Advertisement

Environmental Earth Sciences

, 78:121 | Cite as

Elucidation of preferential elimination of Cr(VI) via bioinspired adsorbents: a comparative assessment

  • Soumya Banerjee
  • Sanghamitra Barman
  • Gopinath HalderEmail author
Original Article
  • 24 Downloads

Abstract

The present study investigates uptake of Cr(VI) from synthetic metal solution by superheated steam-activated biochar (SABC) made from roots of Colocasia esculenta and synthetic zeolite (ZRHA) prepared from rice husk ash under the influence of pH (1–7), adsorbent dose (1–100 mg/L), initial Cr(VI) concentration (5–190 mg/L), temperature (15–55 °C), agitation speed (100–170 rpm) for a contact time of 30–1440 min. ZRHA and SABC were able to remove metal ions from a stock solution of 90 and 110 mg/L of Cr(VI) with a removal of 85.89% and 94.8%, respectively. Metal ion adsorption onto zeolite ZRHA followed monolayer adsorption, whereas biochar SABC employed multilayer adsorption. Kinetic studies suggested that adsorption of Cr(VI) ions could follow both physisorption and chemisorption depending on the adsorbent used. The two-compartment dynamic model study revealed Cr(VI) adhesion followed a slow phase of adsorption which suggested intraparticle diffusion to be a prominent rate-limiting factor for both cases. The thermodynamic study claimed that Cr(VI) adsorption was a temperature dependent phenomenon. Instrumental studies by TEM, SEM, EDX and FT-IR also advocated their part on Cr(VI) removal. Also, crystallinity of both the adsorbents was determined from their XRD analysis. Thus, the current study promotes both ZRHA and SABC to be a promising adsorbent for Cr(VI) removal from contaminated aqueous solution.

Keywords

Cr(VI) contamination Adsorption Zeolite Activated biochar Intraparticle diffusion Cost estimation 

Notes

Acknowledgements

The authors convey their sincere thankfulness to the Department of Biotechnology (Govt. of India) through project no: BT/484/NE/TBP/2013, for their uninterrupted financial support towards completion of this present work. The authors with equal sincerity express their gratefulness to the Department of Chemical Engineering, National Institute of Technology for assisting with fundamental recourses required for incessant execution of the work.

