Skip to main content
SpringerLink
Log in

In vitro biological effects of clay minerals advised as substitutes for asbestos

  • Published:
Cell Biology and Toxicology Aims and scope Submit manuscript

Abstract

We studied one sample of commercial sepiolite and two samples of commercial vermiculite—clay minerals proposed as replacements for asbestos—and testedin vitro their abilities to activate complement, to lyse erythrocytes, and to elicit the production of reactive oxygen species (ROS) with human polymorphonuclear leukocytes (PMN) or bovine alveolar macrophages (AM); their behavior was compared with that of asbestos fibers obtained from the Union International Contra Cancer (UICC) as reference standards, as well as with kaolinite and illite, main members of the clay mineral family.

Since in short-termin vitro tests the biological activity of mineral particles seems especially related to the active sites on their surface, we first measured the specific surface area of each mineral. Sepiolite was unreactive in two of the three tests we used (complement activation and ROS production) and able to lyse a minimal percentage of red blood cells. Vermiculite was shown to be incapable of activating complement, to have a moderate hemolytic activity and a high ability to elicite ROS production, although lower than that of chrysotile. Sepiolite, therefore, might be of more interest than vermiculite, given the low level of biological effects detected during the tests used to compare both clay minerals with asbestos fibres. The ROS production does not seem to require phagocytosis. A high ROS production was observed with kaolinite: this result casts doubt on the ability of pathogenic mineral dustsin vitro to induce a greater release of ROS than nonpathogenic mineral dusts.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Similar content being viewed by others

Abbreviations

AM:

alveolar macrophages

CL:

chemiluminescence

EDTA-CH-S:

NHS treated with EDTA

EGTA-CH-S:

NHS treated with EGTA

HBSS:

Hanks' balanced salt solution

NHS:

normal human serum

PMA:

phorbol myristate acetate

PMN:

polymorphonuclear leukocytes

ROS:

reactive oxygen species

ZAP:

zymosan-activated plasma

References

  • Aeschbacher M, Reinhard CA, Zbihden G. A rapid cell membrane permeability test using fluorescent dyes and flow cytometry. Cell Biol Toxicol. 1988; 2: 247–55.

    Google Scholar 

  • Amandus HE, Wheeler R. The morbidity and mortality of vermiculite miners and millers exposed to tremolite-actinolite: Part II. Mortality. Am J Industr Med. 1987; 11: 15–26.

    Google Scholar 

  • Baris YI, Sahin AA, Erkan ML. Clinical and radiological study in sepiolite workers. Arch Environ Health. 1980; 35: 343–6.

    Google Scholar 

  • Becklake MR. Asbestos-related diseases of the lungs and pleura. Am Rev Resp Dis. 1982; 126: 187–94.

    Google Scholar 

  • Benbow J. Minerals in fire protection. Industrial Minerals. 1987; Sep: 61–73.

  • Bradley WF. Diagnostic criteria for clay minerals. Am Mineralogist. 1945; 30: 704–13.

    Google Scholar 

  • Brody AR, George G, Hill LH. Interactions of chrysotile and crocidolite asbestos with red blood cell membranes. Chrysotile binds to sialic acid. Lab Invest. 1983; 49: 468–75.

    Google Scholar 

  • Brunauer S, Emmett PH, Teller E. Adsorption of gases in multimolecular layers. J Am Chem Soc. 1938; 60: 309–19.

    Google Scholar 

  • Burilkov T, Michailova L. Asbestos content of the soil and endemic pleural asbestosis. Environ Res. 1970; 3: 443–51.

    Google Scholar 

  • Campbell DH, Garvey JS, Cremer NE, Sussidorf DH. Methods in immunology: New York: WA Benjamin; 1970: 28–30.

    Google Scholar 

  • Colditz IG, Movat HZ. Kinetics of neutrophil accumulation in acute inflammatory lesions induced by chemotaxins and chemotaxinigens. J Immunol. 1984; 133: 2169–73.

