Advertisement

Optimization of operation conditions for biodiesel preparation from soybean oil using an electric field

  • Piyaphong Yongphet
  • Junfeng WangEmail author
  • Dongbao Wang
  • Christian Mulbah
  • Zhiheng Fan
  • Wei Zhang
  • Paulo C. S. Amaral
Original Article
  • 45 Downloads

Abstract

The acceleration of the biodiesel-glycerol separation has attracted the interest of many researchers in a quest to improve biodiesel production efficiency and reduce the overall production time. This has played a pivotal role in lowering the production cost and reducing the demand for other nonrenewable sources of energy. In the present study, the transesterification of soybean oil into biodiesel was done using methanol and sodium hydroxide (as a catalyst) under an applied electric field. Response surface methodology (RSM) via Box-Behnken design (BBD) was applied to evaluate the influences of transesterification response on the reaction parameters of biodiesel production. Analysis of variance (ANOVA) was adopted to investigate several parameters of the quadratic polynomial model. The optimum condition was found under an applied electric field of 5 kV at a catalyst concentration, molar ratio of methanol to oil, reaction temperature, and stirring rates of 1 wt.%, 6:1, 60 °C, and 450 rpm respectively. During the transesterification process, the biodiesel yield reached 96.85% within 180.0 s. This is a huge improvement as compared with the conventional biodiesel preparing method which takes more than 2 h to obtain similar biodiesel yield.

Keywords

Electric field Biodiesel Acceleration Soybean oil Optimization 

Notes

Funding information

This work was supported by the National Natural Science Foundation of China (51761145011). A special thanks to Prof. Dr. Tanongkiat Kiatsiriroat, Department of Mechanical Engineering, Faculty of Engineering, Chiang Mai University; for instructions to conduct this research.

