Abstract
In the CH3SiCl3-H2 CVD system, from which SiC-based films are prepared, the supersaturation of the gas phase increases when temperature and total pressure decreases and when a diffusion-controlled kinetic process is changed in a reaction-controlled one. These conditions variations seem to induce a transition from a growth regime to a nucleation regime, as evidenced by a study of the initial stages of the deposition. A transition from a crystallized film with columnar crystals to a nanocrystalline deposit is also reported on the basis of accurate experiments using TEM and related techniques.
Similar content being viewed by others
References
T. Hirai and M. Sasaki, in “Silicon Carbide Ceramics-1”, edited by S. Somiya and Y. Inomata (Elsevier Science Publishers, London, New York, 1991) p. 77.
R. Naslain and F. Langlais, in “Tailoring Multiphase and Composite Ceramics”, edited by R. E. Tressler, G. L. Messing, G. G. Pantano and R. E. Newnham (Plenum Publishing Corporation, 1986) p. 145.
J. Schlichting, Powder Metall. Int. 12 3 (1980) 141 and 12 4 (1980) 196.
W. F. Knippenberg, Philips Res. Repts. 18 (1963) 161.
S. Hotojima, H. Vagi and N. Iwamosi, J. Mater. Sci. Lett. 5 (1986) 13.
J. Bloem, Acta Electronica 21 3 (1978) 201.
W. A. P. Claassen and J. Bloem, J. Electrochem. Soc. 127 (1980) 194.
idem, ibid. 127 (1980) 1336.
idem, ibid. 128 (1980) 1353.
J. Bloem, J. Crystal Growth 50 (1980) 581.
F. Hottier and R. Cadoret, J. Crystal Growth 52 (1981) 199.
J. Chin, P. K. Gantzel and R. G. Hudson, Thin Solid Films 40 (1977) 57.
R. Pampuch and L. Stobierski, Ceramurgia Int. 3 2 (1977) 43.
F. Sibieude and G. Benezech. J. Mater. Sci. 23 (1988) 1632.
R. Cadoret, in “Current Topics in Materials Science”, edited by E. Kaldis (North-Holland, Amsterdam, 1980) ch. 2.
c. prebende, Thesis no. 347, University of Bordeaux (1989).
F. Loumagne, F. Langlais and R. Naslain, J. le Physique IV, 3/C3 (1993) 527.
F. Langlais, F. Hottier and R. Cadoret, J. Crystal Growth 56 (1982) 659.
F. Langlais and C. Prebende, in Proceedings of Eleventh International Conference on CVD, Seattle, October 1990, edited by K. E. Spear and G. W. Cullen (The Electrochem, Society, Pennington, 1990) p. 686.
H. Poppa, J. Appl. Phys. 38 10 (1967) 3883.
M. Giso and J. Chun, J. Vac. Sci. Technol. A 6 1 (1988) 5.
K. A. Jacobson, J. Electrochem. Soc. 118 6 (1971) 1001.
K. Minato and K. Fukuda, J. Mater. Sci. 23 (1988) 699.
P. Tsui and K. E. Spear, Mat. Sci. Res. 17 (1984) 37.
S. Prouhet, F. Langlais, A. Guette, R. Naslain and J. Rey, Eur. J. Solid State Inorg. Chem. 30 (1993) 953.
Von M. Horstmann and G. Meyer, Acta Cryst. 15 (1962) 271.
D. Lespiaux, F. Langlais, R. Naslain, S. Schamm and J. Sevely, J. Europ. Ceram. Soc. (in press).
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Lespiaux, D., Langlais, F., Naslain, R. et al. Correlations between gas phase supersaturation, nucleation process and physico-chemical characteristics of silicon carbide deposited from Si-C-H-Cl system on silica substrates. Journal of Materials Science 30, 1500–1510 (1995). https://doi.org/10.1007/BF00375255
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/BF00375255