Advertisement

Journal of Food Science and Technology

, Volume 56, Issue 4, pp 2038–2048 | Cite as

The potential of the iron concentrated germinated wheat in wheat flour fortification: an alternative to the conventional expensive iron fortification

  • J. K. Naveen Kumar
  • S. P. Muthukumar
  • P. PrabhasankarEmail author
Original Article
  • 32 Downloads

Abstract

Investigation of the effect of the Fe abiotic stress on the germination rate, iron accumulation, root and shoot elongation of wheat (Triticum aestivum) was carried out. The grains were exposed to different experimental concentrations of ferrous sulfate (FeSO4) (0–15 mM). The effect of the treatment on the shoot and root elongation of the seeds were reported. There is a linear relationship between the treatment and the inhibition of shoot elongation. The half-inhibition dose (ID50) of FeSO4 on inhibition of shoot elongation was 7.3 mM. Each treatment groups (3–15 mM) were used to fortify the wheat flour at 0.1 mg Fe/g. The effect of fortification on rheology (farinograph, extensograph, and amylograph), quality of pasta and iron bioavailability was studied. The pasta cooking properties, texture and sensory properties of 12 and 15 mM composite pasta were equally acceptable as wheat without fortification, or NaFeEDTA fortified pasta. The iron dialysability of 3–15 mM composite pasta was similar to the NaFeEDTA fortified pasta. The iron bioavailability (in vivo) of 15 mM group based pasta was evaluated in the anemic rats. The pasta at 4% (Fe 0.026 mg/g) in iron-deficient diet fed to anemic rats for 2 weeks showed percentage iron absorption (PIA) and hemoglobin regeneration efficiency (HRE) of 85.3% and 44.4% respectively which is higher than the NaFeEDTA. In conclusion, iron-fortified pasta is the promising food fortificant with more iron bioavailability in the prevention of iron deficiency anemia.

Keywords

Wheat Fortification Iron bioavailability Anaemic rats Haemoglobin regeneration efficiency 

Abbreviations

HRE

Haemoglobin regeneration efficiency

PIA

Percentage iron absorption

GFE

Gross food efficiency

mM

Millimolar

BU

Brabender units

FU

Farinograph units

Notes

Acknowledgements

The authors would like to express their sincere thanks for the financial support from the INSPIRE programme (IF131140), Department of Science and Technology, Government of India.

Compliance with ethical standards

Conflict of interest

The authors declare no conflict of interests.

Ethical approvel

The institutional ethical committee approved all the experimental procedures involved in the presented experiments.

