Abstract
The cyclic deformation behaviour of an aluminium matrix composite reinforced with 16% Vf silicon carbide whiskers was studied. The microstructures were designed so that different precipitates existed in the composite. The results indicated that the SiCw/6061 Al composite demonstrated cyclic hardening, however the cyclic response stresses and the cyclic hardening tendency were different under differing ageing conditions. Lower cyclic response stresses and higher hardening tendencies were found under natural ageing conditions, while higher cyclic response stresses and lower hardening tendencies were obtained under artificial ageing conditions. The higher the cyclic response stresses following artificial ageing, the lower the hardening tendencies that reduced fatigue life. The effects of microstructures on the cyclic deformation behaviour of the composite were examined under the TEM and changes in microstructure caused by the cyclic deformation were observed.
Similar content being viewed by others
References
R. J. LEDERICH and S. M. L. SASTRY, Mater. Sci. Eng. 2 (1982) 143.
W. R. MOHN and D. VUKOBRATOVICH, SAMPE J. 24 (1988) 26.
Z. Y. MA and C. K. YAO, Mater. Chem. Phys. 25 (1990) 463.
J. M. PAPAZIAN and P. N. ADLER, Metall. Trans. A 21A (1990) 411.
C. R. CROWE and D. F. HASSON, Proceedings of Strength of Metals and Alloys, Melbourne, Australia (1982) p. 859.
D. R. WILLIAMS and M. E. FINE, Proceedings, of the 5th ICCM, USA (1985) 639.
W. A. LOGSDON and P. K. LIAW, Eng. Fract. Mech. 24 (1986) 737.
C. MASUDA and Y. TANAKA, Tetsu-To-Hagane 9 (1989) 339.
S. J. HARRIS and G. YI, Proceedings of the 7th ICCM, Guangzhou, People's Republic of China (1989) 659.
J. LIU, D. Z. WANG, C. K. YAO, W. C. YU and Z. G. WANG, J. Mater. Sci. Lett. 11 (1992) 970.
M. H. JACOBS, Phil. Mag. 26 (1972) 1.
P. K. LIAW, J. G. GREGGL and W. A. LOGSDON, J. Mater. Sci. 22 (1987) 1613.
M. VOGELSANG, R. J. ARSENAULT and R. M. FISHER, Metall. Trans. A 17A (1986) 379.
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Wang, D.Z., Liu, J., Yao, C.K. et al. Effects of microstructures on the cyclic deformation behaviour of SiCw/AI composite. Journal of Materials Science 30, 3561–3566 (1995). https://doi.org/10.1007/BF00349911
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/BF00349911