Abstract
Branched polyethylene irradiated (0–400 Mrad) with a Co60 source at room temperature under vacuum was studied by density, wide- and small-angle X-ray scattering (WAXS and SAXS) measurements. The radiation effects on the structure of bulk, branched polyethylene are quite similar to those observed by others on single crystals or oriented preparations. These effects include changes in bulk densityϱ, crystallinity(w c orv c) and¯d 100 and¯d 200 spacings as a function of irradiation. A decrease in crystallinity is seen to begin at radiation dose ≈100 Mrad whereas lattice expansion indicating onset of an orthorhombic-hexagonal transition can begin as low as 10 Mrads. The decrease in crystallinity can be attributed to additional lattice distortions primarily introduced by the crosslinks occurring at the lateral grain boundaries, while lattice expansion can be associated with the same crosslinking mechanism which begins at the defects both within the crystals as well as those outside the crystals at the lateral grain boundaries. Strong evidence for a primary crosslinking-at-the-defects mechanism has also come fromϱ c andϱ a data obtained in this study as a function of radiation dose. The same data have also led to an excellent correspondence between the measured density crystallinityv c and the measured WAXS crystallinityw c. Without consideration of the effects of crosslinks onϱ c andϱ a one would have obtained a divergence of the two crystallinities, especially at radiation doses greater than 100 Mrads.
Similar content being viewed by others
References
Charlesby A (1960) Atomic Radiation and Polymers, Pergamon Press, Oxford
Chapiro A (1962) Radiation Chemistry of Polymeric Systems, Wiley-Intersci, New York
Dole M (1972, 1973) The Radiation Chemistry of Macromolecules, Vol 1 and 2, Academic Press, New York and London
Dole M (1979) Polymer Plast Technol Engr 13:41
Dole M, Rose D (1948) Paper presented at the 114th Meeting of the ACS, Portland, Oregon
Salovey R, Keller A (1961) J Bel Syst Techn 40:1397, 1409
Kawai T, Keller A, Charlesby A, Ormerod MS (1965) Phil Mag 12:657
Kawai T, Keller A (1965) Phil Mag 12:673, 687
Patel GN, Keller A (1975) J Polym Sci (Phys) 13:303, 323, 333
Jenkins H, Keller A (1975) J Macromol Sci Phys B11:301
Ungar G, Keller A (1980) Polymer 21:1273
Hosemann R, Loboda-Cackovic J, Cackovic H (1972) J Mater Sci 7:963
Loboda-Cackovic J, Cackovic H (1972) Kolloid Z Z Polym 250:511
Loboda-Cackovic J, Cackovic H, Hosemann R (1974) Kolloid and Polym Sci 252:738
Nagasawa T, Kobayashi K (1970) J Appl Phys 41:4276
Yoda O, Odajima A (1980) Japan J Appl Phys 19:1241
Ungar G (1981) J Mat Sci 16:2635
Ungar G, Keller A (1980) Polymer 21:1273
Gupta M, Yeh GSY (1979) J Macromol Sci Phys B 16:225
For example: Bhateja SK, Andrews EH, Young RJ (1983) J Polymer Sci Phys 21:523
Fischer EW, Goddar H, Schmidt GF (1967) J Polym Sci B5:619
Vonk CG, Kortleve G (1967) Kolloid Z Z Polym 220:19
Kortleve G, Vonk CG (1968) Kolloid Z Z Polym 225:124
Fischer EW, Goddar H, Schmidt GF (1969) J Polym Sci A2(1):37
Kavesh S, Schultz JM (1971) J Polym Sci A2:9, 85
Fischer EW, Fakirov S (1976) J Mat Sci 11:1041
Debye P, Bueche A (1949) J Appl Phys 20:518
Porod G (1951) Kolloid Z, 124:83
Kortleve G, Vonk CG (1968) Kolloid Z Z Polym 225:124
Kawai T, Keller A (1965) Phil Mag 12:699
Woodward AE, Decley CW, Kline DE, Saner JA (1957) J Polym Sci 26:383
Heinze D (1966) Kolloid Z Polymere 210:50
Hosemann R, Lindenmeyer PH, Yeh GSY (1978) J Macromol Sci Phys B15(1):19
Boose DC, Unpublished
Author information
Authors and Affiliations
Additional information
Dedicated Prof. Dr. R. Bonart on the occasion of his 60th birthday
Rights and permissions
About this article
Cite this article
Yeh, G.S.Y., Chen, C.J. & Boose, D.C. CPS K 843 Radiation-induced crosslinking: Effect on structure of polyethylene. Colloid & Polymer Sci 263, 109–115 (1985). https://doi.org/10.1007/BF01412784
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/BF01412784