Advertisement

Efficient methane production from petrochemical wastewater in a single membrane-less microbial electrolysis cell: the effect of the operational parameters in batch and continuous mode on bioenergy recovery

  • Amin Arvin
  • Morteza HosseiniEmail author
  • Mohammad Mehdi Amin
  • Ghasem Najafpour Darzi
  • Younes Ghasemi
Research Article
  • 8 Downloads

Abstract

The main objective of this study is to evaluate the treatment and simultaneous production of methane from low-strength petrochemical wastewater by single membrane-less microbial electrolysis cells. To achieve this objective, the influence of variables such as applied voltage, operation mode, and hydraulic retention time (HRT) on the performance of the MEC system was investigated over a period of 110 days. According to the obtained results, the maximum COD removal efficiency in the batch mode was higher than which in the continuous mode (i.e. 85.9% vs 75.3%). However, the maximum methane production in the continuous mode was almost 1.6 times higher than which in the batch mode. The results show, COD removal, methane content, and methane production in both operation modes, were enhanced as applied voltage increased from 0.6 to 0.8-1 V. The proportion of methane, methane production rate, and COD removal were increased as HRT decreased from 72 to 48 h, while these values were decreased as the HRT decreased from 48 to 12 h. In continues mode, the energy efficiency had a range of 94.7% to 97.9% with an average of 96.6% in phase III, which almost recovered all of the electrical energy input into the system. These results suggest that single membrane-less microbial electrolysis cell is a promising process in order to the treatment of low-strength wastewater and methane production.

Keywords

Microbial electrolysis cell Treatment Petrochemical wastewater Methane production Bioenergy 

Notes

Acknowledgments

The authors would like to acknowledge the financial support provided by Babol Noshirvani University of Technology (BNUT/935150002/95). Also, this study was financially supported by the Biotechnology Development Council of the Islamic Republic of Iran [grant numbers: 960103].

Compliance with ethical standards

Conflict of interest

The authors would like to declare that there is no conflict of interest with this research and in the publication.

