Abstract
The high-temperature-corrosion behavior of a Ni-Co-Cr-Si superalloy (HAYNES Alloy HR-160) in an SO2+O2 (SO2∶O2=2∶1) has been studied at 625°C and 750°C. Alloy samples were corroded for 72 hr, followed by XRD, SEM, EDS, and XPS analysis on the surface and/or cross-section of the samples. It was found that the simultaneous nucleation of nickel and cobalt oxides and chromia at the initial stage lead to the subsequent formation of a sulphate layer on reaction with the gas phase. This eventually lead to the formation of a thick sulphide layer above the chromia scale. The stable phases for Cr, Ni, and Co in such an atmosphere are chromia as well as Ni and Co sulphates. The existence of a thin sulphate layer was suggested some time ago but could not be detected and was disputed. The XPS analysis in this work now provides evidence for the existence of this sulphate layer. The transport of sulphur through the oxide scale into the alloy substrate is discussed. It was concluded that sulphur advanced into the substrate by the oxidation of sulphides, thus liberating the sulphur. The possibility of sulphur transport in the form of SO2 molecules was also discussed. Based on the results and discussion, a schematic corrosion mechanism is presented.
Similar content being viewed by others
References
C. B. Alcock, M. G. Hocking, and S. Zador,Corros. Sci. 9, 111 (1969).
M. R. Wootton and N. Birks,Corros. Sci. 12, 829 (1972).
P. Kofstad and G. Akesson,Oxid. Met. 12, 503 (1978).
K. L. Luthra and W. L. Worrell,Met. Trans. A,10A, 621 (1979).
J. Gilewicz-Wolter and M. Ciechanowski,Oxid. Met. 34, 151 (1990).
P. Kofstad,High Temperature Corrosion (Elsevier, 1988), p. 451.
V. Vasantasree and M. G. Hocking,Corros. Sci. 16, 261 (1976).
M. G. Hocking and V. Vasantasree,Corros. Sci. 16, 279 (1976).
P. S. Sidky and M. G. Hocking,Corros. Sci. 27, 183 (1987).
M. G. Hocking and P. S. Sidky,Corros. Sci. 27, 205 (1987).
M. R. Wootton and N. Birks,Corros. Sci. 15, 1 (1975).
A. Anderson and P. Kofstad,Corros. Sci. 24, 731 (1984).
P. Singh and N. Birks,Oxid. Met. 19, 37 (1983).
J. Gilewicz-Wolter and K. Kowalska,Oxid. Met. 22, 101 (1984).
B. Haflan and P. Kofstad,Oxid. Met. 25, 217 (1986).
Y. H. Chung and M. J. McNallan,Oxid. Met. 31, 169 (1989).
S. N. Basu and G. J. Yurek,Oxid. Met. 35, 441 (1991).
H. Xu, M. G. Hocking, and P. S. Sidky, High Temperature Corrosion of Superalloys in a Simulated Coal Gasifier Environment, EUROCORR'91, 21–25 October 1991, Budapest, Hungary.
G. Y. Lai, A New Sulfidation-Resistant Ni-Co-Cr-Si Alloy, High Temperature Materials for Power Engineering, 24–27 September 1990, Liege, Belgium.
J. Gawel and A. Wyczesany,Corros. Sci. 28, 867 (1988).
Phase Diagrams for Ceramists, 1969 Supplement, The American Ceramic Society, 1969, p. 493.
Phase Diagrams for Ceramists, The American Ceramic Society, 1964, p. 350.
G. C. Wood and F. H. Stott,Mater. Sci. Technol. 3, 519 (1987).
P. Kofstadet al. (ed.),Oxid. Met. 32, 125 (1989), Subject area 5.
B. Haflan and P. Kofstad,Corros. Sci. 23, 1333 (1983).
P. J. Ficalora,Oxid. Met. 18, 19 (1982).
K. P. Lillerud, B. Haflan, and P. Kofstad,Oxid. Met. 21, 119 (1984).
R. Zhu, M. Guo, and Y. Zuo,Oxid. Met. 27, 253 (1987).
D. E. Jones and J. Stringer,Oxid. Met. 9, 409 (1975).
A. Andersonet al. Mat. Sci. Eng. 87, 45 (1987).
M. Guoet al. Hot Corrosion Behaviour of Alloy 5Cr21Mn9Ni4(W)N Induced by Na2SO4 Deposits, 5th Asian-Pacific Corrosion Control Conf., Nov.1987, Melbourne, Australia.
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Xu, H., Hocking, M.G. & Sidky, P.S. Sulphidation-oxidation behavior of a Ni-Co-Cr-Si alloy in an SO2 + O2 atmosphere. Oxid Met 39, 371–388 (1993). https://doi.org/10.1007/BF00664662
Received:
Revised:
Issue Date:
DOI: https://doi.org/10.1007/BF00664662