References

  1. Agrawal A, Kumar V, Pandy BD (2006) Remediation options for the treatment of electroplating and leather tanning effluent containing chromium—a review. Miner Process Extract Metall Rev 27:99–130CrossRefGoogle Scholar
  2. Ahluwalia SS, Goyal D (2007) Microbial and plant derived biomass for removal of heavy metals from wastewater. Bioresour Technol 98:2243–2257CrossRefGoogle Scholar
  3. Ahmed S, Khalid N, Daud M (2002) Adsorption studies of lead minerals from aqueous media. Sep Sci Technol 37:343–362CrossRefGoogle Scholar
  4. Attia AA, Khedr SA, Elkholy SA (2011) Adsorption of chromium ion (VI) by acid activated carbon. Braz J Chem Eng 27:183–193CrossRefGoogle Scholar
  5. Babak K, Roshanak RK, Mahdi F, Amir HM, Ali E, Ali A, Ahmad RY, Allah BJ (2014) Enhanced chromium (VI) removal using activated carbon modified by zero valent iron and silver bimetallic nanoparticles. J Environ Health Sci Eng 12:1–10CrossRefGoogle Scholar
  6. Banerjee S, Joshi SR, Mandal T, Halder G (2016a) Insight into Cr6+ reduction efficiency of Rhodococcus erythropolis isolated from coalmine waste water. Chemosphere 167:269–281CrossRefGoogle Scholar
  7. Banerjee S, Mukherjee S, LaminKa-ot A, Joshi SR, Mandal T, Halder G (2016b) Biosorptive uptake of Fe2+, Cu2+ and As5+ by activated biochar derived from Colocasia esculenta: Isotherm, kinetics, thermodynamics, and cost estimation. J Adv Res 7:597–610CrossRefGoogle Scholar
  8. Banerjee S, Barman S, Halder G (2017) Sorptive elucidation of rice husk ash derived synthetic zeolite towards deionization of coalmine waste water: a comparative study. Groundw Sustain Dev 5:137–151CrossRefGoogle Scholar
  9. Barnowski C, Jakubowski N, Stuewer D, Broekaert JAC (1997) Speciation of chromium by direct coupling of ion exchange chromatography with ICP-MS. J Anal Atom Spectrom 12:1155–1161CrossRefGoogle Scholar
  10. Bhaumik M, Maity A, Srinivasu VV (2011) Onyango MS. Enhanced removal of Cr(VI) from aqueous solution using polypyrrole/Fe3O4 magnetic nanocomposite. J Hazard Mater 190:381–390CrossRefGoogle Scholar
  11. Bhavornthanayod C, Rungrojchaipon P (2009) Synthesis of zeolite a membrane from rice husk ash. J Metal Mater Miner 19:79–83Google Scholar
  12. Celik A, Demirbas A (2005) Removal of heavy metal ions from aqueous solutions via adsorption onto modified lignin from pulping wastes. Energ Source 27:1167–1177CrossRefGoogle Scholar
  13. Dai J, Ren FL, Tao CY (2012) Adsorption of Cr(VI) and speciation of Cr(VI) and Cr(III) in aqueous solutions using chemically modified chitosan. Int J Environ Res Public Health 9:1757–1770CrossRefGoogle Scholar
  14. Demiral H, Demiral I, Tumsek F, Karabacakoglu B (2008) Adsorption of chromium (VI) from aqueous solution by activated carbon derived from olive bagasse and applicability of different adsorption models. Chem Eng J 144:188–196CrossRefGoogle Scholar
  15. Ferdouse ZT, Azizul H, Sirajul H (2016) Bacterial tolerance and reduction of chromium (VI) by Bacillus cereus isolate PGBw4. Am J Environ Protect 5:35–38CrossRefGoogle Scholar
  16. Gaffer A, Kahlawy AAA, Aman D (2017) Magnetic zeolite-natural polymer composite for adsorption of chromium (VI). Egypt J Petrol.  https://doi.org/10.1016/j.ejpe.2016.12.001 CrossRefGoogle Scholar
  17. Gheju M (2011) Hexavalent chromium reduction with zero-valent iron (ZVI) in aquatic systems. Water Air Soil Pollut 222:103–148CrossRefGoogle Scholar
  18. Goyal N, Barman S, Bulasara VK (2016) Adsorptive removal of Biochanin A, an endocrine disrupting compound, from its aqueous solution by synthesized zeolite NaA. Desal Water Treat 57:1–11CrossRefGoogle Scholar