References

  1. 1.
    Zhang H, He Y, Jiang T, Yang F. Research on characteristics of aerobic granules treating petrochemical wastewater by acclimation and co-metabolism methods. Desalination. 2011;279(1–3):69–74.CrossRefGoogle Scholar
  2. 2.
    Yeruva DK, Jukuri S, Velvizhi G, Kumar AN, Swamy Y, Mohan SV. Integrating sequencing batch reactor with bio-electrochemical treatment for augmenting remediation efficiency of complex petrochemical wastewater. Bioresour Technol. 2015;188:33–42.CrossRefGoogle Scholar
  3. 3.
    Ebrahimi M, Kazemi H, Mirbagheri S, Rockaway TD. An optimized biological approach for treatment of petroleum refinery wastewater. J Environ Chem Eng. 2016;4(3):3401–8.CrossRefGoogle Scholar
  4. 4.
    Hoseinzadeh E, Rezaee A, Farzadkia M. Nitrate removal from pharmaceutical wastewater using microbial electrochemical system supplied through low frequency-low voltage alternating electric current. Bioelectrochemistry. 2018;120:49–56.CrossRefGoogle Scholar
  5. 5.
    Arvin A, Peyravi M, Jahanshahi M, Salmani H. Hydrodynamic evaluation of an anaerobic baffled reactor for landfill leachate treatment. Desalin Water Treat. 2016;57(42):19596–608.CrossRefGoogle Scholar
  6. 6.
    Arvin A, Peyravi M, Jahanshahi M. Fabrication and Evaluation of anaerobic baffle reactor for leachate treatment of Sari province 2017;19(74):159–171.Google Scholar
  7. 7.
    Jafary T, Daud WRW, Ghasemi M, Kim BH, Jahim JM, Ismail M, et al. Biocathode in microbial electrolysis cell; present status and future prospects. Renew Sust Energ Rev. 2015;47:23–33.CrossRefGoogle Scholar
  8. 8.
    Guo X, Liu J, Xiao B. Bioelectrochemical enhancement of hydrogen and methane production from the anaerobic digestion of sewage sludge in single-chamber membrane-free microbial electrolysis cells. Int J Hydrog Energy. 2013;38(3):1342–7.CrossRefGoogle Scholar
  9. 9.
    Hoseinzadeh E, Rezaee A, Farzadkia M. Low frequency-low voltage alternating electric current-induced anoxic granulation in biofilm-electrode reactor: a study of granule properties. Process Biochem. 2017;56:154–62.CrossRefGoogle Scholar
  10. 10.
    Kadier A, Kalil MS, Abdeshahian P, Chandrasekhar K, Mohamed A, Azman NF, et al. Recent advances and emerging challenges in microbial electrolysis cells (MECs) for microbial production of hydrogen and value-added chemicals. Renew Sust Energ Rev. 2016;61:501–25.CrossRefGoogle Scholar
  11. 11.
    Gulhane M, Khardenavis AA, Karia S, Pandit P, Kanade GS, Lokhande S, et al. Biomethanation of vegetable market waste in an anaerobic baffled reactor: effect of effluent recirculation and carbon mass balance analysis. Bioresour Technol. 2016;215:100–9.CrossRefGoogle Scholar
  12. 12.
    Sangeetha T, Guo Z, Liu W, Cui M, Yang C, Wang L, et al. Cathode material as an influencing factor on beer wastewater treatment and methane production in a novel integrated upflow microbial electrolysis cell (Upflow-MEC). Int J Hydrog Energy. 2016;41(4):2189–96.CrossRefGoogle Scholar
  13. 13.
    Baek G, Kim J, Lee S, Lee C. Development of biocathode during repeated cycles of bioelectrochemical conversion of carbon dioxide to methane. Bioresour Technol. 2017;241:1201–7.CrossRefGoogle Scholar
  14. 14.
    Heidrich ES, Edwards SR, Dolfing J, Cotterill SE, Curtis TP. Performance of a pilot scale microbial electrolysis cell fed on domestic wastewater at ambient temperatures for a 12 month period. Bioresour Technol. 2014;173:87–95.CrossRefGoogle Scholar
  15. 15.
    Escapa A, San-Martín M, Mateos R, Morán A. Scaling-up of membraneless microbial electrolysis cells (MECs) for domestic wastewater treatment: bottlenecks and limitations. Bioresour Technol. 2015;180:72–8.CrossRefGoogle Scholar
  16. 16.
    Moreno R, San-Martín M, Escapa A, Morán A. Domestic wastewater treatment in parallel with methane production in a microbial electrolysis cell. Renew Energy. 2016;93:442–8.CrossRefGoogle Scholar
  17. 17.
    Wang Y, Guo W-Q, Xing D-F, Chang J-S, Ren N-Q. Hydrogen production using biocathode single-chamber microbial electrolysis cells fed by molasses wastewater at low temperature. Int J Hydrog Energy. 2014;39(33):19369–75.CrossRefGoogle Scholar
  18. 18.
    Carmona-Martínez AA, Trably E, Milferstedt K, Lacroix R, Etcheverry L, Bernet N. Long-term continuous production of H2 in a microbial electrolysis cell (MEC) treating saline wastewater. Water Res. 2015;81:149–56.CrossRefGoogle Scholar
  19. 19.
    Shen R, Liu Z, He Y, Zhang Y, Lu J, Zhu Z, et al. Microbial electrolysis cell to treat hydrothermal liquefied wastewater from cornstalk and recover hydrogen: degradation of organic compounds and characterization of microbial community. Int J Hydrog Energy. 2016;41(7):4132–42.CrossRefGoogle Scholar
  20. 20.
    Ren L, Siegert M, Ivanov I, Pisciotta JM, Logan BE. Treatability studies on different refinery wastewater samples using high-throughput microbial electrolysis cells (MECs). Bioresour Technol. 2013;136:322–8.CrossRefGoogle Scholar
  21. 21.
    Tenca A, Cusick RD, Schievano A, Oberti R, Logan BE. Evaluation of low cost cathode materials for treatment of industrial and food processing wastewater using microbial electrolysis cells. Int J Hydrog Energy. 2013;38(4):1859–65.CrossRefGoogle Scholar
  22. 22.
