Abstract
Linear alkylbenzene (LAB) was introduced in the mid-1960s as a raw material for cleaning products. Since then, continuing and explosive research on its biodegradation and on its environmental and human toxicity has been performed. The efficiency of linear alkylbenzene sulfonate as surfactant is clearly established, and it is one of the safest and most cost-effective products in widespread commercial use. The aim of the present paper is to survey the most important developments and understandings of the chemistry of LAB production and of its physical and environmental properties. The expected consequence of this analytical survey is to envisage the continuous challenges for the detergents industry in catalytic production of LAB, better control of selectivity, replacement of corrosive and mineral liquid acid catalyst by heterogeneous acid catalyst and the maintenance of competitiveness of LAB with respect to natural alcohols.
Similar content being viewed by others
References
Jacobs, P.A., and J.A. Martens,Introduction to Zeolite Science and Practice, edited by V. Vann Bekkum, E.M. Flanigen and J.C. Jansen, Elsevier, 1991.
Anon.,Kirk-Othmer, Encyclopedia of Chemical Technology, 2nd edn., Vol. 1, 1963.
Patikins, S.H., and B.S. Friedman,Friedel-Crafts and Related Reactions, Interscience Publishers, Vol. 2, 1964, Chapter 14.
Roberts, R.M., and A.A. Khalaf,Friedel-Crafts Alkylation Chemistry, Marcel Dekker, New York, 1984.
Davidsohn, A.S., and B. Milwidsky,Synthetic Detergents, Longman Scientific & Technical, Essex, 7th edn., 1987.
Holtzman, S., and B.M. Milwidsky,Soap Chem. Spec.:64, 1965.
Alul, H.R.,Ind. Eng. Chem. Prod. Res. Dev. 7:7 (1968).
Alul, H.R.,J. Org. Chem. 33:1522 (1968).
Alul, H.R., and G.J. McEwan,Ibid. 37:3323 (1972).
Alul, H.R., and G.J. McEwan,Ibid. 37:4157 (1972).
Alul, H.R., and G.J. McEwan,Ibid. 32:3365 (1967).
Olson, A.C.,Ind. Eng. Chem. 52:833 (1960).
Swisher, R.D., E.F. Kaelble and S.K. Liu,J. Org. Chem. 26:4066 (1961).
Cavalli, L., C. Divo, G. Giuffrida, T. Pellizzon, P. Radici, L. Valtorta and A. Zatta,Proceedings of Actas Third CESIO International Surfactants Congress, London, June 1–5, 1992.
Hinds, G.E.,Anionic Surfactants, edited by W.M. Linfield, Marcel Dekker Inc., New York, Vol. 1, 1976, p. 17.
Biermann, M., F. Lange, R. Piorr, U. Ploog, H. Rutzen, J. Schindler and R. Schmid,Surfactants in Consumer Products, edited by J. Falbe, Springer-Verlag, Berlin, 1987.
Lappin, G.R.,Alpha Olefins Applications Handbook, edited by G.R. Lappin, and J.D. Sauer, Marcel Dekker, New York, 1989, p. 35.
Vora, B.V., P.R. Pujado, T. Imai and T.R. Fritsch, inRecent Advances in Detergent Industry, Society of Chemical Industry, University of Cambridge, March 26–28, 1990.
Fritsch, T., S. Ozmen, S. Raghuram, A. Banerji, J. Berna and A. Moreno,Proceedings of Actas Third CESIO International Surfactants Congress, London, June 1–5, 1992.
Almeida, J.L.G., E.A. Sales and R. Frety,Actas Simp. Iberoam. Catal. 12:644 (1990).
Gangemi, G.C., J.L.G. Almeida and R. Frety,Ibid.:633 (1990).
Petrochemical News 31, William Bland Co., 1993, p. 12C.
Swisher, R.D.,Surfactant Biodegradation, 2nd edn., Marcel Dekker, New York, 1987.
Larson, R.J., T.M. Rothgeb, R.J. Shimp, T.E. Ward and R.M. Ventullo,J. Am. Oil Chem. Soc. 70:645 (1993).
American Society for Testing and Materials, Standard Test Method for Biodegradability of Alkylbenzene Sulfonates, Designation: D 2667-82, Philadelphia, 1982, pp. 526–535.
Robeck, G.G., J.M. Cohen, W.T. Sayers and R.L. Woodward,J. Water Pollut. Control Fed. 35:1225 (1963).
