothibe KJ, Roknul Azam SM (2013) Study of drying uniformity in pulsed spouted microwave–vacuum drying of stem lettuce slices with regard to product quality. Dry Technol 31(1):91–101

    Article  Google Scholar 

  9. Wojdyło A, Figiel A, Lech K, Nowicka P (2014) Effect of convective and vacuum–microwave drying on the bioactive compounds, color, and antioxidant capacity of sour cherries. Food Bioprocess Technol 7(3):829–841

    Article  Google Scholar 

  10. Giri SK, Sutar PP, Prasad S (2014) Effect of process variables on energy efficiency in microwave vacuum drying of button mushroom. Food Res Technol 2(1):31–38

    Google Scholar 

  11. Figiel A (2010) Drying kinetics and quality of beetroots dehydrated by combination of convective and vacuum-microwave methods. J Food Eng 98(4):461–470

    Article  Google Scholar 

  12. Clary CD, Wang SJ, Petrucci VE (2005) Fixed and incremental levels of microwave power application on drying grapes under vacuum. J Food Sci 70(5):344–349

    Article  Google Scholar 

  13. Calin-Sanchez A, Figiel A, Wojdyło A, Szarycz M, Carbonell-Barrachina AA (2014) Drying of garlic slices using convective pre-drying and vacuum-microwave finishing drying: kinetics, energy consumption, and quality studies. Food Bioprocess Technol 7(2):398–408

    Article  Google Scholar 

  14. Pu YY, Sun DW (2015) Vis–NIR hyperspectral imaging in visualizing moisture distribution of mango slices during microwave-vacuum drying. Food Chem 188:271–278

    Article  Google Scholar 

  15. AOAC (2002) Official methods of analysis. Method number 934.06. Assosiation of Official analitical Chemists, Arlington

    Google Scholar 

  16. Figiel A (2009) Drying kinetics and quality of vacuum-microwave dehydrated garlic cloves and slices. J Food Eng 94(1):98–104

    Article  Google Scholar 

  17. Dissa AO, Bathiebo DJ, Desmorieux H, Coulibaly O, Koulidiati J (2011) Experimental characterization and modelling of thin layer direct solar drying of Amelia and Brooks mangoes. Energy 36:2517–2527

    Article  Google Scholar 

  18. Doymaz İ, Özdemir Ö (2014) Effect of air temperature, slice thickness and pretreatment on drying and rehydration of tomato. Food Sci Technol 49(2):558–564

    Article  Google Scholar 

  19. Crank J (1975) The mathematics of diffusion. Clarendon Press, Oxford

    MATH  Google Scholar 

  20. Dissa AO, Desmorieux H, Savadogo PW, Segda BG, Koulidiati J (2010) Shirinkage porosity abd density behaviour during convective drying of spirlulina. J Food Eng 97(3):410–418

    Article  Google Scholar 

  21. Sledz M, Witrovwa-Rajchert D (2012) Influence of microwave-convective drying on chlorophyll content and colour of herbs. Acta Agrophysica 19(4):865–876

    Google Scholar 

  22. Yam KL, Papadakis SE (2004) A simple digital imageing method for meauring and analysing colour of food surfaces. J Food Eng 61(1):137–142

    Article  Google Scholar 

  23. Darvishi H, Najaf HA, Khodaei J, Aazdbakht M (2013) Far-infrared drying characteristics of mushroom slices. Chem Prod Process Model 8(2):107–117

    Google Scholar 

  24. Akpinar E, Midilli A, Bicer Y (2003) Single layer drying behaviour of potato slices in a convective cyclone and mathematical modelling. Ener Convers Manag 44(7):1689–1705

    Article  Google Scholar 

  25. Alibas I, Köksal N (2014) Convective, vacuum and microwave drying kinetics of mallow leaves and comparison of color and ascorbic acid values of three drying methods. Food Sci Technol (Campinas) 34(2):358–364

    Article  Google Scholar 

  26. Musielak G, Kieca A (2014) Influence of varying microwave power during microwave–vacuum drying on the drying time and quality of beetroot and carrot slices. Dry Technol 32(11):1326–1333

    Article  Google Scholar 

  27. Lee JH, Zuo L (2013) Mathematical modeling on vacuum drying of Zizyphus jujuba miller slices. Food Sci Technol 50(1):115–121

    Article  Google Scholar 

  28. Mitra J, Shrivastava SL, Srinivasarao P (2011) Vacuum dehydrated kinetics of onion slices. Food Bioprod Process 89(1):1–9