  19. Guocheng L, Li Z, Wei-The Jiang CA, Nancy F, Nick D (2014) Removal of Cr(VI) from water using Fe (II)-modified natural zeolite. Chem Eng Res 92:384–390CrossRefGoogle Scholar
  20. Gupta VK, Rastogi A, Nayak A (2010) Adsorption studies on the removal of hexavalent chromium from aqueous solution using a low-cost fertilizer industry waste material. J Colloid Interface Sci 342:135–141CrossRefGoogle Scholar
  21. Halder G, Banerjee S (2018) A review on potential reusability of industrial solid wastes as adsorbents. In: Sen T (ed) Air, gas, and water pollution control using industrial and agricultural solid wastes adsorbents. CRC Press, Boca Raton, pp 179–194Google Scholar
  22. Halder G, Sinha K, Dhawane S (2015) Defluoridation of wastewater using powdered activated carbon developed from Eichornia crassipes stem: optimization by response surface methodology. Desal Water Treat 56:953–966CrossRefGoogle Scholar
  23. Horsfall Jnr M, Spiff AI (2005) Effects of temperature on the sorption of Pb2+ and Cd2+ from aqueous solution by Caladium bicolor (Wild Cocoyam) biomass. Electron J Biotechnol 8:162–169CrossRefGoogle Scholar
  24. Ibrahim MNM, Ngah WSW, Norliyana MS, Daud WRW, Rafatullah M, Sulaiman O, Hashim R (2010) A novel agricultural waste adsorbent for the removal of lead (II) ions from aqueous solutions. J Hazard Mater 182:357–365Google Scholar
  25. Igwe JC, Abia AA (2007) Equilibrium sorption isotherm studies of Cd(II), Pb(II) and Zn(II) ions detoxification from waste water using unmodified and EDTA-modified maize husk. Electron J Biotechnol 4:536–548Google Scholar
  26. Jyotikusum A, Sahu JN, Sahoo BK, Mohanty CR, Meikap BC (2009) Removal of chromium (VI) from wastewater by activated carbon developed from Tamarind wood activated with zinc chloride. Chem Eng J 150:25–39CrossRefGoogle Scholar
  27. Kobya M (2004) Removal of Cr (VI) from aqueous solutions by adsorption onto hazelnut shell activated carbon: kinetic and equilibrium studies. Bioresour Technol 91:317–321CrossRefGoogle Scholar
  28. Lesmana SO, Febriana N, Soetaredjo FE, Sunarso J, Ismadji S (2009) Studies on potential applications of biomass for the separation of heavy metals from water and wastewater. Biochem Eng J 44:19–41CrossRefGoogle Scholar
  29. Leyva-Ramos R, Jacobo-Azuara A, Diaz-Flores PE, Guerrero-Coronado RM, Mendoza-Barron J, Berber-Mendoza MS (2008) Adsorption of chromium (VI) from an aqueous solution on a surfactant-modified zeolite. Colloid Surf A Physicochem Eng Aspect 330:35–41CrossRefGoogle Scholar
  30. Liang-qi L, Ci-an S, Xiang-li X, Yan-hong L, Fei W (2010) Acid mine drainage and heavy metal contamination in groundwater of metal sulfide mine at arid territory (BS mine, Western Australia). Trans Nonferrous Met Soc China 20:1488–1493CrossRefGoogle Scholar
  31. Lva G, Li Z, Wei-Teh J, Ackley C, Fenske N, Demarco N (2014) Removal of Cr(VI) from water using Fe(II)-modified natural zeolite. Chem Eng Res Des 92:384–390CrossRefGoogle Scholar
  32. Mohamed RM, Mkhalid IA, Barakat MA (2015) Rice husk ash as a renewable source for the production of zeolite NaY and its characterization. Arabian J Chem 8:48–53CrossRefGoogle Scholar
  33. Mondal S, Aikat K, Halder G (2016) Biosorptive uptake of ibuprofen by chemically modified Parthenium hysterophorus derived biochar: equilibrium, kinetics, thermodynamics and modelling. Ecol Eng 92:158–172CrossRefGoogle Scholar
  34. Mthombeni NH, Onyango MS, Aoyi O (2015) Adsorption of hexavalent chromium onto magnetic natural zeolite-polymer composite. J Taiwan Inst Chem Eng 50:242–251CrossRefGoogle Scholar
  35. Mulligan CN, Yong RN, Gibbs BF (2001) Remediation technologies for metal-contaminated soils and groundwater: an evaluation. Eng Geo 60:193–207CrossRefGoogle Scholar
