Skip to main content
SpringerLink
Log in

Tunnelling in squeezing rocks: Case histories

  • Published:
Rock Mechanics and Rock Engineering Aims and scope Submit manuscript

Summary

Squeezing rock conditions have posed and continue to pose a major obstacle to the construction of tunnels through mountains, as experience dating back more than a century shows. The paper deals with the study of past experiences in the light of present geotechnical engineering knowledge. Many of the transalpine tunnels were constructed before geotechnical engineering had been developed, and the principles underlying squeezing were not yet understood. Also construction techniques have changed with time. By studying past experience in the light of our present knowledge in geotechnical engineering (rock and soil mechanics), one may gain more insight into the nature and causes of squeezing ground behaviour. Here, a number of older and newer case histories are summarised, providing substantial insight into the phenomenon of squeezing rock. Squeezing rock behaviour is influenced by rock type and structure. Usually, in squeezing zones the rock is strongly jointed and fractured and has low strength. Overburden has also a significant effect and squeezing behaviour may occur abruptly in a tunnel once a limiting overburden has been exceeded. Water pressures in strongly jointed and often crushed rock are important and so are the adopted construction procedures and sequences. A support of substantial structural strength may be necessary to prevent long-term deformations and to withstand increased loading on the tunnel liner from the rock mass surrounding the tunnel.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Similar content being viewed by others

References

  • Albi, Ch., Forrest, K. (1986): The Moffat Tunnel, a brief history. Colorado Railroad Historical Foundation Inc. Colorado Railroad Museum, Golden, Co., 46p.

    Google Scholar 

  • Amberg, R. (1982): Projekt und Bauausführung. Schweiz. Ing. Architekt 100(24), 503–511.

    Google Scholar 

  • Amberg, R. (1983): Design and construction of the Furka Base Tunnel. Rock Mech. Rock Engng. 16(4), 215–231.

    Google Scholar 

  • Amberg, R. (1994): Die Bewältigung der Serpentinzone in der Zweispurstrecke — Vereina-Tunnel Nord. Schweiz. Ing. Architekt 44, 920–923.

    Google Scholar 

  • Amberg, R., Sala A. (1984): Shoterete as a permanent lining for the Furka Base Tunnel. Rock Mech. Rock Engng. 17(1), 1–15.

    Google Scholar 

  • Andreae, C. (1948): Les grands souterrains transalpins, Leemann AG, Zurich.

    Google Scholar 

  • Anonymous (1894): Simplon-Tunnel. Schweiz. Bauz. 24(18–21), 123 ff.

  • Anonymous (1921): Le tunnel du Simplon, sa construction, son achèvement. 47p.

  • Baumann, L., Zischinsky, U. (1994): Neue Löse- und Ausbautechniken zur maschinellen Fertigung von Tunneln in druckhaftem Fels. Felsbau 12(1), 25–29.

    Google Scholar 

  • Bianchetti, G., Zuber, F., Vuataz, F.-D., Rouiller, J. D. (1993): Hydrogeologic and geothermal investigations in the Simplon Tunnel (in German with English summary). Contribution to the geology of Switzerland, Schweizerische Geotechnische Kommission, Zürich, 75p.

    Google Scholar 

  • Bierbaumer, A. (1913): Die Dimensionierung des Tunnelmauerwerks, Engelmann, Leipzig.

    Google Scholar 

  • Bollinger, E. (1994): In: Jones, W. C. (ed.) Rails that climb, 2nd edn. Colorado Railroad Museum, Golden, Co., 235–246.

    Google Scholar 

  • Brandau, K. (1909): Das Problem des Baus langer, tiefliegender Alpentunnels und die Erfahrungen beim Bau des Simplon Tunnels. Schweiz. Bauz. 53.

  • Brunar, G., Powondra, F. (1985): Nachgiebiger Tübbingausbau mit Meypo-Stauchelementen. Felsbau, 3(4), 225–229.