    Google Scholar 

  • de la Calle C, Suquet H. Vermiculite. In: Hydrous phyllosilicates (exclusive of micas). Min Soc Am Rev Mineralogy. 1988; 19: 455–92.

  • Deer WA, Howie RA, Zussman J. An introduction to the rock-forming minerals, London: Longman; 1977.

    Google Scholar 

  • Dickson T. Mineral fibres: a general review. Industrial Minerals. 1978; October: 18–9.

  • Dimitru-Stanescu R, Mandravel C, Bercu C. Infrared and nuclear magnetic resonance studies of some surface properties of asbestos-albumin interactions. Analyst. 1994; 119: 689–91.

    Google Scholar 

  • Doll NJ, Bozelka BE, Goldbach S, Anorve-Lopez E, Salvaggio JE. Asbestos-induced alteration of human peripheral blood monocyte activity. Int Arch Allergy Appl Immunol. 1982a; 69: 302–5.

    Google Scholar 

  • Doll NJ, Stankus RP, Godbach S, Salvaggio JE. In vitro effect of asbestos fibres on polymorphonuclear leukocyte function. Int Arch Allergy Appl Immunol. 1982b; 68: 17–21.

    Google Scholar 

  • Dunningham J. Comparing biological effects of mineral fibres. Br J Industr Med. 1989; 46: 681–2.

    Google Scholar 

  • Evans PH, Brown RC, Poole A. Modification of the in vitro activities of amosite asbestos by surface derivatization. J Toxicol Environ Health. 1983; 11: 535–43.

    Google Scholar 

  • Fantone JC, Ward PA. Role of oxygen-derived free radicals and metabolites in leukocyte-dependent inflammatory reactions. Am J Pathol. 1982; 107: 397–418.

    Google Scholar 

  • Ferrante A, Thong YH. Optimal conditions for simultaneous purification of mononuclear and polymorphonuclear leukocytes from human peripheral blood by the Hypaque-Ficoll method. J Immunol Methods. 1980; 36: 109–17.

    Google Scholar 

  • Fridovich I. The biology of oxygen radicals. Science. 1978; 201: 875–80.

    Google Scholar 

  • Fubini B. The possible role of surface chemistry in the toxicity of inhaled fibers. In: Warheit DH, ed. Fiber toxicology. San Diego: Academic Press; 1993: 229–57.

    Google Scholar 

  • Fukuda K, Kohyama K, Myojo T. Fibrogenicity and carcinogenicity in mice and rats. Environ Res Japan. 1987; 93: 1–18.

    Google Scholar 

  • Ghio AJ, Kennedy TP, Stonehuerner JG, Crumbliss AL, Hoidal JR. DNA strand breaks following in vitro exposure to asbestos increase with surface-complexed [Fe3+]. Arch Biochem Biophys. 1994; 311: 13–8.

    Google Scholar 

  • Goldstein B, Rendall REG. The relative toxicities of the main classes of minerals. In: Proc. int. conf. on pneumoconiosis, Johannesburg. 1970: 429–34.

  • Gormley IP, Kowolik MJ, Cullen RT. The chemiluminescent response of human phagocytic cells to mineral dusts. Br J Exp Pathol. 1985; 66: 409–16.

    Google Scholar 

  • Governa M, Valentino M, Visonà I, Marchiseppe I, Lo Martire N. Activation of the alternative complement pathway and generation of stimulating factors for granulocytes by glass fibers. Cell Biol Toxicol. 1988; 4: 187–97.

    Google Scholar 

  • Hahon N, Vallyathan V, Booth JA, Sepulveda MJ. In vitro biologic responses to native and surface-modified asbestos. Environ Res. 1986; 39: 345–55.

    Google Scholar 

  • Hansen K, Mossman BT. Generation of superoxide (O −2 ) from alveolar macrophages exposed to asbestiform and nonfibrous particles. Cancer Res. 1987; 47: 1681–6.

