Abstract
Au-based catalysts, generally known for high activity in the selective catalytic oxidation of CO to CO2 at ambient temperatures, can play a significant role in increasing the fuel cell system’s CO tolerance. In this work, an unconventional CO tolerance method, using an Au/TiO2 “guard bed”, has been investigated. The system is unconventional in the sense that it does operate as a PROX catalyst, but not in a traditional reformer system configuration. Instead, it has been developed to completely remove CO onboard the vehicle over a wide range, ppm to percentage levels, from impure pressurized H2-rich gas, i.e. from partially enriched H2 that would be stored in a fuel tank/cylinder but that would have some CO contamination and would essentially be dry. This set up will allow a reduction in the cost and complexity of conventional “off-board” hydrogen enrichment. The system CO tolerance obtained with the Au/TiO2 system was compared with state of the art PtRu/C and PtMo/C CO tolerant anode technologies. Catalytic effectiveness in the removal of CO has been directly monitored by both direct analytical measurements and by monitoring the operation of a laboratory fuel cell to which the purified hydrogen stream was passed.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
S. Gottesfeld and T. A. Zawodzinski,Adv. Electrochemical Science and Engineering, 1997,5, 219
M.S. Wilson, C.R. Derouin, J.A. Valerio and S. Gottesfeld,Proc. 28th Intersociety Energy Conversion Engineering Conference, Atlanta, Georgia, 1993,1, 1203
3 M. Iwase, and S. Kawatsu, in “First International Symposium on Proton Conducting Membrane Fuel Cells I”, eds. A.R. Landgrebe, S. Gottesfeld and G. Halpert,The Electrochemical Society, Pennington, NJ, 1995, PV 95-23, p. 12
H.F. Oetjen, V.M. Schmidt, U. Stimming and F. Trila,Electrochemical Society, 1996,143, 3838
T.R. Ralph and M.P. Hogarth,Catalysis for Low Temperature Fuel Cells Part II, Platinum Metals Review, 2002,46, 117
S. Watanabe, Influence of Impurities in Hydrogen on Fuel Cell Performance,Hydrogen Codes and Standards Coordinating Committee Fuel Purity Specifications Workshop, 26 April 2004
B.N. Grgur, G. Zhuang, N.M. Markovic, and P.N. Ross,Journal of Physical Chemistry, 1997,101, 3910
B.N. Grgur, G. Zhuang, N.M. Markovic and P.N. Ross,Journal of Physical Chemistry, 1998,102, 2494
S. Mukerjee, S.J. Lee, E.A. Ticianelli, J. McBreen, B.N. Grgur, N.M. Markovic, P.N. Ross, J.R. Giallombardo and E.S. De Castro,Electrochemical Solid State Letters, 1999,2, 12
S. Mukerjee and R.C. Urian,Electrochemica Acta, 2002,47, 3219
J.H. Yang J.D. Henao, M.C. Raphulu Y. Wang T. Caputo A J Grosnek M.C. Kung, M.S. Scurrell, J.T. Miller and H.H. Kung,J. Phys. Chem. B. 2005,109 10319
J. Steyn, G. Pattrick, M.S. Scurrell, D. Hildebrandt, M.C. Raphulu, and E. van der Lingen,Catal. Today, 2007,122, 254
Author information
Authors and Affiliations
Rights and permissions
Open Access This is an open access article distributed under the terms of the Creative Commons Attribution Noncommercial License ( https://creativecommons.org/licenses/by-nc/2.0 ), which permits any noncommercial use, distribution, and reproduction in any medium, provided the original author(s) and source are credited.
About this article
Cite this article
Steyn, J., Pattrick, G., Scurrell, M.S. et al. An unconventional Au/TiO2 PROX system for complete removal of CO from non-reformate hydrogen. Gold Bull 41, 318–325 (2008). https://doi.org/10.1007/BF03214889
Issue Date:
DOI: https://doi.org/10.1007/BF03214889