    Google Scholar 

  • Brunold, R. (1993): Probleme bei der Durchörterung von Störzonen auf der Südseite. Proc., SIA-FGU, D0113, 41–44.

    Google Scholar 

  • Chronic, H. (1980): Roadside geology of Colorado, Mountain Press Publishing, Missoula, Montana, 153.

    Google Scholar 

  • Cording, E. J. (1987). Constraints in tunneling technology. In: Davidson, F. P. (ed.), Tunneling and underground transport: future developments in technology, economics, and policy, Elsevier, Amsterdam, 121–141.

    Google Scholar 

  • Cording, E. J. (1995): Personal communication.

  • Egger, P. (1989): Geotechnical problems in deep tunnelling and construction methods (in French). In: Maury, V., Formaintraux, D., Rock at great depth, ISRM-SPE Int. Symposium, Pau, Balkema, Rotterdam, 1191–1198.

  • Engineering News Record (1927): Various articles on Moffat Tunnel. Engineering News Record 96(7) 284–285; July, 14, 1927; December 22, 1927.

    Google Scholar 

  • Furka-Oberalpbahn (1981): Brochure to the holing through of the Furka-Base-Tunnel, Brig, Switzerland.

  • Gable, Dolores J. (1969): Geologic map of the Nederland Quadrangle, Boulder and Gilpin Counties, Colorado. GQ-833, U.S. Department of the Interior, U.S. Geological Survey.

  • Gable, Dolores J. (1972): Geologic map of the Tungsten Quadrangle, Gilpin and Jefferson Counties, Colorado. GQ-978, U.S. Department of the Interior, U.S. Geological Survey.

  • George, R. D. (1922): Notes on the geology of the line of the proposed Moffat Tunnel, photocopies unknown publisher.

  • Hacker, D. (1986/87): Auffahrung eines Füllortes in 1440 m Teufe mit mehrschaligem Ausbau. In: Deilmann-Haniel, Unser Betrieb, Vol. 42, 45, 47.

  • Heim, A. (1904): Über die geologische Voraussicht beim Simplon-Tunnel. Eclogae Geol. Helv. 8, 364–384.

    Google Scholar 

  • Hitchcock and Tinkler Inc. (1928): Moffat Tunnel: The contractors' story, 60 p.

  • John, M. (1976): Geotechnical measurements in the Arlberg Tunnel and their consequences on construction (in German). Rock Mech. Suppl. 5, Springer Wien New York, 157–177.

    Google Scholar 

  • Keller, F. (1993): Geologie des Zugwald und Vereinatunnels. In: Proc., SIA-FGU, D0113, Zurich, 13–20.

  • Keller, F., Schneider, T. R. (1982): Geologie und Geotechnik-Geology und geotechnics of the Furka-Base-Tunnel. Schweiz. Ing. Architekt 100(24), 512–520.

    Google Scholar 

  • Lovering, T. S. (1928): Geology of the Moffat Tunnel, Colorado. Trans. AIME 76–22, 337–346.

    Google Scholar 

  • Maillart, R. (1921): De la construction de galeries sous pression intérieure. Bulletin technique de la Suisse Romande, pp. 256–260, 271–274, 291, 294.

  • Märki, E. (1994): Verbal communication.

  • Marushack, J. M., Tilp, P. J. (1980): Stillwater Tunnel — a progress report. Tunneling Technol. Newsletter 31, September 1980, 1–11.

    Google Scholar 

  • Morton, J. D., Provost, A. J. (1980): Stillwater Tunnel: a classroom in engineering geology. Underground Rock Engineering, Proc., 13th Canadian Rock Mechanics Symposium, Toronto, 80–89.

  • Muzzani, C. (1982): Ricordi del Sempione. Gallerie e grandi opere sotterranne Vol. 6, No. 15/16, 3–11.

    Google Scholar 

  • Pressel, K. (1906): Die Bauarbeiten am Simplontunnel. Schweiz. Bauz. 50, 249 ff.