Tarring, R.C.,Int. J. Air Wat. Poll 9:545 (1965).
Huddleston, R.L., and R.C. Allred,Dev. Ind. Microbiol 4:24 (1963).
Ruschenburg, E.,Fette, Seifen, Anstrichm. 65:810 (1963).
Swisher, R.D.,J. Water Pollut. Control Fed. 35:877 (1963).
Swisher, R.D.,Ibid. 35:1557 (1963).
Allred, R.C., E.A. Setzkorn and R.L. Huddleston,J. Am. Oil Chem. Soc. 41:13 (1964).
Kölbel, H., P. Kurzendörfer and C. Werner,Tenside 4:33 (1967).
Schöberl, P.,Tenside, Surfactants Deterg. 26:86 (1989).
Mieure, J.P., M.L. Trehy and R.A. Kimerle,Proceedings of Third World Conference and Exhibition on Detergents, Montreux, September 26–30, 1993.
Brenner, T.E.,J. Am. Oil Chem. Soc. 45:433 (1968).
Mann, A.H., and V.W. Reid,Ibid. 48:588 (1971).
Hon-Nami, H., and T. Hanya,Water Res. 14:1251 (1980).
Matthijs, E., and M. Stalmans,Tenside Surfactants Deterg. 30:29 (1993).
Sweeney, W.A., and R.G. Anderson,J. Am. Oil Chem. Soc. 66:1844 (1989).
Hirsh, E.,Vom Wasser 30:249 (1963).
Kay, J.H., F.E. Kohn and J.C. Calandra,Toxic. Appl. Pharmacol. 7:812 (1965).
Brown, V.M., V.V. Mitrovic and G.T.C. Stark,Water Res. 2:255 (1968).
Cairns, J., and J.J. Loos,Proc. Pa. Acad. Sci. 4:47 (1967).
Divo, C.,Riv. Ital. Sostanze Grasse 53:88 (1976).
Divo, C., and G. Cardini,Tenside Deterg. 17:30 (1980).
Schmid, O.J., and H. Mann,Nature 18:675 (1961).
Marchetti, R.,Riv. Ital. Sostanze Grasse 41:533 (1964).
Kimerle, R.A.,Tenside Surfactants Deterg 26:169 (1989).
Lewis, M.A.,Water Res. 25:101 (1991).
Tusing, T.W., O.E. Paynter and D.L. Opdyke,Toxicol. Appl. Pharmacol. 2:464 (1960).
Michael, W.R.,Ibid. 12:473 (1968).
Oser, B.L., and K. Morgavidge,Ibid. 7:819 (1965).
Gloxhuber, C.,Anionic Surfactants—Biochemistry, Toxicology, Dermatology, Marcel Dekker, New York, 1980.
Beck, L.W., A.W. Maki, N.R. Astman and E.R. Wilson,Regul. Toxicol. Pharmacol. 1:19 (1981).
Huber, L.,Tenside Surfactants Deterg 26:71 (1989).
Berth, P., and P. Jeschke,Ibid. 26:75 (1989).
Hansen, P.D.,Ibid. 26:80 (1989).
Waters, J., M.S. Holt and E. Matthijs,Ibid. 26:129 (1989).
Bressan, M., R. Brunetti, S. Casellato, G.C. Fava, P. Giro, M. Marin, P. Negrisolo, L. Talladine, S. Thomann, L. Tosoni and M. Turchetto,Ibid. 26:148 (1989).
Figge, K., and P. Schöberl,Ibid. 26:122 (1989).
Larson, R.J., T.W. Federle, R.J. Shimp and R.M. Ventullo,Ibid. 26:116 (1989).
Painter, H.A., and T. Zabel,Ibid. 26:108 (1989).
Berna, J.L., J. Ferrer, A. Moreno, D. Prats and F. Ruiz Bevia,Ibid. 26:101 (1989).
Giger, W., A.C. Alder, P.H. Brunner, A. Marcomini and H. Siegrist,Ibid. 26:95 (1989).
Poremski, H.J.,Ibid. 26:85 (1989).
Ötvös, I., S. Iglewsky, D.H. Hunneman, B. Bartha, Z. Balthazar and G. Pályi,J. Chromatogr. 78:309 (1973).
Ötvös, I., B. Bartha, Z. Balthazar and Pályi, G.,J. Chromatogr. 94:330 (1974).