References

  1. AACC, 2000 AACC (2000) American Association of Cereal Chemists. Approved methods (10th ed.). St. Paul, MinnesotaGoogle Scholar
  2. Ahmad N, Kalakoti P, Bano R, Aarif SM (2010) The prevalence of anaemia and associated factors in pregnant women in a rural Indian community. Aust Med J 3(5):276–280CrossRefGoogle Scholar
  3. Buchowski MS, Mahoney AW, Kalpalathika MP (1989) Nonheme iron absorption, apparent iron absorption and haemoglobin regeneration efficiency in anaemic and normal rats fed with dietary heme and nonheme iron at various levels. Nutr Res 9(7):773–783CrossRefGoogle Scholar
  4. Cakmak I, Yilmaz A, Kalayci M, Ekiz H, Torun B, Ereno B, Braun HJ (1996) Zinc deficiency as a critical problem in wheat production in Central Anatolia. Plant Soil 180(2):165–172CrossRefGoogle Scholar
  5. Dharmalingam A, Navaneetham K, Krishnakumar CS (2010) Nutritional status of mothers and low birth weight in India. Matern Child Health J 14(2):290–298CrossRefGoogle Scholar
  6. Eissa HA, Hussein AS, Mostafa BE (2007) Rheological properties and quality evaluation on Egyptian balady bread and biscuits supplemented with flours of ungerminated and germinated legume seeds or mushroom. Pol J Food Nutr Sci 57(4):487–496Google Scholar
  7. Gallegos-Infante JA, Rocha-Guzman NE, Gonzalez-Laredo RF, Ochoa-Martínez LA, Corzo N, Bello-Perez LA, Peralta-Alvarez LE (2010) Quality of spaghetti pasta containing Mexican common bean flour (Phaseolus vulgaris L.). Food Chem 119(4):1544–1549CrossRefGoogle Scholar
  8. Govindaraj T, KrishnaRau L, Prakash J (2007) In vitro bioavailability of iron and sensory qualities of iron-fortified wheat biscuits. Food Nutr Bull 28(3):299–306CrossRefGoogle Scholar
  9. Hallén E, İbanoğlu Ş, Ainsworth P (2004) Effect of fermented/germinated cowpea flour addition on the rheological and baking properties of wheat flour. J Food Eng 63(2):177–184CrossRefGoogle Scholar
  10. Hurrell R, Ranum P, de Pee S, Biebinger R, Hulthen L, Johnson Q, Lynch S (2010) Revised recommendations for iron fortification of wheat flour and an evaluation of the expected impact of current national wheat flour fortification programs. Food Nutr Bull 31(1):S7–S21CrossRefGoogle Scholar
  11. Kalgaonkar S, Lonnerdal B (2009) Receptor-mediated uptake of ferritin-bound iron by human intestinal Caco-2 cells. J Nutr Biochem 20(4):304–311CrossRefGoogle Scholar
  12. Kapoor R, Mehta U (1993) Iron status and growth of rats fed different dietary iron sources. Plant Foods Hum Nutr 44(1):29–34CrossRefGoogle Scholar
  13. Kloots W, Op den Kamp D, Abrahamse L (2004) In vitro iron availability from iron-fortified whole-grain wheat flour. J Agric Food Chem 52(26):8132–8136CrossRefGoogle Scholar
  14. Lobo AR, Gaievski EHS, Colli C (2011) Haemoglobin regeneration efficiency in anaemic rats: effects on bone mineral composition and biomechanical properties. Biol Trace Elem Res 143(1):403–411CrossRefGoogle Scholar
  15. Lucca P, Hurrell R, Potrykus I (2001) Genetic engineering approaches to improve the bioavailability and the level of iron in rice grains. Theor Appl Genet 102(2):392–397CrossRefGoogle Scholar
  16. Lucca P, Hurrell R, Potrykus I (2002) Fighting iron deficiency anemia with iron-rich rice. J Am Coll Nutr 21(3):184S–190SCrossRefGoogle Scholar
  17. Luten J, Crews H, Flynn A, Van Dael P, Kastenmayer P, Hurrell R, Farre R (1996) Interlaboratory trial on the determination of the in vitro iron dialysability from food. J Sci Food Agric 72(4):415–424CrossRefGoogle Scholar
  18. Martinez-Navarrete N, Camacho MM, Martınez-Lahuerta J, Martinez-Monzo J, Fito P (2002) Iron deficiency and iron fortified foods—a review. Food Res Int 35(2):225–231CrossRefGoogle Scholar
  19. Miller DD, Schricker BR, Rasmussen RR, Van Campen D (1981) An in vitro method for estimation of iron availability from meals. Am J Clin Nutr 34(10):2248–2256CrossRefGoogle Scholar
