Abstract
Thermogravimetry and differential thermal analysis of films and fibres prepared from polypyromellitimidediphenyl oxide were carried out with standard Derivatograph and Du Pont-951 thermoanalyzers. The results were used for the investigation of some methodological factors affecting the processes of thermal degradation of polyimides, and the quantitative characteristics of these processes. It was shown that the pattern of thermal degradation of polyimide and its thermal characteristics depend on the construction of the sample holders, on the weight of the sample and on its packing in the holder. It is concluded that strict standardization of conditions of comparative thermal analysis and a detailed description of the conditions of carrying out the analysis are necessary to obtain comparable results.
Résumé
Etude de pellicules et de fibres préparées à partir de l'oxyde de polypyromellit imidediphényle, par thermogravimétrie et par analyse thermique différentielle à l'aide d'un Derivatograph et d'un analyseur Du Pont 951. On a suivi l'influence de quelques facteurs méthodologiques sur le processus de la dégradation thermique des polyimides et sur les caractéristiques quantitatives qui s'y rapportent. On montre que le schéma de dégradation thermique du polyimide et les caractéristiques thermiques dépendent de la construction des supports d'échantillon, de la masse de l'échantillon et de la manière dont celui-ci est disposé dans le creuset. On en conclut que l'obtention de résultats comparables est soumise à l'emploi d'un mode opératoire méthodique et à la description détaillée des conditions expérimentales de l'analyse thermique.
Zusammenfassung
Thermogravimetrie und Differentialthermoanalyse von aus Polypyromellitimid-diphenyloxid hergestellten Filmen und Fasern wurden in den Thermoanalysatoren “Derivatograph” und “Du Pont 951” durchgeführt. Die Ergebnisse wurden zur Untersuchung einiger, den thermischen Zersetzungsprozeß von Polyimiden beeinflussender methodologischer Faktoren und quantitativer Charakteristika dieser Vorgänge eingesetzt. Es wurde gezeigt, daß das “Muster” der thermischen Zersetzung des Polyimids und seine thermischen Charakteristika von der Konstruktion des Probenhalters, vom Gewicht der Probe und seiner Einfüllung in den Probenhalter abhängen. Daraus wird abgeleitet, daß eine strenge Standardisierung der Bedingungen der vergleichenden Thermoanalyse und eine eingehende Beschreibung der Analysenbedingungen zwecks Erhalten vergleichbarer Resultate unbedingt erforderlich sind.
Резюме
С помощью стандартны х термоанализаторов таких как дериватогр аф и прибор «Дюпон-951», были проведе ны термогравиметрич еский и дифференциальный те рмический анализ пленок и волок он, полученных их полипиромеллитимид о-дифенилоксида. Эти результаты были и спользованы для иссл едования некоторых методолог ических факторов, затрагивающих проце ссы термического разрушения полиимид ов и количественных характеристик этих п роцессов. Показано, чт о характер термической деграда ции полиимида и его термические хар актеристики, зависят от конструкции держате лей образца, веса обра зца и его набивки в держат еле. Сделано заключен ие, что для получения сравни мых результатов, требуется строгая ст андартизация услови й сравнительного терм ического анализа и детальное описание у словий его выполнени я.
Similar content being viewed by others
References
R. C. Mackenzie, J. Macromol. Sci., Ser. A, 4 (1970) 1015.
R. C. Mackenzie, J. Thermal Anal., 4 (1972) 343.
R. C.Mackenzie, J. Thermal Anal., 8 (1975)
P. D.Garn, Thermoanalytical methods of investigation A. P. N. Y. -L. 1965.
M. M. Koton andYu. N. Sazanov, J. Thermal Anal., 7 (1975) 165.
L. N.Korzhavin, Thesis, Leningrad, 1971.
L. G. Berg, Vvedenije v termografiyu (Introduction to thermography), Nauka, Moscow, 1969.
Thermal Analysis, ed. Schwenker, P. D. Garn, Academic Press, New York-London, 1969, Vol. 1., p. 243.
Yu. N. Sazanov, G. N. Fedorova andL. M. Shcherbakova, J. Appl. Polymer Sci., 19 (1975) 2335.
G. V.Bagrov, Thesis, Leningrad, 1975.
Yu. N. Sazanov, L. V. Krasilnikova andL. M. Shcherbakova, Europ. Polymer. J., 11 (1975) 801.
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Sazanov, Y.N. Effects of some methodological factors on quantitative characteristics of thermal stability of polyimide materials. Journal of Thermal Analysis 10, 391–398 (1976). https://doi.org/10.1007/BF01909891
Received:
Issue Date:
DOI: https://doi.org/10.1007/BF01909891