Cavalli, L., A. Landone, C. Divo, G. Gini, M. Galli and E. Bareggi,J. Am. Oil Chem. Soc. 53:704 (1976).
Sendem, W.A.A., and R. Riermersma,Tenside Deterg 22:319 (1985).
Bravo, J., and R. Vergara,Tenside Surfactants Deterg 25:212 (1988).
Fellows, R., and F.W. Heywood,Industrial Applications of Surfactants III, edited by D.R. Karsa, Royal Society Chemistry, Cambridge, 1992.
Wingrave, J.A.,Soap. Cosmet. Chem. Spec.:33 (1981).
Rubinfeld, J., E.M. Emery and H.D. Cross III,J. Am. Oil Chem. Soc. 41:822 (1964).
Sweeney, W.A., and A.C. Olson,Ibid. 41:815 (1964).
Rubinfeld, J., E.M. Emery and H.D. Cross III,Ind. Eng. Chem. Prod. Res. Dev. 4:33 (1965).
Anstett, R.M., P.A. Munger and J. Rubinfeld,J. Am. Oil Chem. Soc. 43:25 (1966).
Rubinfeld, J., and H.D. Cross III,Soap Chem. Spec.:41 (1967).
Matheson, K.L., and T.P. Matson,J. Am. Oil Chem. Soc. 60:1693 (1983).
Matheson, K.L., M.F. Cox and D.L. Smith,Ibid. 62:1391 (1985).
Cox, M.F., and K.L. Matheson,Ibid. 62:1391 (1985).
Rosen, M.J.,Surfactants and Interfacial Phenomena, Wiley, New York, 1978.
Smith, D.L., K.L. Matheson and M.F. CoxJ. Am. Oil Chem. Soc. 62:1399 (1985).
Moreno, A., J. Bravo and J.L. Berna,Ibid. 65:1000 (1988).
Moreno, A., L. Cohen and J.L. Berna,Tenside Surfactants Deterg. 25:216 (1988).
Moreno, A., L. Cohen and J.L. Berna,J. Am. Oil Chem. Soc. 67:547 (1990).
Cohen, L., A. Moreno and J.L. Berna,Tenside Surfactants Deterg. 29:131 (1992).
Cohen, L., A. Moreno and J.L. Berna,J. Am. Oil Chem. Soc. 70:79 (1993).
Venuto, P.B., L.A. Hamilton, P.S. Landis and J.J. Wise,J. Catal. 5:81 (1966).
Sebulsky, R.T., and A.M. Henke,Ind. Eng. Chem. Process Des. Dev. 10:272 (1971).
Bakhshi-zade, A.A., Russian Patent 739046 (1980).
Young, L.B., United States Patent 4,301,316 (1981).
Young, L.B.,Ibid. United States Patent 4,301,317 (1981).
Bouncer, H.A., European Patent Application 016145 (1985).
Ming-Yuan, H., L. Zhonghui and M. Enze,Catal. Today 2:321 (1988).
Bouncer, H.A., European Patent Application 016144 (1985).
Berna Tejero, J.L. and A. Moreno Danvila,Ibid. European Patent Application 0353813 (1990).
Le, Q.N., D.O. Marler, J.P. McWilliams, M.K. Rubin, J. Shim and S.S. Wong, United States Patent 4,962,256 (1990).
San Gil, R.A.S., S.Q.M. Leite, S.M.C. Menezes, H.A.A. Abdel Rehin and N.M. Estrada,Proceedings of the 5th Cong. Bras. Petroquimica, IBP, Salvador, Brazil, 1992.
Araújo, S.A., Thesis, Alkylation of Benzene with 1-Dodecane in Presence of Zeolites, Universidede de São Paulo, I.Q., 1992.
Sivasanker, S., and A. Thangaraj,J. Catal. 138:386 (1992).
Sivasanker, S., A. Thangaraj, R.A. Abulla and P. Ratnasamy,Proceedings of the 10th International Congress on Catalysis, July 19–24, 1992, Budapest, Hungary, pp. 397–408.
Author information
Authors and Affiliations
About this article
Cite this article
de Almeida, J.L.G., Dufaux, M., Taarit, Y.B. et al. Linear alkylbenzene. J Am Oil Chem Soc 71, 675–694 (1994). https://doi.org/10.1007/BF02541423
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/BF02541423