  20. Murray-Kolb LE, Takaiwa F, Goto F, Yoshihara T, Theil EC, Beard JL (2002) Transgenic rice is a source of iron for iron-depleted rats. J Nutr 132:957–960CrossRefGoogle Scholar
  21. Murray-Kolb LE, Welch R, Theil EC, Beard JL (2003) Women with low iron stores absorb iron from soybeans. Am J Clin Nutr 77(1):180–184CrossRefGoogle Scholar
  22. Muthayya S, Thankachan P, Hirve S, Amalrajan V, Thomas T, Lubree H, Kurpad AV (2012) Iron fortification of whole wheat flour reduces iron deficiency and iron deficiency anemia and increases body iron stores in Indian school-aged children–4. J Nutr 142(11):1997–2003CrossRefGoogle Scholar
  23. Prabhasankar P, Ganesan P, Bhaskar N, Hirose A, Stephen N, Gowda LR, Hosokawa M, Miyashita K (2009) Edible Japanese seaweed, wakame (Undaria pinnatifida) as an ingredient in pasta: chemical, functional and structural evaluation. Food Chem 115(2):501–508CrossRefGoogle Scholar
  24. Sachdeva B, Kaushik R, Arora S, Kapila S (2015) Bioavailability of iron in multiple fortified milk. J Food Sci Technol 52(9):6017–6023CrossRefGoogle Scholar
  25. Sekhon KS, Singh N, Kaur H, Nagi HPS (1995) Improving the functional and bread making properties of sprouted Indian wheat. J Food Process Preserv 19(2):147–160CrossRefGoogle Scholar
  26. Shaw NS, Liu YH (2000) Bioavailability of iron from purple laver (Porphyra spp.) estimated in a rat haemoglobin regeneration bioassay. J Agric Food Chem 48(5):1734–1737CrossRefGoogle Scholar
  27. Singh N, Sekhon KS, Nagi HPS (1987) Laboratory sprout damage and effect of heat treatment on milling and baking properties of Indian wheats. J Food Sci 52(1):176–179CrossRefGoogle Scholar
  28. Singh H, Singh N, Kaur L, Saxena SK (2001) Effect of sprouting conditions on functional and dynamic rheological properties of wheat. J Food Eng 47(1):23–29CrossRefGoogle Scholar
  29. Torres A, Frias J, Granito M, Vidal-Valverde C (2007) Germinated Cajanus cajan seeds as ingredients in pasta products: chemical, biological and sensory evaluation. Food Chem 101(1):202–211CrossRefGoogle Scholar
  30. Wang M, Zhou Q (2005) Single and joint toxicity of chlorimuron-ethyl, cadmium, and copper acting on wheat Triticum aestivum. Ecotoxicol Environ Saf 60(2):169–175CrossRefGoogle Scholar
  31. Whittaker P, Vanderveen JE (1990) Effect of EDTA on the bioavailability to rats of fortification iron used in Egyptian balady bread. Br J Nutr 63(3):587–595CrossRefGoogle Scholar
  32. Wolfgor R, Drago SR, Rodriguez V, Pellegrino NR, Valencia ME (2002) In vitro measurement of available iron in fortified foods. Food Res Int 35(1):85–90CrossRefGoogle Scholar
  33. Zielinska-Dawidziak M, Hertig I, Piasecka-Kwiatkowska D, Staniek H, Nowak KW, Twardowski T (2012) Study on iron availability from prepared soybean sprouts using an iron-deficient rat model. Food Chem 135(4):2622–2627CrossRefGoogle Scholar
  34. Zielinska-Dawidziak M, Hertig I, Staniek H, Piasecka-Kwiatkowska D, Nowak KW (2014a) Effect of iron status in rats on the absorption of metal ions from plant ferritin. Plant Foods Hum Nutr 69(2):101–107CrossRefGoogle Scholar
  35. Zielinska-Dawidziak M, Piasecka-Kwiatkowska D, Warchalewski JR, Makowska A, Gawlak M, Nawrot J (2014b) Sprouted wheat grain with ferritin overexpression as a potential source of iron for cereal product fortification. Eur Food Res Technol 238(5):829–835CrossRefGoogle Scholar

Copyright information

© Association of Food Scientists & Technologists (India) 2019

Authors and Affiliations

  • J. K. Naveen Kumar
    • 1
    • 2
  • S. P. Muthukumar
    • 2
    • 3
  • P. Prabhasankar
    • 1
    • 2
    Email author
  1. 1.Department of Flour Milling Baking and Confectionery TechnologyCSIR-Central Food Technological Research InstituteMysoreIndia
  2. 2.Academy of Science and Innovative Research (AcSIR)CSIR-Central Food Technological Research InstituteMysoreIndia
  3. 3.Department of BiochemistryCSIR-Central Food Technological Research InstituteMysoreIndia

Personalised recommendations