Abstract
Indium tin oxide (ITO) films containing different In : Sn atomic ratios, viz. 90 :10, 70 :30, 50 : 50, 30 :70, were deposited on two types of glass substrates by sol-gel spinning technique. XPS analysis of the films was done under as-received and after-sputtering conditions. The narrow spectra obtained for the Na1s, In3d, Sn3d and O1s have been discussed. Oxygen was found to exist in three chemical environments in as-received samples due to the existence of (i) environmental hydroxyl (-OH) group, (ii) crystalline ITO and (iii) amorphous ITO; but it was in two chemical environments, (ii) and (iii), after surface cleaning by sputtering. The presence of both tin metal and tin oxides was confirmed by the peak analysis of Sn3d. The In : Sn atomic ratio taken in the precursor sols did not change considerably in the case of developed films of low Sn content, but considerable change was observed in the films having high Sn content.
Similar content being viewed by others
References
Alam M J and Cameron D C 2002Thin Solid Films 420–421 76
Arfsten N J, Kaufmann R and Dislich H 1984Ultrastructure processing of ceramics, glasses and composites (eds) L L Hench and D R Ulrich (New York: John Wiley & Sons) p. 189
Atashbar M Z, Gong B, Sun H T, Wlodarski W and Lamb R 1999Thin Solid Films 354 222
Atta A K, Biswas P K and Ganguli D 1990J. Non-Cryst. Solids 125 202
Balasubramanian N and Subramanyam A 1989J. Phys. D: Appl. Phys. 22 206
Barua A K and Banerjee R 1992New materials (eds) S K Joshiet al (New Delhi: Narosa Publishing House) p. 96
Biswas P Ket al 2000Photonics-2000 (eds) S K Lahiriet al (New Delhi: Allied Publishers Limited)2 p. 636
Biswas P K, De A, Pramanik N C, Chakraborty P K, Ortner K, Hock V and Korder S 2003Mater. Lett. 57 2326
Briggs D and Seah M P 1990Practical surface analysis (New York: John Wiley & Sons)1
Cao X, Cao L, Yao W and Ye X 1998Thin Solid Films 317 443
Cho J-S, Koh S-K and Yoon K H 2000J. Electrochem. Soc. 147 1065
Christian K D J and Shatynski S R 1983Thin Solid Films 108 319
Fan J C C and Goodenough J B 1977J. Appl. Phys. 48 3524
Frank G, Kauer E and Kostlin H 1981Thin Solid Films 77 107
Furusaki T and Kodaira K 1991High performance ceramic films and coatings (ed.) P Vincenzini (Amsterdam: Elsevier Science Publishers) p. 241
Gallagher D, Scanlan F, Houriet R, Mathieu H J and Ring T A 1993J. Mater. Res. 8 3135
Ishida T, Kobayashi H and Nakato Y 1993J. Appl. Phys. 73 4344
Karasawa T and Miyata Y 1993Thin Solid Films 223 135
Kim H, Horwitz J S, Kushto G P, Qadri S B, Kafafi Z H and Chrisey D B 2001Appl. Phys. Lett. 78 1050
Kobayashi H, Ishida T, Nakamura K, Nakato Y and Tsubomura H 1992J. Appl. Phys. 72 5288
Kostlin H 1982Festkorperprobleme XXII 229
Kostlin H, Jost R and Lems W 1975Phys. Status Solidi A29 87
Kulkarni A K and Knickerbocker S A 1992Thin Solid Films 220 321
Kundu D, Biswas P K and Ganguli D 1989J. Non-Cryst. Solids 110 16
Mori N, Ooki S, Masubuchi N, Tanaka A, Kogoma M and Ito T 2002Thin Solid Films 411 6
Naseem S and Coutts T J 1986Thin Solid Films 138 65
Ohhata Y, Shinoki I and Yoshida S 1979Thin Solid Films 59 255
Parent Ph, Dexpert H and Tourillon G 1992J. Electrochem. Soc. 139 276, 282
Pujilaksono B, Klement U, Nyborg L, Jelvestam U, Hill S and Burgard D 2005Mater. Charact. 54 1
Scofield J H 1976J. Electron Spectrosc. & Rel. Phenom. 8 129
Takahashi Y, Hayashi H and Ohya Y 1992Mater. Res. Soc. Symp. Proc. 271 401
Takahashi Y, Okada S, Tahar R B H, Nakano K, Ban T and Ohya Y 1997J. Non-Cryst. Solids 218 129
Yamaguchi M, Ektessabi A I, Nomura H and Yasui N 2004Thin Solid Films 447–448 115
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Biswas, P.K., De, A., Dua, L.K. et al. Surface characterization of sol-gel derived indium tin oxide films on glass. Bull Mater Sci 29, 323–330 (2006). https://doi.org/10.1007/BF02706504
Received:
Revised:
Issue Date:
DOI: https://doi.org/10.1007/BF02706504