Abstract
The inherent problems of the rotating machine dysfunction are often caused by shaft misalignment. This defect generates some important loads and vibrations, and can lead to a premature failure of the bearing, the shaft, or the coupling. This work deals with the development of a theoretical model describing this phenomenon. This allows obtaining and analysing the vibration response as well as the reaction in bearings.
Similar content being viewed by others
References
Pyle LR (2002) Five Basic Erors in Shaft Alignment. Maintenance Resources.com, online magazine
Xu M, Marangoni RD (1994) Vibration analysis of a motor-flexible coupling system subject to a misalignment and unbalance, part 1: theoretical mode and analysis. J Sound Vib 176:663–679
Xu M, Marangoni RD (1994) Vibration analysis of a motor-flexible coupling system subject to a misalignment and unbalance, part 2: Experimental validation. J Sound Vib 176:681–691
Perreira ND, Dubowsky S (1980) Analytical method to predict noise radiation from vibrating machine systems. J Acoust Soc 67:551–563 America
Dewell DL, Mitchell LD (1984) Detection of a misaligned disk coupling using spectrum analysis. J Vibration Acoust Stress Reliab Des 216:553–570
Hamzaoui N, Boisson C, Lesueur C (1998)Vibro-Acoustic and identification of defects in rotating machinery. J Sound Vib 106:9–16
Ginsberg JH (2001) Mechancal and structural vibrations. Wiley, New York
Lalanne M, Ferraris G (1990) Rotor dynamics in engineering. Wiley, New York
Gibert RJ Vibration des structures. CEA–EDF-INRIA, Ecole d’été d’Analyse Numérique, Editions Eyrolle
Dhatt G, Touzot G (1984) Une présentation de la méthode des éléments finis. Collection Université de Compiègne, Edition Maloine
Batoz JL, Dhatt G (1990)Modélisation des structures par éléments finis – volume 1: solide élastique. Edition Hermès, Paris
Lalanne M, Ferraris G (1996) Dynamique des rotors en flexion. Techniques de l’ingénieur, traité Génie mécanique
Timoshenko S, Young DH (1948) Advanced dynamics. McGraw-Hill
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Hili, M., Fakhfakh, T., Hammami, L. et al. Shaft misalignment effect on bearings dynamical behavior. Int J Adv Manuf Technol 26, 615–622 (2005). https://doi.org/10.1007/s00170-004-2013-y
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00170-004-2013-y