    Google Scholar 

  • Hayashi H, Koshi K, Sakabe H. Structural changes of fibrous minerals—asbestos, sepiolite and palygorrskite—on heat treatment and their effect on toxicity to the cells. Proc Int Clay Conf. 1969; 1: 903–13.

    Google Scholar 

  • Hedenborg M, Klockars M. Production of reactive oxygen metabolites induced by asbestos fibres in human polymorphonuclear leukocytes. J Clin Pathol. 1987; 40: 1189–93.

    Google Scholar 

  • Hill HR, Hogan NA, Mitchell TG. Evaluation of a cytocentrifuge method for measuring neutrophil granulocyte chemotaxis. J Lab Clin Med. 1975; 86: 703–10.

    Google Scholar 

  • Hiraoka K, Horie A, Kido N. Study of asbestos bodies in Japanese urban patients. Am J Industr Med. 1990; 18: 547–54.

    Google Scholar 

  • Ishizaki T, Yano E, Urano E, Evans PH. Crocidolite-induced reactive oxygen metabolites generation from human polymorphonuclear leukocytes. Environ Res. 1994; 66: 208–16.

    Google Scholar 

  • Koshi K, Kohyama N, Myojo T, Fukuda K. Cell toxicity, hemolytic action and clastogenic activity of asbestos and its substitutes. Industrial Health. 1991; 29: 37–56.

    Google Scholar 

  • Light W, Wei ET. The in vitro effects of mineral dusts. In: Brown RC, Chamberlain M, Davies R, Gormley IP, eds. Surface change and molecular basis of asbestos toxicity. New York: Academic Press; 1980: 141–5.

    Google Scholar 

  • Lokey JE, Brooks SM, Jarabek AM et al. Pulmonary changes after exposure to vermiculite contaminated with fibrous tremolite. Am Rev Respir Dis. 1984; 129: 952–8.

    Google Scholar 

  • Magnani C, Borgo G, Betta GP et al. Mesothelioma and non-occupational environmental exposure to asbestos. Lancet. 1991; 48: 709–14.

    Google Scholar 

  • May KR. A new graticule for particle counting and sizing. J Sci Instrum. 1965; 47: 500–1.

    Google Scholar 

  • McConnochie K, Bevan C, Newcombe RG, Lyons JP, Skidmore WJ, Wagner JC. A study of Spanish sepiolite workers. Thorax. 1993; 48: 370–4.

    Google Scholar 

  • McDonald JC, McDonald AD, Amstrong B, Sebastien P. Cohort study of mortality of vermiculite miners exposed to tremolite. Br J Industr Med. 1985; 43: 436–44.

    Google Scholar 

  • Miles PR, Castranova V, Lee P. Reactive forms of oxygen and chemiluminescence in phagocytozing rabbit alveolar macrophages. Am J Physiol. 1978; 253: C103–8.

    Google Scholar 

  • Milchev K, Kounrva N, Obretov TS, Dimitrov D. Structural-adsorption characterizations of natural vermiculite raw minerals. CR Acad Bulg. 1989; 42: 75–8.

    Google Scholar 

  • Mossman BT, Landesman JM. Importance of free radicals in asbestos-induced injury to airway epithelial cells. Chest. 1983; 83: 50S-51S.

    Google Scholar 

  • Mossman BT, March JP, Sesko A et al. Inhibition of lung injury, inflammation and interstitial pulmonary fibrosis by polyethylene glycol-conjugated catalase in a rapid inhalation model of asbestosis. Am Rev Respir Dis. 1990; 141: 1266–71.

    Google Scholar 

  • Nagy B, Bradley F. The structural scheme of sepiolite. Am Mineralogist. 1955; 40: 885–92.

    Google Scholar 

  • Nolan RP, Langer AM, Harington JS, Oster G, Selikoff IJ. Quartz hemolysis as related to its surface functionalities. Environ Res. 1981; 26: 503–20.

