Abstract
The effects of nitrogen (N), phosphorus (P), zinc (Zn) or iron (Fe) limitations on lipid and especially α-linolenic acid (ALA) synthesis in the oleaginous yeast Rhodotorula glutinis have been investigated. Exhaustion of the limiting element in the medium resulted in an enhancement of both the fatty acid cell content (FA/X) and the corresponding productivity. Except for Fe-limited media, lipid accumulation was always coupled with an increase in the yield of ALA synthesis, whereas in all the limiting conditions the productivity of ALA declined. Kinetic investigations showed that this decline resulted from a sharp decrease in the specific rates of ALA synthesis associated with slowing down of growth. A comparative study showed that the highest yields and specific rates of fatty acid and ALA synthesis were induced by P-limitation early in the lipid accumulation phase. However, above a FA/X of 15%, N-limiting conditions become more attractive for producing lipids. During P-limited growth a down-shift of temperature from 30° C to 25° C was shown ao reduce the range of FA/X values at which the specific rate of fatty acid synthesis was maximal but without any other effect on fatty acid formation. In contrast, the decreased temperature resulted in enhanced ALA production by maintaining the specific rate of synthesis near to the maximal value of 3.6 mg g −1X h−1, where X* is free fatty acid biomass, and increased the corresponding yield by a factor of up to three.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Choi SY, Ryu DY, Rhee JS (1982) Effects of growth rate and oxygen on lipid synthesis and fatty acid composition of Rhodotorula gracilis. Biotechnol Bioeng 14:1165–1172
Citharel B, Oursel A, Mazliak P (1983) Desaturation of oleoyl and linoleoyl residues linked to phospholipids in growing roots of yellow lupin. FEBS 161:251–256
Davies RJ (1988) Yeast oil from cheese whey — process development. In: Moreton RS (ed) Single cell oil. Longman, London, pp 99–143
Egli T, Fiechter A (1981) Theoretical analysis of media used in the growth of yeasts on methanol. J Gen Microbiol 123:365–369
Evans CT, Ratledge C (1983) Biochemical activities during lipid accumulation in Candida curvata. Lipids 18:630–635
Ferrante G, Kates M (1983) Pathways for desaturation of oleoyl chains in Candida lypolitica. Can J Biochem Cell Biol 61:1191–1196
Ferrante G, Ohno Y, Kates M (1983) Influence of temperature and growth phase on desaturase activity of the mesophilic yeast Candida lypolitica. Can J Biochem Cell Biol 61:171–177
Gill CO, Hall MJ, Ratledge C (1977) Lipid accumulation in oleaginous yeast Candida 107 growing on glucose on a single stage continuous culture. Appl Environ Microbiol 33:231–239
Granger L-M, Perlot P, Goma G, Pareilleux A (1992) Kinetics of growth and fatty acid production of Rhodotorula glutinis. Appl Microbiol Biotechnol 37:13–17
Hammond EG, Glatz BA, Choi Y, Teasdale MT (1981) Oil production by Candida curvata and extraction, composition and properties of the oil. In: Pride EH, Princen LH, Mukerjee KD (eds) New sources of fats and oils (monograph 9). American Oil Chemists' Society, Champaign, Ill., pp 171–187
Hansson L, Dostàlek M (1988) Effects of culture conditions on mycelial growth and production of gamma-linolenic acid by the fungus Mortierella ramanniana. Appl Microbiol Biotechnol 28:240–246
Halloway PW, Katz JT (1972) A requirement for cytochrome b in microsomal stearyl-CoA desaturation. Biochemistry 11:1689–1695
Kendrick A, Ratledge C (1992) Lipid formation in the oleaginous mould Entomophtora exitalis grown in continuous culture: effects of growth rate, temperature and dissolved oxygen tension on polyunsaturated fatty acids. Appl Microbiol Biotechnol 37:18–22
Pan JG, Rhee JS (1986) Kinetic and energetic analysis of lipid accumulation in batch culture of Rhodotorula glutinis. J Ferment Technol 6:557–560
Ratledge C (1982) Microbial oils and fats: an assessment of their commercial potential. Prog Ind Microbiol 16:119–206
Ratledge C (1988) Biochemistry, stoechiometry, substrates and economics. In: Moreton RS (ed) Single cell oil. Longman, London, pp 33–70
Rolph CE, Moreton RS, Harwood JL (1989) Acyl lipid metabolism in the oleaginous yeast Rhodotorula gracilis (CBS 3043). Lipids 24:715–720
Yamauchi H, Mori H, Kobayashi T, Shimizu S (1983) Mass production of lipids by Lipomyces starkeyi in microcomputer-aided fed-batch culture. J Ferment Technol 61:275–280
Author information
Authors and Affiliations
Additional information
Correspondence to: A. Pareilleux
Rights and permissions
About this article
Cite this article
Granger, LM., Perlot, P., Goma, G. et al. Effect of various nutrient limitations on fatty acid production by Rhodotorula glutinis . Appl Microbiol Biotechnol 38, 784–789 (1993). https://doi.org/10.1007/BF00167145
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/BF00167145