Zusammenfassung
Es wird die Druckabhängigkeit des nicht -Newtonschen Fließverhältens von Polyolefinschmelzen (Hochdruck-, Niederdruck-,Phillips-Polyäthylen und Polypropylen) experimentell untersucht und gefunden, daß der durch Gl. [1] definierte Druckkoeffizient\(\alpha _{\dot \gamma } \) mit zunehmender Deformationsgeschwindigkeit\((\dot \gamma = 1,2 \ldots 120 \sec ^{ - 1} )\) kleiner wird und dabei die (im einzelnen in der Tabelle 1 angeführten) Werte\(\alpha _{\dot \gamma } = 1,46 \cdot 10^{ - 3} \ldots 0,32 \cdot 10^{ - 3} cm^2 \cdot kp^{ - 1} \) annimmt. Der Druckkoeffizient der Polyolefinschmelzen ist ebenso wie für vieleNewtonsche Flüssigkeiten bis 2000 kp cm−2 unabhängig vom Druck, er wird mit zunehmender Temperatur kleiner und nimmt mit zunehmender Verzweigung zu. Die Meßergebnisse werden mit Hilfe eines Aufweitungsvolumens interpretiert. Es wird gezeigt, daß eine Deutung des Fließverhaltens von Polyäthylen durch das freie Volumen allein nicht möglich ist.
Summary
The influence of pressure of the non-Newtonian flow behaviour of polyolefin melts (Low- and High density Polyethylene,Phillips-Polyethylene and Polypropylene) was investigated. The results are: the coefficient of pressure\(\alpha _{\dot \gamma } \) as defined by eq. [1], decreases with increasing shear rate\((\dot \gamma = 1.2 to 120 \sec ^{ - 1} )\) and reaches the values given in table 1\((\alpha _{\dot \gamma } = 1,46 \times 10^{ - 3} \ldots 0,32 \times 10^{ - 3} cm^2 kp^{ - 1} )\). The pressure coefficient of polyolefin melts does not depend on pressure up to 2000 kp cm−2. As observed with manyNewtonian fluids,\(\alpha _{\dot \gamma } \) decreases with increasing temperature and increases with the degree of branching. The experimental results are explained by means of a so called volume of expansion. It has been shown that it is impossible to explain the flow behaviour of polyethylene exclusively with the free volume.
Schrifttum
Norton, A. E., M. J. Knott, andJ. R. Muenger, Trans. ASME63, 631 (1941).
Semjonow, V., Rheologica Acta2, 138 (1962).
Semjonow, V., Rheologica Acta3, 98 (1963).
Hirai, N. andH. Eyring, J. Polymer Sci.37, 51 (1959).
Bueche, F., J. Chem. Phys.36, 2940 (1962).
Weymann, H. D., Kolloid-Z.181, 131 (1962).
Bondi, A., J. Chem. Phys.14, 591 (1946).
Kuss, E., Z. angew. Phys.10, 566 (1958).
Kauzmann, W. andH. Eyring, J. Amer. Chem. Soc.62, 3113 (1940).
Meissner, J., Paper presented at the 4th Intern. Congr. on Rheologgy, 26.–30. Aug. 1963, Providence.
Hellwege, K.-H., W. Knappe undP. Lehmann, Kolloid-Z.183, 110 (1962).
Semjonow, V., unveröffentlichte Messungen.
Hersey, M. D. andR. F. Hopkins, Viscosity of Lubricants under Pressure (New York 1954).
Bridgman, P. W., Phys. Rev. (2)25, 899 (1925).
Batschinski, A. J., Phys. Z.13, 1157 (1912); Z. phys. Chem.84, 643 (1913).
Bingham, E. C. andP. W. Kinney, J. appl. Phys.11, 192 (1940).
Dubief, J., Compt. Rend.182, 688 (1962).
MacLeod, D. B., Trans. Faraday Soc.19, 6 (1923); Trans. Faraday Soc.32, 875 (1936).
Stuart, H. A., Z. Naturforschung3a, 196 (1948).
Peterlin, A., inH. A. Stuart, Physik der Hochpolymere, Bd. II, S. 280–324 (Berlin 1953).
Hendus, H. undG. Schnell, Kunststoffe51, 69 (1961).
Author information
Authors and Affiliations
Additional information
Für die Diskussion und Förderung dieser Arbeit danke ich Herrn Professor Dr.K.-H. Hellwege und Herrn Dr.W. Knappe.
Rights and permissions
About this article
Cite this article
Semjonow, V. Druckabhängigkeit der Viskosität einiger Polyolefinschmelzen. Rheol Acta 4, 133–137 (1965). https://doi.org/10.1007/BF01984709
Received:
Issue Date:
DOI: https://doi.org/10.1007/BF01984709