Summary
Synthetic aviation turbine oils based on fatty acid tetraesters of pentaerythritol were investigated by gc-ms. The formation of specific ions by electron impact induced fragmentation is discussed using model compounds. Esterification of pentaerythritol with mixtures of fatty acids yields complex ester mixtures which can be separated by gas chromatography according to molecular size of the ester components. The separation of isomers is not successful. The identification of these components is possible by mass spectrometry. It is shown that the structure of the ester components can be determined extensively by direct gc-ms of the oils. Additional information is obtained by determination of the quantitative fatty acid composition of the oils and calculation of the possible ester combinations. The method is illustrated using a commercial aviation turbine oil.
Zusammenfassung
Synthetische Flugturbinenöle auf Basis von FettsÄuretetraestern des Pentaerythrits wurden mittels Gaschromatographie — Massenspektrometrie untersucht. Die Entstehung strukturspezifischer Ionen bei der elektronensto\induzierten Fragmentierung wird anhand einiger Modellester diskutiert. Werden FettsÄuregemische mit Pentaerythrit verestert, dann entstehen komplexe Gemische, die gas-chromatographisch nach der Molmasse der Esterkomponenten getrennt werden können. Die Auftrennung isomerer Esterkomponenten gelingt nicht. Die Identifizierung dieser Komponenten kann massenspektrometrisch erfolgen. Es wird gezeigt, da\ durch direkte GC-MS der öle die Struktur der vorliegenden Esterkomponenten weitgehend ermittelt werden kann. ZusÄtzliche Informationen werden durch Bestimmung der quantitativen FettsÄurezusammensetzung der öle und Berechnung der möglichen Esterkombinationen erhalten. Die Methode wird an einem handelsüblichen Flugturbinenöl erlÄutert.
Similar content being viewed by others
Literatur
Abel, H., Rehm, H. G.: Hochschule der Bundeswehr München FB Luft- und Raumfahrttechnik WE Chemie
Barnes, R. S., Fainman, M. Z.: Lubrication Eng. 13, 454 (1957)
Byford, D. C., Edgington, P. G.: Erdöl u. Kohle 22, 694 (1969)
Ciba-Geigy (UK): Techn. Service Bull. LU 1.2
Dorn, H.-D.: Schmiertechn. Tribologie 17, 32 (1970)
Gunderson, R. C., Hart, A. W.: Synthetic Lubricants, Reinhold, N. Y. 1962
Niedzielski, E. L.: Ind. Eng. Chem., Prod. Res. Dev. 15, 54 (1976)
Ranney, M. W.: Synthetic Lubricants 1972. Noyes Data Corp., Park Ridge 1972
Ranney, M. W.: Synthetic Oil and Greases for Lubricants 1976, Noyes Data Corp., Park Ridge 1976
Robson, R.: Ind. Lubric. Tribol. 23, 7 (1971)
Robson, R.: AGARD Aircraft Fuels, Lubricants and Fire Safety, 28-1, Aug 1971
Schlunegger, U. P.: Angew. Chem. 87, 731 (1975)
Sniegoski, P. J.: ASLE Trans. 12, 273 (1969)
Zeman, A., Bartl, P., Schaaff, A.: a) J. Org. Mass. Spectrom. (im Druck); b, c) Fette, Seifen, Anstrichm. (im Druck)
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Zeman, A., Bartl, P., Schaaff, A. et al. Analyse synthetischer Flugturbinenöle durch Gas-Chromatographie — Massenspektrometrie. Z. Anal. Chem. 290, 21–28 (1978). https://doi.org/10.1007/BF00468857
Received:
Issue Date:
DOI: https://doi.org/10.1007/BF00468857