    Google Scholar 

  • Pöchhacker, H. (1974): Tunnelling in squeezing rock, theory and practice. Separate print from Porr-Nachrichten No. 57 (in German) and (in English) Proc., RETC Chapter No 27, AIME New York, 464–512.

    Google Scholar 

  • Proctor, R. V., White T. L. (1946): Rock tunnelling with steel supports, Commercial Shearing and Stamping Company, Youngstown, Ohio.

    Google Scholar 

  • Robinson, R. A., Cording, E. J., Roberts, D. A., Noppadol, P., Mahar, J. W., Parker, H. W. (1985). Ground deformations ahead and adjacent to a TBM in sheared shales at Stillwater Tunnel, Utah. Proc. RETC Vol. 1, 34–53.

    Google Scholar 

  • Rothpletz, F. (1915): Der Ausbau der Druckpartie des Simplontunnel II, km 4.452 bis km 4.500 ab Südportal. Schweiz. Bauz. 65(4, 5), 35 pp.

    Google Scholar 

  • Schardt, H. (1904): Note sur le profil géologique et la tectonique du massif du Simplon, comparés aux travaux antérieurs. Eclogae Geol. Helv. 8(1), 173–200.

    Google Scholar 

  • Schoeman, K. D. (1987): Buckskin mountain tunnel and Stillwater Tunnel: developments in technology. In: Davidson, F. P. (ed.), Tunneling and underground transport: future developments in technology, economics, and policy, Elsevier, Amsterdam, 92–108.

    Google Scholar 

  • Sinha, R. S., Schoeman, R. D. (1984): Stillwater Tunnel, central Utah project, UTAH, case history. Proc., Int. Conference on Case Histories in Geotechnical Engineering, St. Louis, 807–815.

  • Skerrett, R. G. (1925): Driving a tunnel through the Continental Divide (in four parts). Compressed Air Magazine, New York Vol. 30(2, 3, 4, 5), pp. 1133–1138, 1165–1171, 1205–1213, 1237–1244.

    Google Scholar 

  • Steiner, W. (1980): Empirical methods in rock tunnelling: review and recommendations. Thesis submitted for the degree of Sc.D. to the Department of Civil Engineering, Massachusetts Institute of Technology, Cambridge, 552 pp. also published as report of the US. DOT, UMTA-MA-06-0100-80-8, NTIS PB80-225196.

  • Steiner, W., Einstein, H. H., Azzouz, A. S. (1979): Tunneling practices in Austria and Germany. Report, Department of Civil Engineering to US. DOT, UMTA.

  • Tauernautobahn (1978): Documentation on Tauerntunnel, Salzburg.

  • Terzaghi, K. (1925): Endbaumechanik, Deuticke, Wien.

  • Terzaghi, K. (1946): Rock defects and loads on tunnel supports. In: Proctor, R. V., White, T. L. (ed.), Rock tunnelling with steel support, Youngstown, Ohio, 17–102.

  • Treichl, H. (1978): The eastern section of the Arlberg Road Tunnel (in German). Special publication by the contractor joint venture Arlberg-East.

  • Young, E. J. (1991): East portal, miscellaneous investigation series MAP 1-2212, U.S. Department of the Interior, U.S. Geological Survey.

  • Zünd, K., Kradolfer, W. (1995): Personal communication.

  • Zünd, K. (1994): Verbal communication.

Download references

Author information

Author notes

  1. W. Steiner

    Present address: Balzari & Schudel AG, Muristrasse 60, CH-3000, Bern, 16, Switzerland

Authors and Affiliations

    Authors
    1. W. Steiner
      View author publications

      You can also search for this author in PubMed Google Scholar

    Rights and permissions

    Reprints and permissions

    About this article

    Cite this article

    Steiner, W. Tunnelling in squeezing rocks: Case histories. Rock Mech Rock Engng 29, 211–246 (1996). https://doi.org/10.1007/BF01042534

    Download citation

    • Issue Date:

    • DOI: https://doi.org/10.1007/BF01042534

    Keywords

    Search

    Navigation