References

  1. 1.
    Roschat W, Siritanon T, Yoosuk B, Promarak V (2016) Biodiesel production from palm oil using hydrated lime-derived CaO as a low-cost basic heterogeneous catalyst. Energy Convers Manag 108:459–467.  https://doi.org/10.1016/j.enconman.2015.11.036 CrossRefGoogle Scholar
  2. 2.
    Krishnamurthy KN, Sridhara SN, Kumar A (2020) Optimization and kinetic study of biodiesel production from Hydnocarpus wightiana oil and dairy waste scum using snail shell CaO nano catalyst. Renew Energy 146:280–296.  https://doi.org/10.1016/j.renene.2019.06.161 CrossRefGoogle Scholar
  3. 3.
    Linhares FN (2017) Development of biodiesel-resistant nitrile rubber compositions. Hanser Publishers, Munich, pp 26–28.  https://doi.org/10.3139/9781569906750 CrossRefGoogle Scholar
  4. 4.
    Sangeeta MS, Pande M, Rani M, Gakhar R (2014) Alternative fuels: an overview of current trends and scope for future. Renew Sust Energ Rev 32:697–712.  https://doi.org/10.1016/j.rser.2014.01.023 CrossRefGoogle Scholar
  5. 5.
    Rahimi M, Aghel B, Alitabar M, Sepahvand A, Ghasempou HR (2014) Optimization of biodiesel production from soybean oil in a microreactor. Energy Convers Manag 79:599–605.  https://doi.org/10.1016/j.enconman.2013.12.065 CrossRefGoogle Scholar
  6. 6.
    Zabeti M, Wan-Daud WMA, Aroua MK (2009) Activity of solid catalysts for biodiesel production: a review. Fuel Process Technol 90:770–777.  https://doi.org/10.1016/j.fuproc.2009.03.010 CrossRefGoogle Scholar
  7. 7.
    Bozbas K (2008) Biodiesel as an alternative motor fuel: production and policies in the European Union. Renew Sust Energ Rev 12:542–552.  https://doi.org/10.1016/j.rser.2005.06.001 CrossRefGoogle Scholar
  8. 8.
    Franjo M, Šalić A, Zelić B (2018) Microstructured devices for biodiesel production by transesterification. Biomass Convers Bior 8:1005–1020.  https://doi.org/10.1007/s13399-018-0341-7 CrossRefGoogle Scholar
  9. 9.
    Sajid Z, Khan F, Zhang Y (2016) Process simulation and life cycle analysis of biodiesel production. Renew Energy 85:945–952.  https://doi.org/10.1016/j.renene.2015.07.046 CrossRefGoogle Scholar
  10. 10.
    Pitt FD, Domingos AM, Barros AAC (2019) Purification of residual glycerol recovered from biodiesel production. South African Journal of Chemical Engineering 29:42–51.  https://doi.org/10.1016/j.sajce.2019.06.001 CrossRefGoogle Scholar
  11. 11.
    Chen G, Shan R, Shi J, Liu C, Yan B (2015) Biodiesel production from palm oil using active and stable K doped hydroxyapatite catalysts. Energy Convers Manag 98:463–469.  https://doi.org/10.1016/j.enconman.2015.04.012 CrossRefGoogle Scholar
  12. 12.
    Sajjadi B, Raman AAA, Arandiyan H (2016) A comprehensive review on properties of edible and non-edible vegetable oil-based biodiesel: composition, specifications and predictionmodels. Renew Sust Energ Rev 63:62–92.  https://doi.org/10.1016/j.rser.2017.09.080 CrossRefGoogle Scholar
  13. 13.
    Silitonga AS, Masjuki HH, Mahlia TMI, Ong HC, Chong WT, Boosroh MH (2013) Over view properties of biodiesel diesel blends from edible and non-edible feedstock. Renew Sust Energ Rev 22:346–360.  https://doi.org/10.1016/j.rser.2013.01.055 CrossRefGoogle Scholar
  14. 14.
    Yin X, Duan X, You Q, Dai C, Tan Z, Zhu X (2016) Biodiesel production from soybean oil deodorizer distillate using calcined duck eggshell as catalyst. Energy Convers Manag 112:199–207.  https://doi.org/10.1016/j.enconman.2016.01.026 CrossRefGoogle Scholar
  15. 15.
    Atabani AE, Silitonga AS, Anjum BI, Mahlia TMI, Masjuki HH, Mekhilef S (2012) A comprehensive review on biodiesel as an alternative energy resource and its characteristics. Renew Sust Energ Rev 4:2070–2093.  https://doi.org/10.1016/j.rser.2012.01.003 CrossRefGoogle Scholar
  16. 16.
    Ullah F, Dong L, Bano A, Peng Q, Huang J (2016) Current advances in catalysis toward sustainable biodiesel production. J Energy Inst 89:282–292.  https://doi.org/10.1016/j.joei.2015.01.018 CrossRefGoogle Scholar
  17. 17.
    Baroutian S, Aroua MK, Raman AAA, Sulaiman NMN (2008) Density of palm oil-based methyl ester. J Chem Eng Data 53:877–880.  https://doi.org/10.1021/je700682d CrossRefGoogle Scholar
  18. 18.
    Soriano JN, Venditti R, Argyropoulos D (2009) Biodiesel synthesis via homogeneous Lewis acid-catalyzed transesterification. Fuel 88:560–565.  https://doi.org/10.1016/j.fuel.2008.10.013 CrossRefGoogle Scholar
  19. 19.
    Maceiras R, Vega M, Costa C, Ramos P, Márquez MC (2011) Enzyme deactivation during biodiesel production. Chem Eng J 166(1):358–361.  https://doi.org/10.1016/j.cej.2010.11.007 CrossRefGoogle Scholar
  20. 20.
    Fadhil AB, Aziz AM, Al-Tamer MH (2016) Biodiesel production from Silybum marianum L. seed oil with high FFA content using sulfonated carbon catalyst for esterification and base catalyst for transesterification. Energy Convers Manag 108:255–265.  https://doi.org/10.1016/j.enconman.2015.11.013 CrossRefGoogle Scholar
  21. 21.
    Hayyan M, Mjalli FS, Hashim MA, AlNashef IM (2010) A novel technique for separating glycerine from palm oil-based biodiesel using ionic liquids. Fuel Process Technol 91:116–120.  https://doi.org/10.1016/j.fuproc.2009.09.002 CrossRefGoogle Scholar
  22. 22.
    Abbaszadeh A, Ghobadian B, Najafi G (2013) High voltage/low amperage current for separation of crude glycerin from biodiesel. Adv Environ Biol 7(13):4028–4031.  https://doi.org/10.4028/www.scientific.net/KEM.599.319 CrossRefGoogle Scholar
  23. 23.