  36. Nicolas K, Sayoubo S, Ousmane B, Prosper Z, Rosa G (2014) Acid mine drainage and heavy metals contamination of surface water and soil in southwest Burkina Faso–West Africa. Inter J Multidis Aca Res 2:9–19Google Scholar
  37. Ofomaja AE (2010) Intraparticle diffusion process for lead (II) biosorption onto mansonia wood sawdust. Bioresour Technol 101:5868–5876CrossRefGoogle Scholar
  38. Owlad M, Aroua MK, Ashri W, Daud W, Baroutian S (2009) Removal of hexavalent chromium-contaminated water and wastewater: a review. Water Air Soil Pollut 200:59–77CrossRefGoogle Scholar
  39. Panpa W, Jinawath S (2009) Synthesis of ZSM-5 zeolite and silicate from rice husk ash. Appl Catal B 90:389–394CrossRefGoogle Scholar
  40. Parikh J, Channiwala SA, Ghoshal GK (2007) A correlation for calculating elemental composition from proximate analysis of biomass materials. Fuel 86:1710–1719CrossRefGoogle Scholar
  41. Ravindran V, Stevens MR, Badriyha BN, Pirbazari M (1999) Modeling the sorption of toxic metals on chelant impregnated adsorbent. AIChE J 45:1135–1146CrossRefGoogle Scholar
  42. Ren WX, Li PJ, Geng Y, Li XJ (2009) Biological leaching of heavy metals from a contaminated soil by Aspergillus niger. J Hazard Mater 167:164–169CrossRefGoogle Scholar
  43. Schneider IAH, Rubio J (1999) Sorption of heavy metal ions by the non-living biomass of freshwater macrophytes. Environ Sci Technol 33:2213–2217CrossRefGoogle Scholar
  44. Shawabkeh RA (2006) Adsorption of chromium ions from aqueous solution by using activated carbo-aluminosilicate material from oil shale. J Colloid Interface Sci 299:530–536CrossRefGoogle Scholar
  45. Sivakumar D (2016) Biosorption of hexavalent chromium in a tannery industry waste water using fungi species. Global J Environ Sci Manag 2:105–124Google Scholar
  46. Volesky B, Holan ZR (1995) Biosorption of heavy metals. Biotechnol Prog 11:235–250CrossRefGoogle Scholar
  47. Wilde EW, Benemann JR (1993) Bioremoval of heavy metals by the use of microalgae. Biotechnol Adv 11:781–812CrossRefGoogle Scholar
  48. Wu FC, Tseng RL, Juang RS (2009) Characteristics of Elovich equation used for the analysis of adsorption kinetics in dye-chitosan systems. Chem Eng J 150:366–373CrossRefGoogle Scholar
  49. Wua FC, Tseng RL, Juang RS (2009) Characteristics of Elovich equation used for the analysis of adsorption kinetics in dye-chitosan systems. Chem Eng J 150:366–373CrossRefGoogle Scholar
  50. Yang J, Yu M, Qiu T (2014) Adsorption thermodynamics and kinetics of Cr(VI) on KIP210 resin. J Ind Eng Chem 20:480–486CrossRefGoogle Scholar
  51. Yuksel O, Sevgi K (2007) Adsorption of toxic metals by natural and modified clinoptilolite. Annali di Chimica 97:781–790CrossRefGoogle Scholar
  52. Yusof AM, Nizam NA, Malek N (2009) Removal of Cr(VI) and As(V) from aqueous solutions by HDTMA-modified zeolite Y. J Hazard Mater 162:1019–1024CrossRefGoogle Scholar
  53. Zhou L, Liu Y, Liu S, Yin Y, Zeng G, Tan X, Xi Hu, Hu X, Jiang L, Ding Y, Liu S, Huang X (2016) Investigation of the adsorption-reduction mechanisms of hexavalent chromium by ramie biochars of different pyrolytic temperatures. Bioresour Technol 218:351–359CrossRefGoogle Scholar

Copyright information

© Springer-Verlag GmbH Germany, part of Springer Nature 2019

Authors and Affiliations

  • Soumya Banerjee
    • 1
  • Sanghamitra Barman
    • 2
  • Gopinath Halder
    • 1
    Email author
  1. 1.Department of Chemical EngineeringNational Institute of TechnologyDurgapurIndia
  2. 2.Department of Chemical EngineeringThapar Institute of Engineering and TechnologyPatialaIndia

Personalised recommendations