    Google Scholar 

  • Pezerat H, Zalma R, Guignard J, Jaurand MC. Production of oxygen radicals by the reduction of oxygen arising from the surface activity of mineral fibres. In: Bignon J, Peto J, Saracci R, eds. Non-occupational exposure to mineral fibres. Lyon: International Agency for Research on Cancer. 1989: 100–11.

    Google Scholar 

  • Pezerat H. The surface activity of mineral dusts and the process of oxidative stress. In: Brown RC, Hoskins JA, Johnson NF, eds. Mechanisms in fiber carcinogenesis. New York: Plenum Press; 1991: 387–95.

    Google Scholar 

  • Pott F, Bellman B, Muhle H et al. Intraperitoneal injection studies for the evaluation of the carcinogenicity of fibrous phyllosilicates. Berlin: Springer-Verlag; 1990: 319–29.

    Google Scholar 

  • Pye AM. A review of asbestos substitute materials in industrial applications. J Hazard Mater. 1979; 3: 125–47.

    Google Scholar 

  • Rendall REG. Occurrence, production, properties, and uses of asbestiform fibres. In: Liddel D, Miller K, eds. Mineral fibres and health. Boca Raton: CRC Press; 1991: 11–25.

    Google Scholar 

  • Reynolds HY. Bronchoalveolar lavage. Am Rev Respir Dis. 1987; 135: 250–63.

    Google Scholar 

  • Rodelsperger K, Bruckel B, Manke J, Woitowitz HJ, Pott F. Potential health risks from the use of fibrous mineral absorption granulates. Br J Industr Med. 1987; 44: 337–43.

    Google Scholar 

  • Saint Remy JMR, Cole P. Interactions of chrysotile asbestos fibres with the complement system. Immunology. 1980; 41: 431–7.

    Google Scholar 

  • Schimmelpfeng J, Seidel A. Cytotoxic effects of quartz and chrysotile asbestos: in vivo interspecies comparison with alveolar macrophages. J Toxicol Environ Health. 1991: 33: 131–40.

    Google Scholar 

  • Schnitzer RJ, Pundsack FL. Asbestos hemolysis. Environ Res. 1970; 3: 1–13.

    Google Scholar 

  • Shi X, Dalal NS, Vallyathan V. ESR evidence for the hydroxyl radical formation in aqueous suspension of quartz particles and its possible relevance to lipid peroxidation in silicosis. J Toxicol Environ Health. 1988; 25: 237–45.

    Google Scholar 

  • Singh SV, Viswanathan PN, Rahman Q. Interaction between erythrocyte plasma membrane and silicate dusts. Environ Health Perspect. 1983; 51: 55–60.

    Google Scholar 

  • Sturm W, Menze B, Krause J, Thriene B. Use of asbestos, health and induced occupational diseases in the former East Germany. Toxicol Lett. 1994; 72: 317–24.

    Google Scholar 

  • Sweeney TD, Castranova V, Bowman L, Miles PR. Factors which affect superoxide anion release from rat alveolar macrophages. Exp Lung Res. 1981; 2: 85–96.

    Google Scholar 

  • Trush MA. Chemiluminescence as a probe to investigate chemical-cell interactions: a toxicological perspective. In: van Dyke K, Castranova V, eds. Cellular chemiluminescence. vol. III. Boca Raton: CRC Press; 1987: 185–205.

    Google Scholar 

  • Vallyathan V, Schwegler D, Reasor M, Stettler L, Clere J, Green FHY. Comparative in vitro cytotoxicity and relative pathogenicity of mineral dusts. Am Occup Hyg. 1988; 32: 279–89.

    Google Scholar 

  • Van Dyke K, Van Dyke C. Calculation from light measurement. In: Van Dyke K, ed. Chemiluminescence: instruments and applications. vol. I. Boca Raton: CRC Press; 1985: 79–82.