    Article  Google Scholar 

  29. Cui ZW, Xu SY, Sun DW (2004) Microwave-vacuum drying kinetics of carrot slices. J Food Eng 65:157–164

    Article  Google Scholar 

  30. Methakhup S, Chiewchan N, Devahastin S (2005) Effects of drying methods and conditions on drying kinetics and quality of Indian gooseberry flake. Food Sci Technol 38:579–587

    Google Scholar 

  31. Hu QG, Min Z, Mujumdar AS, Xiao GN, SUN JC (2006) Drying of edamames by hot air and vacuum microwave combination. J Food Eng 77:977–982

    Article  Google Scholar 

  32. Giri SK, Prasad S (2007) Drying kinetics and rehydration characteristics of microwave-vacuum and convective hot-air dried mushrooms. J Food Eng 78:512–521

    Article  Google Scholar 

  33. Zielinska M, Zapotoczny P, Alves-Filho O, Eikevik TM, Blaszczak W (2013) A multi-stage combined heat pump and microwave vacuum drying of green peas. J Food Eng 115(3):347–356

    Article  Google Scholar 

  34. Dak M, Pareek NK (2014) Effective moisture diffusivity of pomegranate arils undergoing microwave-vacuum drying. J Food Eng 122:117–121

    Article  Google Scholar 

  35. Jaya S, Das H (2003) A vacuum drying model for mango pulp. Dry Technol 21:1215–1234

    Article  Google Scholar 

  36. Arevalo-pinedo A, Murr FEX (2007) Influence of pre-treatments on the drying kinetics during vacuum drying of carrot and pumpkin. J Food Eng 80:152–156

    Article  Google Scholar 

  37. Defraeye T (2014) Advanced computational modelling for drying processes-a review. Appl Energy 131:323–344

    Article  Google Scholar 

  38. Bórquez R, Melo D, Saavedra C (2015) Microwave–vacuum drying of strawberries with automatic temperature control. Food Bioprocess Technol 8(2):266–276

    Article  Google Scholar 

  39. Giri SK, Prasad S (2013) Quality characteristics of microwave-vacuum dried button mushrooms (Agaricus bisporus). Octa J Biosci 1(1):24–31

    Google Scholar 

  40. Mothibe KJ, Wang CY, Mujumdar AS, Zhang M (2014) Microwave-assisted pulse-spouted vacuum drying of apple cubes. Dry Technol 32(15):1762–1768

    Article  Google Scholar 

  41. Orikasa T, Koide S, Sugawara H, Watanabe T, Okada M, Matsushima U, Kato K, Muramatsu Y, Thammawong M, Nakamura N, Shiina T (2014) Drying kinetics and quality of tomato fruits dehydrated by a vacuum-microwave method. In: J.B. Golding et al. (Eds) XXIX IHC – Proc. Int. Symposia on Postharvest Knowledge for the Future and Consumer and Sensory Driven Improvements to Fruits and Nuts, Sustaining Lives, Livelihoods and Landscapes (IHC2014): 1120 (pp. 375–380).

  42. Therdthai N, Zhou W (2009) Characterization of microwave vacuum drying and hot air drying of mint leaves (Mentha cordifolia Opiz ex Fresen). J Food Eng 91(3):482–489

    Article  Google Scholar 

  43. Bondaruk J, Markowski M, Blaszczak W (2007) Effect of drying conditions on the quality of vacuum-microwave dried potato cubes. J Food Eng 81(2):306–312

    Article  Google Scholar 

  44. Cui ZW, Sun LJ, Chen W, Sun DW (2008) Preparation of dry honey by microwave-vacuum drying. J Food Eng 84(4):582–590

    Article  Google Scholar 

Download references

Author information

Authors and Affiliations

  1. Department of Biosystems Engineering, Faculty of Agriculture, Bu-Ali Sina University, Hamedan, Iran

    Reza Amiri Chayjan, Nesa Dibagar & Behnam Alaei

Authors
  1. Reza Amiri Chayjan
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Nesa Dibagar
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Behnam Alaei
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Reza Amiri Chayjan.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Chayjan, R.A., Dibagar, N. & Alaei, B. Drying characteristics of zucchini slices under periodic infrared-microwave vacuum conditions. Heat Mass Transfer 53, 3473–3485 (2017). https://doi.org/10.1007/s00231-017-2081-9

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s00231-017-2081-9

Search

Navigation