    Shirazi MMA, Kargari A, Tabatabaei M, Mostafaeid B, Akia M, Barkhi M, Shirazi MJA (2013) Acceleration of biodiesel–glycerol decantation through NaCl-assisted gravitational settling: a strategy to economize biodiesel production. Bioresour Technol 134:401–406.  https://doi.org/10.1016/j.biortech.2013.02.026 CrossRefGoogle Scholar
  24. 24.
    Tabatabaei M, Aghbashlo M, Dehhaghi M, Panahi HKS, Mollahosseini A, Hosseini M, Soufiyan MM (2019) Reactor technologies for biodiesel production and processing: a review. Prog Energy Combust Sci 74:239–303.  https://doi.org/10.1016/j.pecs.2019.06.001 CrossRefGoogle Scholar
  25. 25.
    Günay ME, Türker L, Tapan NA (2019) Significant parameters and technological advancements in biodiesel production systems. Fuel 250:27–41.  https://doi.org/10.1016/j.fuel.2019.03.147 CrossRefGoogle Scholar
  26. 26.
    Joshi S, Gogate PR, Moreira PF, Giudici R (2017) Intensification of biodiesel production from soybean oil and waste cooking oil in the presence of heterogeneous catalyst using high speed homogenizer. Ultrason Sonochem 39:645–653.  https://doi.org/10.1016/j.ultsonch.2017.05.029 CrossRefGoogle Scholar
  27. 27.
    Rahimi M, Aghel B, Alitabar M, Sepahvand A, Ghasempour HR (2014) Optimization of biodiesel production from soybean oil in a microreactor. Energy Convers Manag 79:599–605.  https://doi.org/10.1016/j.enconman.2013.12.065 CrossRefGoogle Scholar
  28. 28.
    Saber M, Golzary A, Wu H, Takahashi F, Yoshikawa K (2017) Ultrasonic pretreatment for low-temperature hydrothermal liquefaction of microalgae: enhancing the bio-oil yield and heating value. Biomass Conv Bioref 8:509–519.  https://doi.org/10.1007/s13399-017-0300-8 CrossRefGoogle Scholar
  29. 29.
    Susumu R, Yusi S (2018) Biodiesel production from waste cooking oil using electrostatic method. Indonesian Journal Fundamental and Applied Chemistry 3(3):71–76.  https://doi.org/10.24845/ijfac.v3.i3.71 CrossRefGoogle Scholar
  30. 30.
    Wang D, Wang J, Liu H, Huo Y, Hu W (2019) Reaction kinetics of waste cooking oil transesterification under electric field. Waste Biomass Valori 1–10.  https://doi.org/10.1007/s12649-019-00673-2
  31. 31.
    Montgomery DC (2012) Design and analysis of experiments. Wiley, New YorkGoogle Scholar
  32. 32.
    Yücel Y (2012) Optimization of biocatalytic biodiesel production from pomace oil using response surface methodology. Fuel Process Technol 99:97–102.  https://doi.org/10.1016/j.fuproc.2012.02.008 CrossRefGoogle Scholar
  33. 33.
    Ahmad T, Danish M, Kale P, Geremew B, Adeloju SB, Nizami M, Ayoub M (2019) Optimization of process variables for biodiesel production by transesterification of flaxseed oil and produced biodiesel characterizations. Renew Energy 139:1272–1280.  https://doi.org/10.1016/j.renene.2019.03.036 CrossRefGoogle Scholar
  34. 34.
    Pitt FD, Domingos AM, Chivanga Barros AA (2019) Purification of residual glycerol recovered from biodiesel production. S Afr J Chem Eng 29:42–51.  https://doi.org/10.1016/j.sajce.2019.06.001 CrossRefGoogle Scholar
  35. 35.
    Guan X, Yao H (2008) Optimization of viscozyme L-assisted extraction of oat bran protein using response surface methodology. Food Chem 106(1):345–351.  https://doi.org/10.1016/j.foodchem.2007.05.041 CrossRefGoogle Scholar
  36. 36.
    Al-Sakkari EG, El-Sheltawy ST, Abadir MF, Attia NK, El-Diwani G (2016) Investigation of cement kiln dust utilization for catalyzing biodiesel production via response surface methodology. Int J Energy Res 41:593–603.  https://doi.org/10.1002/er.3635 CrossRefGoogle Scholar
  37. 37.
    Montgomery DC (2000) Design and analysis of experiments, 5th edition Wiley, New York Ch.6, Ch.8 and Ch.11Google Scholar
  38. 38.
    Chuah LF, Bokhari A, Yusup S, Klemeš JJ, Akbar MM, Saminathan S (2017) Optimisation on pretreatment of kapok seed (Ceiba pentandra) oil via esterification reaction in an ultrasonic cavitation reactor. Biomass Conv Bioref 7:91–99.  https://doi.org/10.1007/s13399-016-0207-9 CrossRefGoogle Scholar
  39. 39.
    Onukwuli DO, Emembolu LN, Ude CN, Aliozo SO, Menkiti MC (2016) Optimization of biodiesel production from refined cotton seed oil and its characterization. Egypt J Pet 26:103–110.  https://doi.org/10.1016/j.ejpe.2016.02.001 CrossRefGoogle Scholar
  40. 40.
    Yu GW, Nie J, Lu LG, Wang SP, Li ZG, Lee MR (2017) Transesterification of soybean oil by using the synergistic microwave-ultrasonic irradiation. Ultrason Sonochem 39:281–290.  https://doi.org/10.1016/j.ultsonch.2017.04.036 CrossRefGoogle Scholar
  41. 41.
    Stavarache C, Vinatoru M, Maeda Y, Bandow H (2007) Ultrasonically driven continuous process for vegetable oil transesterification. Ultrason Sonochem 14:413–417.  https://doi.org/10.1016/j.ultsonch.2006.09.014 CrossRefGoogle Scholar
  42. 42.
    Barnard TM, Nicholas EL, Matthew BB, Lauren MS, Benjamin AW (2007) Continuous flow preparation of biodiesel using microwave heating. Energy Fuel 21:1777–1781.  https://doi.org/10.1021/ef0606207 CrossRefGoogle Scholar
  43. 43.
    Kurniati S, Soeparman S, Yuwono SS, Hakim L, Syam S (2019) A novel process for production of calophyllum inophyllum biodiesel with electromagnetic induction. Energies 12(3):383.  https://doi.org/10.3390/en12030383 CrossRefGoogle Scholar

Copyright information

© Springer-Verlag GmbH Germany, part of Springer Nature 2020

Authors and Affiliations

  1. 1.School of Energy and Power EngineeringJiangsu UniversityZhenjiangChina

Personalised recommendations