    Google Scholar 

  • Wagner JC. Health hazards of substitutes. In: Asbestos, health and society. Proceedings of the world symposium on asbestos, Montreal, Canada, 1982. Montreal: Canadian Asbestos Information Centre; 1982: 244–67.

    Google Scholar 

  • Walker C, Everitt J, Barret C. Possible cellular and molecular mechanisms for asbestos carcinogenicity. Am J Industr Med. 1992; 21: 253–73.

    Google Scholar 

  • Walker GF. Vermiculite-organic complexes. Nature. 1950; 166: 695.

    Google Scholar 

  • Ward PA, Warren JS, Johnson KJ. Oxygen radicals, inflammation and tissue injury. Free Rad Biol Med. 1988; 5: 403–8.

    Google Scholar 

  • Warheit DB, George G, Hill LH, Snyderman R, Brody AR. Inhaled asbestos activates a complement-dependent chemoattractant for macrophages. Lab Invest. 1985; 52: 505–14.

    Google Scholar 

  • Warheit DB, Hill LH, George G, Brody AR. Time course of chemotactic factor generation and the corresponding macrophage response to asbestos inhalation. Am Rev Respir Dis. 1986; 134: 128–33.

    Google Scholar 

  • Weaver CE, Pollard LD. Vermiculite. In: The chemistry of clay minerals. Amsterdam: Elsevier; Weaver CE, Pollard LD, eds., Developments in sedimentology; vol. 15, 1973a: 99–106.

    Google Scholar 

  • Weaver CE, Pollard LD. Sepiolite. In: The chemistry of clay minerals. Amsterdam: Elsevier; Weaver CE, Pollard LD, eds., Developments in sedimentology; vol. 15, 1973b: 127–330.

    Google Scholar 

  • Woodworth CD, Mossman BT, Craighead JE. Induction of squamous metaplasia in organ cultures of hamster trachea by naturally occurring and synthetic fibres. Cancer Res. 1983; 43: 4906–12.

    Google Scholar 

  • Wright A, Gormley IP, Collings PL, Davis JMG. The cytotoxicity of asbestos and other fibrous dusts. In: Brown RC, Chamberlain M, Davies R, eds. In vitro effects of mineral dusts. Berlin: Springer-Verlag; 1980: 25–31.

    Google Scholar 

  • Zhanyuan L, Yuxiang F, Fengting Y, Xingyuan X. Study of fibrogenic effect of vermiculite dust on rat lung. In: Proc. VII int pneumoconiosis conference, Pittsburg, 1988. vol. II. Washington DC: US Dept of Human Service, NIOSH; 1988: 1290–2.

    Google Scholar 

Download references

Author information

Authors and Affiliations

  1. Institute of Occupational Medicine, University of Ancona, Italy

    M. Governa, M. Valentino, I. Visonà, F. Monaco & M. Amati

  2. Institute of Occupational Medicine, Univesity of Siena, Italy

    G. Scancarello

  3. Institute of Occupational Medicine, University of Turin, Italy

    G. Scansetti

Authors
  1. M. Governa
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. M. Valentino
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. I. Visonà
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. F. Monaco
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. M. Amati
    View author publications

    You can also search for this author in PubMed Google Scholar

  6. G. Scancarello
    View author publications

    You can also search for this author in PubMed Google Scholar

  7. G. Scansetti
    View author publications

    You can also search for this author in PubMed Google Scholar

Rights and permissions

Reprints and permissions

About this article

Cite this article

Governa, M., Valentino, M., Visonà, I. et al. In vitro biological effects of clay minerals advised as substitutes for asbestos. Cell Biol Toxicol 11, 237–249 (1995). https://doi.org/10.1007/BF00757622

Download citation

  • Accepted:

  • Issue Date:

  • DOI: https://doi.org/10.1007/BF00757622

Key words

Search

Navigation