    APhA A. WEF (American public health association, American Water Works Association, and water environment federation). 1998. Standard methods for the examination of water and wastewater 1998;19.Google Scholar
  23. 23.
    Eaton AD, Clesceri LS, Greenberg AE, Franson MAH. Standard methods for the examination of water and wastewater. American public health association. 2005;1015:49–51.Google Scholar
  24. 24.
    Logan BE. Microbial fuel cells. Wiley 2008.Google Scholar
  25. 25.
    Cai W, Liu W, Yang C, Wang L, Liang B, Thangavel S, et al. Biocathodic methanogenic community in an integrated anaerobic digestion and microbial electrolysis system for enhancement of methane production from waste sludge. ACS Sustain Chem Eng. 2016;4(9):4913–21.CrossRefGoogle Scholar
  26. 26.
    Yossan S, Xiao L, Prasertsan P, He Z. Hydrogen production in microbial electrolysis cells: choice of catholyte. Int J Hydrog Energy. 2013;38(23):9619–24.CrossRefGoogle Scholar
  27. 27.
    De Vrieze J, Gildemyn S, Arends JB, Vanwonterghem I, Verbeken K, Boon N, et al. Biomass retention on electrodes rather than electrical current enhances stability in anaerobic digestion. Water Res. 2014;54:211–21.CrossRefGoogle Scholar
  28. 28.
    Jourdin L, Grieger T, Monetti J, Flexer V, Freguia S, Lu Y, et al. High acetic acid production rate obtained by microbial electrosynthesis from carbon dioxide. Environ Sci Technol. 2015;49(22):13566–74.CrossRefGoogle Scholar
  29. 29.
    Elreedy A, Tawfik A, Kubota K, Shimada Y, Harada H. Hythane (H2+ CH4) production from petrochemical wastewater containing mono-ethylene glycol via stepped anaerobic baffled reactor. Int Biodeterior Biodegrad. 2015;105:252–61.CrossRefGoogle Scholar
  30. 30.
    Ren L, Ahn Y, Hou H, Zhang F, Logan BE. Electrochemical study of multi-electrode microbial fuel cells under fed-batch and continuous flow conditions. J Power Sources. 2014;257:454–60.CrossRefGoogle Scholar
  31. 31.
    Koch C, Popiel D, Harnisch F. Functional redundancy of microbial anodes fed by domestic wastewater. ChemElectroChem. 2014;1(11):1923–31.CrossRefGoogle Scholar
  32. 32.
    Zhao Z, Zhang Y, Quan X, Zhao H. Evaluation on direct interspecies electron transfer in anaerobic sludge digestion of microbial electrolysis cell. Bioresour Technol. 2016;200:235–44.CrossRefGoogle Scholar
  33. 33.
    Van Eerten-Jansen MC, Heijne AT, Buisman CJ, Hamelers HV. Microbial electrolysis cells for production of methane from CO2: long-term performance and perspectives. Int J Energy Res. 2012;36(6):809–19.CrossRefGoogle Scholar
  34. 34.
    Cusick RD, Logan BE. Phosphate recovery as struvite within a single chamber microbial electrolysis cell. Bioresour Technol. 2012;107:110–5.CrossRefGoogle Scholar
  35. 35.
    Wu T, Zhu G, Jha AK, Zou R, Liu L, Huang X, et al. Hydrogen production with effluent from an anaerobic baffled reactor (ABR) using a single-chamber microbial electrolysis cell (MEC). Int J Hydrog Energy. 2013;38(25):11117–23.CrossRefGoogle Scholar
  36. 36.
    Cai W, Han T, Guo Z, Varrone C, Wang A, Liu W. Methane production enhancement by an independent cathode in integrated anaerobic reactor with microbial electrolysis. Bioresour Technol. 2016;208:13–8.CrossRefGoogle Scholar
  37. 37.
    Hu H, Fan Y, Liu H. Hydrogen production using single-chamber membrane-free microbial electrolysis cells. Water Res. 2008;42(15):4172–8.CrossRefGoogle Scholar
  38. 38.
    O'Flaherty V, Mahony T, O'Kennedy R, Colleran E. Effect of pH on growth kinetics and sulphide toxicity thresholds of a range of methanogenic, syntrophic and sulphate-reducing bacteria. Process Biochem. 1998;33(5):555–69.CrossRefGoogle Scholar
  39. 39.
    Feng Y, Zhang Y, Chen S, Quan X. Enhanced production of methane from waste activated sludge by the combination of high-solid anaerobic digestion and microbial electrolysis cell with iron–graphite electrode. Chem Eng J. 2015;259:787–94.CrossRefGoogle Scholar
  40. 40.
    Yin Q, Zhu X, Zhan G, Bo T, Yang Y, Tao Y, et al. Enhanced methane production in an anaerobic digestion and microbial electrolysis cell coupled system with co-cultivation of Geobacter and Methanosarcina. J Environ Sci. 2016;42:210–4.CrossRefGoogle Scholar
  41. 41.
    Elreedy A, Tawfik A. Effect of hydraulic retention time on hydrogen production from the dark fermentation of petrochemical effluents contaminated with ethylene glycol. Energy Procedia. 2015;74:1071–8.CrossRefGoogle Scholar
  42. 42.
    Li Y, Zhang Y, Liu Y, Zhao Z, Zhao Z, Liu S, et al. Enhancement of anaerobic methanogenesis at a short hydraulic retention time via bioelectrochemical enrichment of hydrogenotrophic methanogens. Bioresour Technol. 2016;218:505–11.CrossRefGoogle Scholar

Copyright information

© Springer Nature Switzerland AG 2019

Authors and Affiliations

  • Amin Arvin
    • 1
  • Morteza Hosseini
    • 1
    Email author
  • Mohammad Mehdi Amin
    • 2
  • Ghasem Najafpour Darzi
    • 1
  • Younes Ghasemi
    • 3
  1. 1.Department of Chemical EngineeringBabol Noshirvani University of TechnologyBabolIran
  2. 2.Environmental Health Engineering DepartmentIsfahan University of Medical ScienceIsfahanIran
  3. 3.Department of Pharmaceutical BiotechnologyShiraz University of Medical SciencesShirazIran

Personalised recommendations